2020 Hyundai Palisade: check engine light

Filed Oct 28, 2026 · Engine, Fuel system · FL

• Noticed a rattle sound when taking off and when the car was preparing to stop; All timely maintenance were done at Headquarter Hyundai in [XXX]. Oil change was done by Tires Plus ([XXX]) end of XXX as the car was just over 100k miles, so no warranty. • XXX, notice the rattle sound and notice the engine tremble when stopping. Returned to Tire Plus for diagnostic. XXX - TECH NOTED NO OIL ON DIPSTICK UPON ARRIVAL. CUSTOMER ADVISED TO DO OIL CHANGES MORE FREQUENTLY AT 3,000 MILE INTERVALS; NO VISIBLE OIL LEAKS AT THIS TIME - INTERNAL ENGINE OIL CONSUMPTION. POTENTIAL PISTON RING OR ENGINE BEARING ISSUE CAUSING OIL CONSUMPTION. COMPUTERIZED ENGINE ANALYSIS. • My safety was at risk when the oil notification failed to occur, when the check engine notification failed to occur. These failures could have resulted in a complete shut down of the engine resulting in an immediate collision as I travel on the interstate daily for work. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 5, 2026 · Engine · GA

My 2020 Hyundai Palisade (3.8L V6) suffered an engine failure at approximately 108,000 miles. On September 3rd,2026 , while driving at about 65 mph, the engine began knocking loudly. There was no warning before this happened and the engine light had not come on. The vehicle was taken to Shottenkirk Hyundai, an authorized Hyundai dealer, which diagnosed a connecting rod bearing failure. The repair order states: "Replace engine assembly due to piston slap on front bank caused by rod bearing failure." The dealer says the entire engine must be replaced. The vehicle has been maintained with regular oil changes. The failure was internal and was not caused by a crash, impact, or outside damage. I believe this is a safety defect. A connecting rod bearing failure can cause the engine to stall or seize without warning while driving, including at highway speed, creating a risk of a crash. A failed rod can also break through the engine block and leak oil onto hot engine parts, which is a fire risk. The vehicle is past Hyundai's 100,000-mile powertrain warranty. I have opened a case with Hyundai Consumer Affairs (case # 43347615) and am waiting for a decision. The vehicle and failed engine are available for inspection at the dealer. I am asking the federal safety agency to investigate connecting rod bearing failures in the 3.8L V6 engine in the 2020 Hyundai Palisade.

Filed Sep 4, 2026 · Engine, Transmission · WA

On August 14, 2026, while driving and decelerating, I heard a knocking sound from the engine and the vehicle had difficulty downshifting. As the transmission shifted from second gear to first, the engine stalled immediately and the vehicle dropped into neutral while on the roadway. I lost propulsion in traffic. The vehicle behind me nearly rear-ended us due to the sudden stall. My children were in the vehicle. All dashboard warning lights illuminated at the moment of the stall. I was able to restart the engine and move the vehicle slowly, in first gear only, into a nearby parking lot. The check engine light came on at that restart and has remained on since. The vehicle sat parked and off for approximately 90 minutes. Before restarting, I checked the engine oil level and it was within the normal range. On startup, my children and I both heard a loud knocking sound and noticed an unusual smell, and the engine idled roughly while in Park. I drove approximately 15 minutes home with the rough idle continuing. On arrival the vehicle smelled hot, with a burning odor, although the temperature gauge read approximately mid-scale and was not in the high range. The check engine light remained on and the oil level was again confirmed to be within range. The vehicle has been out of service since the incident and is currently at a dealership awaiting diagnosis. This is a 2020 Hyundai Palisade with approximately 93,000 miles at the time of failure. A sudden loss of motive power in a travel lane is a safety defect.

Filed Jul 3, 2026 · Engine · MI

I bought this car used from Albion Ford and I didn't have it 3,000 mile when my check engine light came on. Took it in and they said nothing was wrong with it. A couple days later it stalled in the middle of the road at a stop sign. It happened a mile later, I stopped at the store and there was absolutely not oil on the dip stick. I put 2 quarts in and it was at the very bottom of the dipstick. It's still under warranty and they did an oil consumption test and said it was normal. It's burning 5.5 quarts every 3,000 miles.

Filed Jun 25, 2026 · Engine · CA

My properly maintained 2020 Hyundai Palisade suffered catastrophic engine failure at 77,000 miles. Importantly, prior to the engine failure, no check engine lights, low oil warnings, or other warning indicators were active or displayed. The vehicle gave no indication of an imminent catastrophic engine failure or lack of oil. In researching this matter, I have found numerous reports, as well as active and settled litigation, involving Hyundai engine failures and oil consumption concerns. Severe oil starvation due to engine manufacture issues caused a thrown rod which can result in fire. The car was being driven by my teenage son after dark and the engine completely shut down putting him in harm's way in the middle of the road. Hyundai has repeatedly refused my requests for assistance in repairing this known issue due to my being a second owner with a lesser warranty that is given to 1st owners. This issue is a safety concern and a known issue to HCA and should be a recall to insure it stops happening.

Filed Jun 16, 2026 · Driver assistance, Engine · MD

On XXX I took my vehicle to Ourisman Hyundai of Bowie because my engine light was on. That same day the Service Adviser (Edson XXX) informed me that the engine was burning oil excessively. They performed an oil change and replaced engine oil gasket and asked me to return after driving 1000 miles. Mileage at the time was 103,380. I return on XXX, mileage was 104,580. [XXX] informed me that vehicle failed oil consumption test. He submitted request for engine replacement. On 11/25/2025 I returned to dealer because engine light came on again, and still no approval for engine replacement. I was informed that Hyundai approved combustion chamber cleaning. The service was complete four days later. However, it did not fix the problem. The engine excessive oil burn still happens as of this report. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 20, 2026 · Engine, Transmission · ID

Premature engine fail. Excessive oil consumption due to piston ring failure. Maintenance has been done on car on regular basis. No check engine light. Carson was services at dealership 4 months ago.

Filed May 12, 2026 · Engine · MS

2020 Hyundai Palisade, VIN: [XXX] . Excessive engine oil consumption beginning at ~95,418 miles. Oil drops to critical levels between oil changes, causing engine hesitation, rough running, and Check Engine Light activation — CEL clears only after oil is manually added, confirming oil starvation as the cause. SAFETY RISKS: Engine seizure or stall at highway speed; engine fire from oil burning on hot components; sudden loss of vehicle control; CEL only illuminates after oil is already critical, leaving no safe warning window. DEALER: Vehicle brought to dealership in [XXX] on 8/25/25 (95,451 mi) and Barnes Crossing Hyundai, [XXX] on 4/22/26 (99,969 mi). RO# XXX/1. HMA Case# XXX. Both dealers confirmed abnormal oil consumption. MANUFACTURER RESPONSE: Hyundai Motor America denied all repair or engine replacement solely because the title was transferred from a family member. Hyundai's own XXX (Dec. 2023) acknowledges systemic oil consumption across all Hyundai gasoline engines and mandates a repair protocol including engine replacement. A title transfer does not cause a mechanical defect and Hyundai failed to apply its own TSB procedures before denial. REQUESTED ACTION: Investigate HMA's pattern of denying TXXX remedies after title transfers; compel engine repair/replacement at no cost; evaluate safety recall eligibility. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 6, 2026 · Engine · 30,000 miles · OH

The contact owns a 2020 Hyundai Palisade. The contact stated that he initially began to notice that his engine would consume oil at a rapid pace. As the failure persisted, the vehicle would shudder upon depression of the accelerator pedal as the check engine light appeared on the instrument panel. In addition, the contact stated that white smoke would emit from the exhaust pipe. The vehicle was taken to an independent mechanic where the spark plugs were replaced on two separate occasions due to carbon build up. The vehicle was then taken to a dealer where it remained in their possession for three months before the contact was informed that they were performing an oil consumption test. The contact was advised to bring the vehicle back at 1,000 to continue the oil test. After 1,000, the contact was informed that the engine showed no sign of excessive oil consumption. The contact then stated that while driving at 35 MPH, the vehicle shut off without warning as the contact managed to coast the vehicle into a nearby parking lot. The contact attempt to restart the vehicle; however, the engine failed to start. Due to the failure, the vehicle was towed to his independent mechanic where they diagnosed the vehicle with engine failure. The vehicle was then towed to another dealer(Diehl Hyundai of Sharon-1251 E State St, Sharon, PA 16146) where the vehicle remained in their possession for two months were they replaced the engine and vehicle starter. Upon return of vehicle while driving at 55 MPH, the front end of the vehicle began to violently shake and the contact immediately contacted the dealer. The contact was informed that the vehicle was not test driven before the vehicle was returned due to the excessive wear of the rear tires. Additionally, the contact stated that the steering wheel would shake while driving which would cause the contact to lose control of the vehicle without warning. The dealer refused to offer a loaner vehicle and that they would listen to the engine but could not guarantee any repairs. The contac

Filed May 3, 2026 · Electrical, Engine · AZ

I recently purchased this vehicle, and shortly after, it began having serious powertrain issues. When I accelerate, the vehicle intermittently loses power and starts shaking violently. It feels like the engine or transmission is slipping or failing. The RPMs surge and drop rapidly, and the vehicle hesitates, jerks, and sometimes briefly slows down before suddenly accelerating again. This creates an unsafe and unpredictable driving condition, especially when merging or driving in traffic. I’m concerned about a loss of propulsion while the vehicle is in motion. My mechanic indicated the issue may involve the torque converter clutch not engaging properly (possible “stuck off” or circuit performance issue), which would explain the shuddering and inconsistent power transfer. Despite how severe this is, there are no warning lights or check engine light, and no diagnostic codes, which raises concern that the failure is not being detected by the vehicle’s onboard systems. I am also experiencing low and fluctuating engine oil levels even after topping it off and a recent oil change, which may indicate an additional engine-related defect. The vehicle has a clean title and no accident history. - Failed system: Powertrain (engine/transmission), suspected torque converter clutch malfunction. Vehicle is available for inspection. - Safety risk: Intermittent loss of power, hesitation, and surging creates a high risk of collision, especially in traffic or at highway speeds. - Confirmation: My independent mechanic has identified as likely a torque converter related issue. - Inspection status: Not yet inspected by manufacturer or insurance. - Warnings/symptoms: No warning lights or codes. Symptoms began shortly after I purchased and have worsened over time.

Filed Apr 12, 2026 · Engine, Suspension · TX

While traveling to Abilene Tx to see my doctor my check engine light came on. I pulled into the Hyundai dealership and ask the service advisor to plug into my vehicle and let me know what was going on. After he talked to his service manager he advised me that they "where to busy" and the earliest they could get me in would be the next Monday. This was Wednesday. My home is 100 miles from Abilene. I asked if he thought it would be alright and he said sure. I barely made it back to Big Spring before it started clinking and cluttering. It sound horrible. My son said it sounded like it through a rod. He checked the oil and said that I had low oil however my low oil light did not come on. I notified the dealership and was advised that I had to have it towed back to the shop in Abilene which I did. After a week passed I was in Abilene and stopped to check on my vehicle. Needless to say my repairs are in excess of 20K. New engine etc. and rear suspension is out also. After researching I have found I'm not the only owner with these problems. There are numerous complaints about these problems with the Palisade. This is a danger to all who own this vehicle. Fires, accidents and no telling what can affect us. All these vehicles need to be recalled because of the engine that was placed in these vehicles. The engine is eating oil fast. My oil changes were on time. Hyundai and the dealership are unwilling to offer any help in repairing my vehicle. The parts on the suspension are sub standard. I can't believe they are called the #1 SUV in America! Buyers need to be aware of the substandard parts and engine. They also need to be aware the Hyundai doesn't stand behind their product or the dealership either for that matter. I shutter to think of who I could've been on the side of the road with a blown on fire engine. I'm thankful I made it home before the vehicle cratered.

Filed Mar 16, 2026 · Engine · MS

Last year while traveling on vacation, my family was on the interstate crusing at approximately 70 MPH when the Hyundai Palisade suddenly started shaking and slowing down. It was shaking so bad, I ended up having to turn on my flashers because the vehicle would not accelerate up hill while pressing on the gas pedal. Thankfully, I was able to exit the highway and located a Hyundai dealership about 15 miles away in Jasper, AL. The dealership service department was very nice and indicated my engine oil was low. I could not figure out why this happened because we have always changed the oil at recommended intervals but once the dealership changed the oil, the check engine light turned off and we were able to proceed on our trip. Last night, we were traveling from [XXX] international airport back to [XXX] and the same pattern started all over again. After conducting some internet research based on the 2020 Palisade SEL, it appears this is a common issue for vehicles just under 100k miles. The reason I am reporting this is because Hyundai Corporate should do the right thing in this situation, by offering to replace the engine since I am within the 100k mile powertrain warranty period. I plan to take the vehicle to my local dealership today becuase there are two outstanding recalls, one of which is considered more serious due to a seatbelt latch. We waited over a month to schedule this service and the local dealership cancelled our appointment and didnt even offer to contact us to tell us this. The seatbelt issue is still not resolved and now we need Hyundai to perform oil consumption testing because the vehicle should not be burning this amount of oil while driving at speeds over 55MPH or over. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)