2022 Hyundai Palisade: excessive oil consumption

Filed Oct 16, 2026 · Engine, Transmission · WA

The vehicle experienced severe engine stalling and critically low oil levels that were officially documented by an authorized dealership well before 100,000 miles (at approximately 79,000 miles). Because this pre-existing condition remained unresolved under warranty, the engine ultimately failed and required a complete replacement at approximately 103,000 miles. Just 7,000 miles later, at 110,000 miles, the automatic transmission suffered a critical failure. The transmission severely shudders, spikes to excessively high RPMs, and refuses to shift properly through lower gears (gears 1 to 3). This causes sudden hesitation, loss of motive power, and violent jerking when accelerating and merging into active traffic, creating an imminent crash hazard. The manufacturer has refused repair assistance despite cascading powertrain defects that originated prior to 100,000 miles.

Filed Jul 13, 2026 · Driver assistance, Engine · FL

I own a 2022 Hyundai Palisade SEL. On XXX, while driving at the intersection of [XXX] and [XXX] in [XXX], the engine abruptly lost power, causing a sudden loss of engine power while the vehicle was in motion. This is my family's primary vehicle, and my wife and children were in the car during this incident. On XXX, I brought the vehicle to Courtesy Hyundai in [XXX]. The dealer found essentially no oil in the engine despite my keeping up with scheduled oil changes. The dealer replaced the oil and performed a software update described on the repair order as "9C9 C ECU SW UPDATE EMISSIONS IMPRV 26-01-010H," and I was instructed to return after 1,000 miles for an oil-level recheck. At that recheck, the dealer's service assistant reported the oil was full. On XXX, before a planned family road trip, I returned the vehicle for another check. The service department found the engine was two quarts low — this was only 4,000 miles after the oil service on April 10, 2026. The dealer stated they requested an oil consumption test but that Hyundai denied the request. Per the dealer's instructions, I returned again after another 1,000 miles, and the engine was one quart low. I am filing this complaint because I believe the excessive oil consumption and the resulting loss of engine power represent a safety defect that has not been remedied. An engine that abruptly loses power while driving creates a serious hazard, including loss of power steering and reduced braking assist, and I am concerned for my family's safety while this condition remains unresolved. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 1, 2026 · Engine · TN

My 2022 Hyundai Palisade recently blew the engine due to very little oil (6 quarts). My wife stated that she was driving when it started to act weird. Very shortly after that she heard the vehicle making a loud knocking / banging sound. She stopped the vehicle and turned it off in the nearest parking lot. We had the vehicle towed to our certified mechanic to have it looked at. 6 quarts of oil was put into the engine before it was full. Both him and my wife stated the vehicle never showed a check engine light, low oil light or oil pressure problems. He stated the vehicle had no leaks. He advised us that Hyundai/Kia was having problems burning oil. This is a high risk and safety concerns since there was no warning, happened suddenly and could cause problems for people to find a safe place to pull off the roadway and interstate. So many things can happen if someone didn't hear the noise or have lights indicating a problem, therefor if this happened on the interstate people could struggle getting to the shoulder when engine locks up. Also, a piston or connecting rod can be ejected from an engine risking the safety of pedestrians on foot or driving down the road.

Filed May 21, 2026 · Engine, Fuel system · GA

purchased a vehicle that has experienced ongoing mechanical and safety-related defects, including excessive oil consumption, seat belt malfunctions, and unresolved injector recall issues. Despite multiple repair attempts by the dealership, the problems continue to persist and have not been permanently corrected. These defects substantially affect the vehicle’s safety, reliability, value, and everyday use. The dealership and manufacturer represented the vehicle as reliable and safe; however, the repeated failures and unresolved recalls suggest otherwise. I believe it is misleading to continue selling or servicing vehicles with known defects that cannot be properly repaired. I have also learned that certain model years are no longer sold due to widespread malfunctioning issues that are costly for consumers to repair, yet I was not informed of these concerns at the time of purchase. I have made several attempts to resolve this matter by bringing the vehicle to the dealership for repairs, reporting the recurring issues, and complying with recommended service appointments. Despite these efforts, the defects remain unresolved, causing financial hardship, inconvenience, and concerns for my safety.

Filed Apr 29, 2026 · Engine · IL

The engine has been burning oil since last May and Hyundai has been putting me through the ringer of hoops to get it fixed. After 11 months and almost 30 visits to the dealership, they are finally replacing the engine. The dealership has told me this is a known issue and I know of others who have the same car and are having the same issue. Someone needs to hold them responsible.

Filed Apr 24, 2026 · Engine · MI

- Engine leaking oil / burning oil - vehicle stuttered while turning left - can lead to sudden breakdown or stalling - dealer performed warranty repair of oil pan and oil filter housing in February. 2 months later, no oil on dipstick. Dealer reports this is a common issue. - manufacturer states one quart of oil lost every 1000 miles is acceptable. Car holds 6 quarts of oil. Dealership oil change is once every 6000 miles. Engine will be out of oil before next oil change is due - car is at dealer with no loaner available. Hyundai corporate contacted and they say this is very common and oil consumption test is next step. In the meantime, no car for us. - Vehicle still has 28000 miles under warranty. A simple internet search will show this is an extremely common issue with no fix. - Life of engine, value of car, peace of mind, safety of occupants are all a concern

Filed Apr 21, 2026 · Engine, Transmission · NC

This same incident has happened twice, June of 2025 and more recently March of 2026. My vehicle will essentially have no oil left causing my car to shake while breaking and eventually the car stalls out. The first time this occurred, my vehicle stalled out in the highway and again at a 4 way stop sign. I took it to the Hyundai dealership where an oil change, oil plug and oil filter was replaced. In December of 2025, I noticed oil leaking from my vehicle, where the oil house filter was deemed the issue and was replaced. March of 2026, my car started to shake and eventually stall out again and this prompted me to check my oil levels where there was little to no oil. An oil consumption test was performed and it was noted my car is consuming 0.5 quarts of oil per 1,000 miles. Per Hyundai, this does not meet the oil consumption warranty (1 quart per 1,000 miles) and there is nothing to do for this issue at this time. My concerns are that this issue arises prior to my next recommended oil change. Also, there are no warning signs that prompt me that my oil is actually low; no dashboard warnings or notifications. I really only know this problem is occurring when my vehicle physically shows signs while I am driving. I am frustrated with this as I have to refill oil in between oil changes but also pay for the oil changes. Also, it worries me for the safety of my family while we are driving this vehicle.

Filed Jan 28, 2026 · Engine · 75,000 miles · IL

The contact owns a 2022 Hyundai Palisade. The contact stated while driving approximately 30 MPH, the vehicle shuddered and jerked significantly. The check engine warning light was illuminated. Additionally, a message advising of an unknown error was displayed. The contact stated that the check engine warning light started flashing. The vehicle was taken to the dealer several times, and the dealer performed approximately four oil consumption tests and determined that the engine needed to be replaced. The dealer replaced the engine; however, the engine failures persisted. The contact stated that the vehicle jerked while driving. The vehicle was taken to the dealer, where the failure was related to the cold weather. The dealer replaced the spark plugs; however, the jerking failure increased while driving, and the vehicle felt as if the vehicle was going to stall. Additionally, the vehicle was experiencing excessive coolant consumption. The contact stated the message "Engine Overheating" was displayed while driving. The vehicle was pulled over to the side of the road for an hour, and coolant was added to the coolant reservoir. The vehicle was driven to the dealer at slow speeds on the expressway, but the dealer informed the contact that the vehicle could not be serviced, and the contact was advised that the vehicle could be driven to the residence because coolant was added to the vehicle. The vehicle was driven and parked at the residence. The vehicle was not repaired. The manufacturer was notified of the failure, and the contact was awaiting a call back. The failure mileage was approximately 75,000.

Filed Jan 22, 2026 · Engine, Fuel system · NC

Since purchasing the vehicle brand new in Oct 2021, all recommended services have been executed on time. (records to prove it can be provided if required) Aug 25, 2025. Mileage = 78,247. Full preventative maintenance including GDI Fuel Service and Oil change Nov 21, 2025. Mileage = 85,421. I am on a 2 hour commute home and the engine is stalling at every stop. Needs to be re-started each time. Pinging noise when accelerating. The car is brought into Parkway Hyundai in Wilmington, NC. Oil was below dipstick. This lack of oil causes the engine to misfire. I asked why the "low oil" light doesn't appear. I am told that he didn't know but the light only goes on when its completely out of oil. That doesn't seem safe at all. At this point, I am told by Service agent that this is a known problem with Hyundai and the recommend bringing the vehicle in for oil checks every 1,000 miles Dec 15, 2025. Mileage = 86,597. Oil check - Engine 0.4 quarts low after 1,000 miles. I am told it is "within Hyundai's range of acceptance Jan 2, 2025. Mileage = 88,463. Oil check - Engine 1.4 qts low after 2,000 miles. I am told 0.75 quarts every 1,000 miles is within the accepted range. Jan 22, 2025. Mileage = 89,487. Oil check - Engine 0.9 qts low after 1,000 miles. I am told 0.9 qts is within Hyundai's accepted range. This is unacceptable for a car to burn almost a quart of oil every 1,000 miles.

Filed Dec 8, 2025 · Engine · OH

The engine is burning oil at a rate that is unreasonable. When the oil level is low, there is no oil light indicator to show that the car is low on oil. My safety is being put at risk because the engine could seize up at any moment and may have slow or no acceleration. I caught the low oil problem just in time because i have a child who was aware of what the issue was with the car. I have had normal oil changes. This is a known issue in Hyundai's and these vehicles need to be repaired/replaced. The care will be inspected by a Hyundai dealership.

Filed Nov 18, 2025 · Engine · MD

After my 2022 Palisade Calligraphy with 95K miles stalled several times in intersections and ran rough, dealership said I was 4 quarts of oil low. Dealership recommended an oil consumption test and vehicle burns 1 quart every 568 miles. Hyundai denied my claim under their 100K power train warranty since I was 2nd owner, and they did not make a good will offer. After researching, it appears oil consumption is a common problem with Hyundai vehicles, specifically the Palisade. Aftermarket warranty I purchased denied my claim since it didn't cover oil consumption. Submitting this incident so others are aware of oil consumption issues with Hyundai vehicles as vehicle is unsafe when it stalls.

Filed Jul 26, 2024 · Engine, Fuel system · TX

In April 2022, we purchased a new 2022 Hyundai Palisade from a dealership due to persistent issues with our previous Hyundai Santa Fe, which had ongoing engine problems and recalls. After multiple unsuccessful repairs and software updates on the Santa Fe, we decided to trade it in for the Palisade. Since the purchase, the Palisade has undergone over ten warranty-related repairs. In early 2023, an oil consumption test revealed significant warranty concerns, leading the dealership to keep the vehicle for additional diagnostics. This process lasted nine months and included a full engine replacement. During this time, my husband filed a complaint with Hyundai Corporate, seeking a lemon law buyback or an equivalent trade-in. Hyundai Corporate denied our request, stating that we did not qualify under the lemon law and refusing to buy back or offer a fair trade-in for the vehicle. In June 2024, after nearly a year of repairs, we retrieved the vehicle, only to experience severe issues shortly afterward. The Palisade began jerking and shaking on the highway, and the check engine light came on. The dealership identified a faulty mass air flow sensor and ordered parts for its repair. They assured us it was safe to drive until the repair was completed. However, the next day, the vehicle displayed the same issues. A diagnostic at Auto Zone revealed problems with both the air flow sensor and the fuel injector, indicating unsafe driving conditions. We returned the vehicle to Hyundai College Station, where we received a loaner car while they conducted repairs. During this period, we were informed of a "computer digital data hack" that prevented the dealership from providing documentation of the services performed. When we picked up the Palisade, we were told that only the mass air flow sensor had been repaired, with no work done on the fuel injector or other issues. Currently our vehicle exhibited engine defaults and the engine light came on. It is at Principle Hyundai for repairs