Hyundai Palisade check engine light comes on

Filed Nov 8, 2026 · Engine · FL

I am filing an immediate safety complaint regarding a severe engine defect on my vehicle and the manufacturer's dangerous diagnostic protocol. The vehicle is experiencing active engine failure symptoms, including [insert symptoms here, e.g., severe knocking, sudden hesitation, intermittent stalling, or a flashing check engine light]. I have clear video evidence of the failure, and the dealership's Shop Foreman inspected the vehicle and diagnosed it with an internal engine problem. Despite a formal diagnosis from their own Shop Foreman and video proof of the failure, Hyundai Techline is attempting to deflect liability by blaming a previously installed aftermarket oil filter. The dealership has since replaced the aftermarket filter with an OEM filter. However, instead of repairing the diagnosed internal engine defect, they are forcing me to drive this malfunctioning vehicle for an additional 1,000 miles to "duplicate" the issue. Operating a vehicle with a known, documented internal engine failure on public roads poses an immediate and severe safety hazard to myself, my kids, and other drivers. The vehicle is at imminent risk of sudden engine stalling, complete power loss, or catastrophic mechanical seizure at highway speeds, which could cause a serious collision. The manufacturer is actively demanding that I operate a dangerous vehicle as a condition of their warranty process, shifting extreme physical liability onto the consumer.

Filed Oct 28, 2026 · Engine, Fuel system · FL

• Noticed a rattle sound when taking off and when the car was preparing to stop; All timely maintenance were done at Headquarter Hyundai in [XXX]. Oil change was done by Tires Plus ([XXX]) end of XXX as the car was just over 100k miles, so no warranty. • XXX, notice the rattle sound and notice the engine tremble when stopping. Returned to Tire Plus for diagnostic. XXX - TECH NOTED NO OIL ON DIPSTICK UPON ARRIVAL. CUSTOMER ADVISED TO DO OIL CHANGES MORE FREQUENTLY AT 3,000 MILE INTERVALS; NO VISIBLE OIL LEAKS AT THIS TIME - INTERNAL ENGINE OIL CONSUMPTION. POTENTIAL PISTON RING OR ENGINE BEARING ISSUE CAUSING OIL CONSUMPTION. COMPUTERIZED ENGINE ANALYSIS. • My safety was at risk when the oil notification failed to occur, when the check engine notification failed to occur. These failures could have resulted in a complete shut down of the engine resulting in an immediate collision as I travel on the interstate daily for work. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 20, 2026 · Engine, Transmission · CA

I am the original owner of a 2021 Hyundai Palisade SEL AWD (74,225 miles) reporting repeated engine shutdowns in traffic, severe rough idling, and an unresolved safety concern. The problem began XXX. I first brought the vehicle to Hyundai on XXX and have sought service approximately four times since June. Despite technicians stating they could not reproduce the issue, the engine stalled again on XXX after I picked it up from service. The dealership also instructed me to complete a 1,000-mile oil consumption test. When I returned after 750 miles, I was told I had returned too early. The engine subsequently shut off twice on XXX. Documented incidents: XXX 1:53 PM: Engine shut off on [XXX]. XXX, 5:38 PM: Engine shut off on [XXX]. XXX, 5:08 AM: Engine shut off at [XXX] exit, [XXX] XXX 11:35 AM: Engine stalled at [XXX]/[XXX]. XXX, 12:30 PM: Engine stalled at [XXX]/[XXX]; check engine light illuminated. XXX, 10:57 AM: Near-stall with severe rough idling at Los Gatos Farmers Market. After further rough idling, the check engine light remained illuminated. On XXX the dealership service advisor personally experienced severe rough idling and an apparent near-stall while moving my vehicle, with the check engine light on. I heard her acknowledge the issue. The vehicle remains at the dealership. I provided a written incident log and opened Hyundai case #XXX. Repeated engine shutdowns at intersections and freeway exits pose a serious collision risk. I request the federal safety agency investigate this potential safety defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 12, 2026 · Engine, Fuel system · CO

The engine misfires and runs very rough when stopped in drive after highway driving, and the vehicle hesitates and struggles to accelerate from a stop. At about 3,000 miles, Phil Long, Colorado Springs diagnosed a failing cylinder 6 fuel injector and replaced it on 22 April 2025. The problem continues after that repair. The condition repeats in the same way. After 15 minutes to 1 hour of interstate driving, I exit the highway. When I stop at the first traffic light on the off ramp, the engine begins idling very rough, and the tachometer shows about 500 RPM. When I shift to park, the idle smooths out. When I shift back to drive, it becomes very rough again. Pulling away from the light is difficult because the vehicle hesitates and does not accelerate normally. This has happened three times since the repair, most recently on [XXX] at about 5,800 miles. The check engine light did not come on. Conditions: 80 F, clear weather. [XXX] exit [XXX]. This is a safety concern because the vehicle may not accelerate when I pull into an intersection or merge into traffic. Other 2026 Palisade owners have reported similar misfires and hesitation, and Hyundai issued TSB 26-01-068H (Service Campaign 9D6) for engine misfires on 2026 Palisade 3.5L vehicles. I have asked Hyundai to confirm whether this campaign has been performed on my vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 11, 2026 · MN · fire

Car smelt bad, drove down the road and check engine light came on. Pulled over and car was smoking under hood,turned off. Let it cool off, started car and thicker smoke happened under hood and it lit on fire. Car started on fire.

Filed Oct 5, 2026 · Engine · GA

My 2020 Hyundai Palisade (3.8L V6) suffered an engine failure at approximately 108,000 miles. On September 3rd,2026 , while driving at about 65 mph, the engine began knocking loudly. There was no warning before this happened and the engine light had not come on. The vehicle was taken to Shottenkirk Hyundai, an authorized Hyundai dealer, which diagnosed a connecting rod bearing failure. The repair order states: "Replace engine assembly due to piston slap on front bank caused by rod bearing failure." The dealer says the entire engine must be replaced. The vehicle has been maintained with regular oil changes. The failure was internal and was not caused by a crash, impact, or outside damage. I believe this is a safety defect. A connecting rod bearing failure can cause the engine to stall or seize without warning while driving, including at highway speed, creating a risk of a crash. A failed rod can also break through the engine block and leak oil onto hot engine parts, which is a fire risk. The vehicle is past Hyundai's 100,000-mile powertrain warranty. I have opened a case with Hyundai Consumer Affairs (case # 43347615) and am waiting for a decision. The vehicle and failed engine are available for inspection at the dealer. I am asking the federal safety agency to investigate connecting rod bearing failures in the 3.8L V6 engine in the 2020 Hyundai Palisade.

Filed Sep 30, 2026 · Electrical, Engine · VA

Vehicle developed a check engine light and underwent warranty repair, during which all six fuel injectors were replaced (Repair Order #1HWS5031079, dated 7/8/2026, 33,768 miles). Despite this repair, the check engine light returned, and the vehicle subsequently developed an intermittent hard-start and no-start condition — in some instances the engine would not start on the first attempt and required a second attempt. The vehicle was returned to the dealership for a second repair visit (Repair Order #1HCS55031999, dated 7/28/2026, 34,090 miles), during which the dealership considered multiple possible causes, including a sensor issue and fuel-related concerns, before completing the repair. The vehicle was out of service for a cumulative total of approximately 22 days across both repair visits. An intermittent no-start condition raises reliability and safety concerns, particularly in situations requiring predictable vehicle operation.

Filed Sep 4, 2026 · Engine, Transmission · WA

On August 14, 2026, while driving and decelerating, I heard a knocking sound from the engine and the vehicle had difficulty downshifting. As the transmission shifted from second gear to first, the engine stalled immediately and the vehicle dropped into neutral while on the roadway. I lost propulsion in traffic. The vehicle behind me nearly rear-ended us due to the sudden stall. My children were in the vehicle. All dashboard warning lights illuminated at the moment of the stall. I was able to restart the engine and move the vehicle slowly, in first gear only, into a nearby parking lot. The check engine light came on at that restart and has remained on since. The vehicle sat parked and off for approximately 90 minutes. Before restarting, I checked the engine oil level and it was within the normal range. On startup, my children and I both heard a loud knocking sound and noticed an unusual smell, and the engine idled roughly while in Park. I drove approximately 15 minutes home with the rough idle continuing. On arrival the vehicle smelled hot, with a burning odor, although the temperature gauge read approximately mid-scale and was not in the high range. The check engine light remained on and the oil level was again confirmed to be within range. The vehicle has been out of service since the incident and is currently at a dealership awaiting diagnosis. This is a 2020 Hyundai Palisade with approximately 93,000 miles at the time of failure. A sudden loss of motive power in a travel lane is a safety defect.

Filed Sep 4, 2026 · Engine, Seats · CA

Seats still don't work after recall fix on 2nd and 3rd row. Front seats also do not work when moving 2nd row seat front to back front seat moved instead. Power train engine issues been in hyundai service 3 times diff services depts and still not fixed have not been able to drive car since mar due to these issues. Engine light on 3 power train warning codes on. When pushing gas car hesitates and almost completely stops on freeway or on only 2 way highway making it very unsafe to drive. Loos of power to ac and lights due to this issue!

Filed Aug 19, 2026 · Electrical, Engine · 80,000 miles · MD

The contact owns a 2022 Hyundai Palisade. The contact stated that while driving at an undisclosed speed, the vehicle stalled and shifted into park independently. The contact stated that there was smoke coming from the engine compartment. The check engine, battery, oil, and another unknown warning light were illuminated. The failure had occurred on several occasions. The vehicle was taken to a dealer to be diagnosed; however, the cause of the failure was not yet determined. The dealer stated that an oil leak was found; however, there was no oil in the engine. The vehicle was not repaired. The vehicle was taken to another dealer, Antwerpen Hyundai Clarksville (12440 Auto Dr Clarksville, MD 21029) to be diagnosed; however, the cause of the failure was not yet determined. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 80,000.