2021 Hyundai Palisade: excessive oil consumption

Filed Oct 20, 2026 · Engine, Transmission · CA

I am the original owner of a 2021 Hyundai Palisade SEL AWD (74,225 miles) reporting repeated engine shutdowns in traffic, severe rough idling, and an unresolved safety concern. The problem began XXX. I first brought the vehicle to Hyundai on XXX and have sought service approximately four times since June. Despite technicians stating they could not reproduce the issue, the engine stalled again on XXX after I picked it up from service. The dealership also instructed me to complete a 1,000-mile oil consumption test. When I returned after 750 miles, I was told I had returned too early. The engine subsequently shut off twice on XXX. Documented incidents: XXX 1:53 PM: Engine shut off on [XXX]. XXX, 5:38 PM: Engine shut off on [XXX]. XXX, 5:08 AM: Engine shut off at [XXX] exit, [XXX] XXX 11:35 AM: Engine stalled at [XXX]/[XXX]. XXX, 12:30 PM: Engine stalled at [XXX]/[XXX]; check engine light illuminated. XXX, 10:57 AM: Near-stall with severe rough idling at Los Gatos Farmers Market. After further rough idling, the check engine light remained illuminated. On XXX the dealership service advisor personally experienced severe rough idling and an apparent near-stall while moving my vehicle, with the check engine light on. I heard her acknowledge the issue. The vehicle remains at the dealership. I provided a written incident log and opened Hyundai case #XXX. Repeated engine shutdowns at intersections and freeway exits pose a serious collision risk. I request the federal safety agency investigate this potential safety defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 9, 2026 · Engine, Fuel system · OH

Due to a known oil consumption issue the manufacture replaced the engine using a short block swap, they used the old fuel injectors and during the swap one of them failed, becoming stuck open. Now they refuse to fix it without me paying for labor. The failed fuel injector occurred immediately following a mandatory manufacturer engine replacement and poses a thermal/fire hazard.

Filed Sep 25, 2026 · Engine · IL

Whatever you do, do not purchase a Hyundai vehicle. Their engines are defective. On XXX, I brought my car in for service at Castle Hyundai, [XXX]. I informed the service representative that I was having issues with my car stopping and automatically applying the braking system intermittently. They looked at the car and said they saw nothing was wrong. They charged me $940.30 for diagnostics and replacing a couple of belts and oil filter housing leak. I started having the same issue in XXX and I brought my car in again. This time they told me that my car was burning oil internally and that I would have to have a Combustion Chamber Cleaning. I was informed by the Service Manager that this was a common problem with my vehicles model year and that if was a requirement to for the Warranty people to initiate changing the engine. I paid $1,094.26 for this service. I was told to bring the car back after driving the car an additional 1,000 miles. I was also told by that service manager that his dealership changes about 200 engines a month due to this issue. I took the car back to the dealership after driving the 1,000 miles. I sent them photos of the 3 oil changes I could find documentation for, and I had one done at this dealership. I was informed by the dealership that the warranty company and Hyundai when asked, refused my claim. I called the warranty company myself and they would not uphold my claim. I then contacted the Regional Case Manager, and they tried to tell me something different. They told me my car was over warranty and that the engine was only covered up to 60,000 miles. I have the Warranty in my hand, and it says lifetime warranty. This is not fair. I am [XXX] old and I bought the car with 31,000 miles on the car. I have consistent and periodic oil changes but could not remember all the places. This is the first Hyundai I have purchased and I am asking that my claim be upheld and executed s INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 23, 2026 · Engine · WA

I have been dealing with the oil consumption issues for this vehicle for about 2 years now. There are documented complaints and a class action lawsuit in California about this issue. Bottom line, the engine burns too much oil to be safely driven between oil changes without the owner checking and adding oil. My particular vehicle is burning just under 1 quart of oil per 1000 miles. Hyundai’s owner manual suggests changing the oil every 7,500 miles, but the oil capacity is under 6 quarts. At the current rate, I would run out of oil before the suggested oil change interval. This is a severe safety issue as engines require oil to run correctly, not overheat, and lubricate all the moving parts. The previous generation Hyundai models also had similar oil consumption issues. Those vehicles had a the federal safety agency campaign which resulted in Hyundai being responsible to fix the engines. I believe a recall is proper given the safety concerns noted above. At a minimum, Hyundai should stand by their work and fix the issues as they arise.

Filed Sep 1, 2026 · Electrical, Engine · IL

I am reporting a potential safety defect involving my 2021 Hyundai Palisade Calligraphy AWD. The vehicle has experienced repeated engine and drivability problems and multiple breakdowns following replacement of the engine by Hyundai. The original engine developed excessive oil consumption and was ultimately replaced by Hyundai with a new engine. Following the engine replacement, the vehicle experienced numerous additional mechanical problems and repair attempts, including engine rattling/pinging, intake-manifold replacement, oil valve-seal replacement, multiple cylinder misfires, ignition-system problems and an ignition-coil failure. Most concerning are repeated incidents involving severe shaking/lurching, loss of engine power, stalling and failure to restart. During one incident following repairs, the vehicle ran extremely rough, stalled and would not restart after approximately 20 miles of driving and had to be towed back to the dealership. During another incident, the vehicle experienced heavy shaking on startup, stalled and had severely limited power. Diagnostic history showed misfires involving multiple cylinders. On June 29, 2026, at approximately 103,671 miles, I was driving at approximately 50 mph when the vehicle began to lurch and shake, lost power, stalled and would not restart. The vehicle had to be towed back to the Hyundai dealership. The unexpected loss of propulsion and stalling while traveling at approximately 50 mph created a serious safety concern because I could no longer rely upon the vehicle to maintain power in traffic. The dealership subsequently identified an ignition-coil short/failure and replaced an ignition coil. The vehicle has nevertheless continued to experience additional mechanical problems. The vehicle is currently again at the Hyundai dealership. It has generated diagnostic code P0430 for Bank 2 catalyst efficiency below threshold, and Hyundai has recommended replacement of both catalytic converter/manifold assemblies. Th

Filed Aug 19, 2026 · Engine · OH

In the past two weeks, our 2021 Hyundai Palisade has shut off completely when driving. It has around 110,000 miles on it and was just purchased used (second owner) three months ago. At that time, the dealership had to fix a leak in the engine and did a complete oil change. Based on internet searches, we just checked the oil dipstick and it is COMPLETELY empty. We have NOT driven more than 3,000 miles since purchasing the vehicle and there is absolutely no oil left. Based on searches, it appears this is a fairly common, known issue and nothing is being done. It is incredibly dangerous that the car shut down while driving (on the highway, in the middle of a right-hand turn). Every single warning light lit up at once then the car completely shut off within a matter of seconds. Thankfully my husband was able to get to the side of the road and no accidents occurred, but this is terrifying and completely unacceptable. The car is going to be towed to the dealership to check for excessive oil consumption, but again, based on research, it appears that this is a known issue but Hyundai says it is "within acceptable limits." PLEASE DO SOMETHING ABOUT THIS BEFORE SOMEONE IS SERIOUSLY INJURED OR KILLED.

Filed Aug 11, 2026 · Engine · CA

I had an oil change in Feb 2026 at 64000 miles. In June, I was driving the car and suddenly the car started jolting while I was idle and would turn off completely when I was stopped. This happened to me while driving on the freeway in traffic and also at a traffic light. I immediately went to the dealership and was told my car had no oil in it. Since the oil change I drove about 5900 miles. I was told there were no leaks so the issue was either the engine or that when I had the oil changed that they forgot to put the oil in. They advised to get an oil test. I drove 1000 miles and took the car back in today 8/11. I had the oil tested and I burned .4 quarts in the 1000 miles which was under the standards of 1 quart per 1000 miles in order to get the issue fixed. I was told that I needed to check my oil and add oil to the car when needed. I left the dealership confused because I have had this car for over a year and never had an issue with the oil or oil levels. I never had any oil indicator on my dashboard to alert me of any issue. I called back the advisor asking more questions because I did not understand how my car burned through so much oil that it was malfunctioning. After being talked to like an idiot about how it is my responsibility to make sure my car has oil, I was finally told that this palisade has a known issue for premature oil consumption once it hits 60000 miles. Then I was told there is no recall and the issue will only get worse and I have to wait till it hits 1 quart of oil burned in 1000 miles for anything to be done. I feel like this is extremely irresponsible of the company to know this issue exists with nothing being done or communicated to their customers and that it is a huge safety concern to not have any indication there is something wrong with the oil amount and my car could literally stop in the middle of the freeway. They are waiting to make the issue neglect from the customer so they are not held responsible for their vehicle's issue.

Filed Aug 9, 2026 · Transmission · IN

My Palisade is burning oil at a rapid pace. I took it to the dealership and they said it was an acceptable level. I don't believe that to be correct. I have less than 100,000 miles on it.

Filed Jul 29, 2026 · Engine · OH

Excessive oil consumption. Oil tank empty at 3 oil changes. Car was stalling at stops. Oil was empty 5000 miles prior to next suggested oil change. No low oil indicator light alarm

Filed Jul 27, 2026 · Engine, Transmission · NY

In May 2025, I contacted Hyundai regarding excessive oil consumption in my 2021 Palisade. In June, Hyundai directed me to take the vehicle to a dealership for testing. Under TSB 23-EM-008H ([XXX]), a failed oil consumption test requires engine replacement. My vehicle is covered under Hyundai’s 10-year/100,000-mile powertrain warranty. I have provided complete maintenance records and receipts for every oil change since purchasing the vehicle. Despite this, Hyundai has repeatedly denied my claim, citing maintenance issues and gross negligence without justification. Hyundai’s own guidance states that oil changes may be performed every 7,000 to 10,000 miles under normal conditions. The repeated testing process has worsened the engine condition. In addition, the dealership has returned the vehicle with missing bolts, oil-related issues, and damage resulting from an improper rear window film installation. I have made numerous attempts to resolve this matter and obtain the warranty coverage to which I am entitled, but Hyundai and the dealership have failed to do so. I am requesting one of the following remedies: (1) a full engine replacement in accordance with the warranty and TSB requirements, (2) a replacement vehicle of equal or greater trim level, or (3) reimbursement of all costs associated with leasing, purchasing, maintaining, and repairing this vehicle. We purchased this vehicle based on Hyundai’s reputation, ratings, and promise of “America’s Best Warranty.” We still like the vehicle itself, but the ongoing mechanical issues and Hyundai’s handling of this claim have been unacceptable. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 28, 2026 · Engine · TN

My Hyundai Palisade was bought brand new in 2020. It currently has 131,500 miles on it. I noticed at around 110,000 miles that my oil was getting low before each oil change. I check my oil frequently. No oil leaks can be found. So the engine is burning oil somehow. My mechanic says Hyundai says its acceptable for it to burn oil after 100,000 miles but 2 quarts between oil changes seems excessive. Ive talked to other Palisade owners who have this year model and have the same issue. If I were not a responsible consumer and checked my oil as frequently as I do then its very possible another consumer could have burned their engine up before they knew what was happening because there is no leak just burning of the oil. This is very dangerous.

Filed Apr 22, 2026 · Electrical, Engine · TX

The engine oil system failed due to a persistent oil leak that was present from the time of purchase on December 16th 2024. The vehicle is available for inspection upon request and is currently immobile due to a completely seized engine. My safety was put at serious risk because the vehicle has no functioning low oil warning indicator to alert the driver of critically low oil levels. I was driving this vehicle regularly for work with no indication whatsoever that the engine was losing oil. A seized engine can cause sudden and complete loss of vehicle control which puts not only the driver but other drivers and pedestrians at risk. This failure occurred without any warning while the vehicle was in regular use. The oil leak was brought to the selling dealership, Auto Merchants Inc. in Plano Texas, for repair on January 6th 2026. They kept the vehicle overnight and confirmed it was fixed. The problem was not resolved as the vehicle continued losing oil. On March 3rd 2026 I discovered the engine was completely empty and added 6 full quarts of oil with no warning light appearing. I also contacted Hyundai consumer affairs and the Hyundai dealership directly who confirmed the manufacturer warranty had already expired at the time of purchase on December 16th 2024 and declined to cover the repair. The vehicle has not yet been formally inspected by the manufacturer or insurance representatives. The dealership serviced it on January 6th 2026 and claimed the leak was repaired however the engine seized on April 20th 2026 due to continued oil loss. There were zero warning lamps or indicators of any kind prior to the engine seizing completely on April 20th 2026. No low oil warning light appeared at any point during the 4 months I owned this vehicle despite the engine running completely out of oil on three separate occasions. The only symptom prior to full engine seizure was the vehicle sputtering when coming to a stop on April 19th 2026, one day before the engine seized completely