2008 Hyundai Santa Fe fuel system problems

Filed Feb 22, 2024 · Fuel system · IN

Large leak detected P0455

Filed Nov 7, 2022 · Fuel system · NY

The fuel tank level sensor failed and yes can be inspected. Check engine light goes on and fuel says empty with little yellow light .My mechanic checked my car and told me it was the fuel tank level sensor. Check engine light goes on and the fuel needle goes up and down to empty. When I fill the tank, the check engine light goes off and the needle rises to full. When the gas reaches a certain level the check engine light goes on and fuel needle drops to empty . It will go up and down. This first occurred October 2022.

Filed Jan 24, 2022 · Fuel system · NJ

The contact owns a 2008 Hyundai Santa Fe. The contact stated that the vehicle failed to display an accurate current fuel level. The contact stated that the check engine warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed with needing the fuel lines replaced. The vehicle was not repaired. The manufacturer was informed of the failure and informed the contact that they were unable to assist. The failure mileage was unavailable.

Filed May 14, 2021 · Fuel system · 110,000 miles · TX

The fuel gage keeps marking the wrong level of gas. First it went crazy going up and down. After sensors were changed, it stayed at half of tank even when full. Now the fuel system will need to be replaced again because when it reaches a certain gas level, the check engine shows up. Its random issues and all have to do with the pump, and sensors. Been trying to fix this for 2 years and replacing the system seems to work for a few months and then the issues show up again.

Filed Apr 16, 2021 · Fuel system · 120,000 miles · KS

Fuel gage does not work. Fill up car with gas and the tank shows empty for days and the check engine light comes on. Getting new system does not fix this issue. Each day you get in the car it will show a different and inaccurate readying. I have seen many other online complaining about this.

Filed Jan 2, 2021 · Fuel system · 89,230 miles · NY

Fuel gauge failed. The fuel tank would be full but the gauge read 1/4 tank, (ran out of gas in the middle of nowhere) contacted hyundai, they were aware of this issue but offered no solution as far as recall, they stated the fix would cost approx. $600.00 with parts and labor. I checked this issue on line and this defect in the "fuel sensors" has been going on from approx. 2007 to 2015 effecting thousands of hyundai santa fe's. My question is, why hasn't "the hyundai motor co." corrected this safety problem or issued a recall? They expect customer loyalty but it appears the loyalty goes only one way. I was very happy with my 2008 santa fe but now I'm wondering how many other safety issues are being covered up. I was at my hyundai dealer just prior to the fuel sensor issue looking at the new palisade limited" but now I'll look elsewhere [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).

Filed Nov 20, 2020 · Fuel system · 110,000 miles · CA

Take to much fuel

Filed Oct 9, 2020 · Driver assistance, Fuel system · 131,009 miles · FL

The fuel sensor stopped working. Pay to fix it but only lasted 1 month and than stop working again. Electrical. Was driving on highway heard a whining noise and then the car starting stalling. Won't turn on

Filed Apr 27, 2020 · Fuel system · GA

I have a 2008 hyundai santa fe that has a faulty fuel level sensor. The gas gauge does not show the correct amount of gas in the tank and the check engine light is always on. About 95 percent of the time it shows empty, even after filling up the tank. Sometimes the gauge will move just over half way, then it goes back to empty. I have taken the vehicle to three different shops to have it checked out and they all say that fuel level sensor not working properly. To fix this issue will be between $700 - $1000. After looking up this issue on the internet, there are multiple complaints about this same issue for the exact my make, model, and year vehicle that I am making the complaint about. This issue is consent if I am moving or stationary. The only way to ensure I do not run out of gas is to fill up about the 250 mile mark to make sure I do not get stranded. I have attached a picture of the indicator after filling up the tank completely. If you need to contact [xxx]. Thanks in advance any help in this matter. Redacted to protect personally identifiable information pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6)

Filed Mar 1, 2020 · Fuel system · 49,377 miles · AZ

With 49,377 miles, I added partial fuel (6.9 gallons) and the fuel gauge showed zero with the fuel light on. After a few days the fuel gauge read normally. Since then I've added fuel five more times. Each time the gauge went to zero and then ramped up gradually. Yesterday, february 29, the check engine light came on steady. Today I had the error code read: p0463 fuel level sensor a circuit high input. Although the part required lists for $79.99, it is apparently changed in the fuel tank and very expensive to access.