2007 Hyundai Santa Fe electrical problems

Filed Jan 15, 2026 · Electrical, Engine · FL

I am writing to formally report an incident involving the service department at Lakeland Hyundai (1500 W Memorial Blvd, Lakeland, FL 33815). My 2007 Hyundai Santa Fe was brought in on 12/31/25 for an active engine recall involving the Cylinder Head Cover Oil Leak Repair (Recall Code 976 / Campaign 24-01-026H). The vehicle was driven into the dealership in proper working condition. I was later informed that allegedly stripped bolts for the cover would require an out-of-pocket cost of $483.36, despite this being a recall repair. There was also a required Upper Timing Chain Guide repair quoted at $58.38 to complete the recall work. When I was called in on 01/12/26 to pick up the vehicle for completed work, I was charged $29.99 for a Multi-Point Inspection related to the recall, yet no documentation or billing was provided for the timing chain guide repair I was told was completed. Upon attempting to leave the lot, the check engine light was on and the vehicle immediately began shaking violently and producing a loud noise. The service representative could not identify the cause and later advised there was nothing further they could do, citing a P0300 code, and instructed me to return the loaner and retrieve my now-undrivable vehicle. My vehicle remains at Lakeland Hyundai and is undrivable due to issues that arose immediately following recall service. I respectfully request guidance and resolution regarding responsibility for the damage, loaner coverage, and loss of transportation.

Filed Sep 17, 2025 · Electrical · VA

UNKNOWN Went to the grocery store and vehicle was working fine. Upon leaving the store, started the car, ESC OFF light was on and when I went to press the brake to put the vehicle in reverse, the gearshift was locked and I couldn't move the gear. Long story short, I had to get my vehicle towed to the house as the vehicle is non-drivable at this time. Kelly's Blue Book indicated there were a few Hyundai recalls related to the ESC but my make and model was not affected but clearly I believe it is based on my experience and find this very unsafe.

Filed Mar 6, 2025 · Electrical, Engine · SC

My vehicle had an oil leak from the front cylinder bank valve cover onto the alternator. the oil damaged the alternator resulting in illumination of the charging system warning lamp and disablement of the charging system. On 11/09/2021, the engine light came on and my car turned off. I had it towed to my mechanic and on 11/10/2021 he replaced the valve cover gaskets, alternator and belt. On 12/2023, I found out there was a manufacture recall related to the valve cover. I placed a claim in 12/2023. They have asked for several versions of documents and then stop communicating and eventually deny/close the account. I have filed approximately 4 claims and they stop communicating. The last claim was filed on 1/2/2025 and I have only received an email stating "Thank you for contacting Hyundai Motor America." I have tried to ask for an update and no response. I have called and it refers me to the recall portal. What do I have to do to get reimbursed for the towing and repair work I that I have paid for.

Filed Nov 22, 2024 · Electrical, Engine · FL

The E .C. M. PART# 39110-3C561 started faulting out, causing stalling abruptly while stop at an intersection an merging into traffic.This events were randomly happening causing higher risks of accidents. I took the vehicle for service an was informed that the "ECM" was causing this faults. The vehicle had the check engine light on during this time. The service shop advised me to bring the vehicle in to the Hyundai dealer, because the problem is likely to increase. The Hyundai dealer verify that the "ECM " is faulty an extremely difficult if not impossible to find. This faulting "ECM " part has literally but my vehicle totally useless.

Filed Feb 28, 2024 · Electrical · 47,000 miles · NV

The contact owns a 2007 Hyundai Santa Fe. The contact stated while attempting to start the vehicle, the battery exploded leaving a hole in the hood of the vehicle. No warning light illuminated. The contact referenced Hyundai Campaign Number: 976. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 47,000.

Filed Jan 30, 2023 · Electrical · IL

Brake/stop light switch located behind the brake pedal sticks causing the gear shift to not be removed from or into Park. Hyundai issued Recall #110 for this issue but the recall does not cover all versions of 2007 Santa Fe even though the issue occasionally occurs on non recalled versions.

Filed Dec 15, 2022 · Electrical, Engine · IL

In 2015 Hyundai issued service campaign 936 for 2007-2009 Santa Fe valve cover & alternator due to the valve cover leaking & dripping oil onto the alternator, potentially damaging the alternator resulting in the charging system becoming inoperative. My 2007 Santa Fe was repaired under this campaign. Now with less than 30K miles since the repair the same problem exists, the valve cover is leaking oil onto the alternator again. I've contacted my local Hyundai dealer but they refuse to repair the issue under the campaign a 2nd time. The issue was detected by the local dealership during a routine oil change & they advised me that the cost to replace the valve cover gasket & the alternator would be in excess of $1,000.

Filed Feb 3, 2021 · Electrical, Fuel system · 109,000 miles · OH

Engine light stays on and the fuel needle stays on empty after the tank is full.

Filed Jan 4, 2021 · Electrical, Engine · NC

The valve cover gasket failed after being replaced under a previous recall in the same manner and oil leaks directly into the alternator causing it to ultimately fail.

Filed Jul 21, 2020 · Acceleration, Electrical · MI

It started off as what seemed like just the bulbs burning out in any which light. Then my passenger window stopped working then started working. The lights still were having issues. It took a bit for me to realize that there is a short or something in the car. The lights go out then come back on then switch which one is out. The worst time was when it went in for an oil change and came back out with no lights working. I contacted the company to make sure there was no foul play and they checked their camera. I've had the lights looked at multiple times by multiple different companies. It never fixes the problem permanently. A few weeks ago the back right passenger lock stopped working then the next week the front passenger window again. Then yesterday the lock started to work and today it doesn't again. And speedometer is off. Hard to say by how much. Depends on which speed reader I go by.