2007 Hyundai Santa Fe suspension problems

Filed Jan 15, 2026 · Electrical, Engine · FL

I am writing to formally report an incident involving the service department at Lakeland Hyundai (1500 W Memorial Blvd, Lakeland, FL 33815). My 2007 Hyundai Santa Fe was brought in on 12/31/25 for an active engine recall involving the Cylinder Head Cover Oil Leak Repair (Recall Code 976 / Campaign 24-01-026H). The vehicle was driven into the dealership in proper working condition. I was later informed that allegedly stripped bolts for the cover would require an out-of-pocket cost of $483.36, despite this being a recall repair. There was also a required Upper Timing Chain Guide repair quoted at $58.38 to complete the recall work. When I was called in on 01/12/26 to pick up the vehicle for completed work, I was charged $29.99 for a Multi-Point Inspection related to the recall, yet no documentation or billing was provided for the timing chain guide repair I was told was completed. Upon attempting to leave the lot, the check engine light was on and the vehicle immediately began shaking violently and producing a loud noise. The service representative could not identify the cause and later advised there was nothing further they could do, citing a P0300 code, and instructed me to return the loaner and retrieve my now-undrivable vehicle. My vehicle remains at Lakeland Hyundai and is undrivable due to issues that arose immediately following recall service. I respectfully request guidance and resolution regarding responsibility for the damage, loaner coverage, and loss of transportation.

Filed May 3, 2023 · Suspension · NY

There was a problem with the steering, so thought may be my wife hit a pothole found out the sub frame was severely corroded rusted and falling apart. My family could seriously got hurt. There was no accident, But there very well could have if she continued to drive ,there has to some form of responsibility of Hyundai add vehicle since it was brand new only 67,000 miles

Filed Oct 2, 2020 · Body, Suspension · IL

2007 sante fe limited, sage grey one owner, garage kept, maintained regular basis, low mileage 84,000, interior and exterior in excellent condition with a kelly blue book of $4200 to $4600. Purchased at lauren hyundai in glenview and maintained at hyundai lincolnwood, il along with my regular mechanic. I learned yesterday that the right rear of sub frame rusted out with a both front frame rusted out and has a hole in it. It's a know issue by fed, the federal safety agency, series of recalls and dealer rusted out frames, sub frames and other part repairs and replacemetns. The 2007 treatment didn't work and the same issue is all over the internet with class action suits. I've also read low and high mileage cars within 2-10 years have same issue but must be covered under warranty. They resolved the older ones by spraying them one one recall and didn't upgrade their sub par parts for us cold weather salt belt states. I now lost the value, cant sell it outright and the car is deemed unsafe. I'd like assistance getting this looked at and repaired. Yes old but in great condition mechanically with a vital part of the car not code for chicago from the beginning with a continued issue up to today. Cars that were new and a few years were getting them replaced. I that even safe after the repair? I still have value in this car and I shouldn't have to forfit from gross negligence on hyundai motors on a vital part of the car. I was considering a trade but now find out its a major safety issue for many models. I'd like to get this looked at, repaired or work out some type of solution. Any assistance you can give me is greatly appreciated. The dealer said it's old and acted like they had no idea. Thank you.

Filed Jul 7, 2020 · Airbags, Fuel system · PR

I would like to have the vehicle removed and compensate the value to prevent loss of my human life or of another person

Filed Apr 3, 2019 · Steering, Suspension · 120,217 miles · OH

I have had to replace the control arm 3 times, (2/2013, 4/2014, 3/2015) and about to do it a 4th time (2019). It goes bad after about 20,000 miles and affects the alignment which causes the tires to wear incorrectly. Brand new tires are get worn down on the inside edge and is not visible. This causes a safety issue. My relatively new tire blew out on the highway and nearly caused a crash. I've spent $3000 in repairs and estimate another $1000 in tires that had to be replaced prematurely. I will fill one of these out for each of the incidents described above.

Filed Apr 3, 2019 · Steering, Suspension · 102,622 miles · OH

I have had to replace the control arm 3 times, (2/2013, 4/2014, 3/2015) and about to do it a 4th time (2019). It goes bad after about 20,000 miles and affects the alignment which causes the tires to wear incorrectly. Brand new tires are get worn down on the inside edge and is not visible. This causes a safety issue. My relatively new tire blew out on the highway and nearly caused a crash. I've spent $3000 in repairs and estimate another $1000 in tires that had to be replaced prematurely. I will fill one of these out for each of the incidents described above.

Filed Apr 3, 2019 · Steering, Suspension · 78,676 miles · OH

I have had to replace the control arm 3 times, (2/2013, 4/2014, 3/2015) and about to do it a 4th time (2019). It goes bad after about 20,000 miles and affects the alignment which causes the tires to wear incorrectly. Brand new tires are get worn down on the inside edge and is not visible. This causes a safety issue. My relatively new tire blew out on the highway and nearly caused a crash. I've spent $3000 in repairs and estimate another $1000 in tires that had to be replaced prematurely. I will fill one of these out for each of the incidents described above.

Filed Aug 27, 2018 · Suspension · 150,000 miles · OH

Excessive rust right rear trailing arm at subframe - is essentially rusted to the point if this joint fails it will cause an accident. This we found out that this is part of a hyundai recall campaign 947 wen we called the dealer and hyundai. Scheduled appointment at dealer to have checked, take pictures,order parts and repaired

Filed Jun 19, 2017 · Suspension · 200,000 miles · IL

I got a letter for a recall for underbody corrosion preventative care, however when I took to the dealer to get this done, the undercarrige/underbody was already too corroted/damaged and hyundai is not willing to fix it, instead they are trying to offer me $4,800 which will not buy me a new SUV car. And this is due to a manufature deffect.

Filed Dec 28, 2016 · Steering, Suspension · 100,000 miles · OH

Tl* the contact owns a 2007 hyundai santa fe. While driving at any speed, the vehicle jerked left and right and leaned on one side without warning. The failure caused the driver to almost lose control of the vehicle. The failure recurred a number of times. The dealer was unable to diagnose or replicate the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.