My complaint is the dealership that said had completed the recall on my brake systems according to both your and state records was not completed. They gave me a service notice stating the work was done. Since then the braked have continued to act up and the vehicle as a strange acceleration problem. The dealership is Don Wood Hyundai in Athens Ohio.
2017 Hyundai Santa Fe engine complaints
Page 7 of 24: complaints 161 to 190 of 673, newest first, as owners wrote them.
The engine seized due to an issue with the oil plug and another part, leading to a lack of oil in the system. The vehicle is currently with Hyundai and available for inspection upon request. How Safety Was Put at Risk: While driving on the highway, I suddenly lost acceleration (below 40mphs). I was forced to pull over to the left side of the highway where it was shallow, where I risked being hit by passing vehicles until there was a safe break in traffic, allowing me to maneuver to an exit. This created a hazardous situation for both myself and other drivers. Reproduction or Confirmation of the Problem: The issue has been confirmed by an independent automotive technician, who diagnosed the problem as a blown engine caused by a lack of oil. The vehicle is now with Hyundai for further inspection. Inspection by Others: The vehicle has been inspected by an independent service center and is currently being inspected by Hyundai. No other parties, such as the police or insurance representatives, have been involved. Warning Lamps or Messages Prior to Failure: The only warning sign prior to the incident was the check engine light blinking at the time of the failure. There were no other warning lamps, messages, or symptoms before the engine seized. The vehicle was within the oil range limit of 7,500 miles at the time of the incident. Additional Notes: The incident occurred suddenly, without prior warning or indication of an issue. Based on the diagnosis and known issues with the oil plug, I believe this failure was caused by a defect.
I have Hyudai Santafe 2017 Sport, bought it from dealership in 2020 with 46,000 Miles and in around past 4/5 years added 30,000 miles. Which is not much, in the past one year i have noticed that engine oil is burning faster than usual. On every oil change after driving between 1200 and 1500 miles the oil engine sign blinks and upon checking needed 2 Quarts of oil. I spoke the dealership and they are not very helpfull. Also they did the oil combustion test which i was charged. Later i was advised to do. ("Good morning, Just got off the phone with you sir warranty won't cover it due to the vehicle being out of manufacture warranty and mileage. My technician recommended starting with combustion chamber cleaning which would be around 1200 before taxes and shop supplies. Combustion chamber cleaning is the process of removing carbon buildup from the combustion chamber and intake valves of a fuel-injection engine. to see if that fixes the problem that you are having with the car burning oil. If that step doesn't work we we would submit a warranty pa again, to see if they would cover a new engine." Please advise what should be my next step, as per my mechanic the only solultion right now i have is keep adding oil carefully.
I was driving my 2017 Hyundai Santa Fe and suddenly I heard the knock sound from the engine and when I pulled over, I saw the oil came down from the engine. I towed my vehicle to Hyundai dealership and they diagnosed the issue is vertical square and potential rod bearing failure. My vehicle has only 91k miles. I want to find out if there is any recall on this issue that happened to my car. Please let me know.
Excessive oil consumption greater that 1 quart per 1000 miles.
After a perfect dealership maintenance history and being babied since bought new, the 3.3L V6 engine in our 2017 Hyundai Santa Fe seized at 101,800 miles without any warning other than a slight knock on startup the day this occurred. The engine seized while being driven on a side road without any warning lights, causing loss of steering and braking power. Hyundai has extended the warranty on the 4 cyl engines for this model year vehicle, but based on online forums there is clearly a manufacturing defect with the V6 engines as well. We were forced to pay ($1,541) for 20% of the cost to repair the engine with rebuilt components after Hyundai kept the car for nearly four months. I feel this payment should be reimbursed given the warranty on the V6 engines also needs to be extended.
While driving on rural side road, two lanes, my check engine light (yellow, steady) came on. I pulled into a safe spot and did a quick survey, checked the owner manual, but could not identify any problem, and continued on my way. The check engine light was still on. About 15 minutes later the car would not accelerate past 25 mph (limp mode?). I was on a two-lane mountain road, speed limit 45 (but most cars were faster), visibility limited by terrain, trees, etc. Again, there was little traffic around me and I found a safe place to pull over. in neutral the engine revved normally. I turned the ignition off, checked oil level, (normal), turned the engine back on and started driving to find a safe place to pull over and summon help, but the car drove normally. I drove directly to my repair shop and had the codes pulled, (0436, 0021) which indicate a problem with timing. When a qualified tech examined it he recommended taking to the dealer. Unwilling to drive in traffic, I had it towed to the dealership. Their inspection revealed damage to CVVT components and the timing chain, and recommend an (expensive) engine rebuild.
Engine blew due to excessive oil consumption (at time of incident I had not a drop of oil left) with no warning. My safety was put at risk by my car stalling in the middle of driving with my kids in the car. My vehicle is now at a service shop, mechanic informing me I need a whole new engine. My dashboard never showed low oil light or service engine light, I never had black smoke or smell.
I went for an oil engine and they told me that my engine didn't have any oil. I checked for oil leaks and the vehicle does not have any oil leaks. My car has 100,480 mileage and have never been in any sort of accident.
My car has 81,000 miles on it, I have had regular oil changes and after reading many recalls on here I see I am definitely not alone. My check engine light stays on, after paying $100. for dealer to check the codes I was told nothing in particular showed a problem even though I have to put oil in my car between oil changes and there are no leaks on drive. Apparently the 100K mile warranty is not being honored from the other reports I have read on here. Why ??? The price of new cars is beyond reach and if dealer is claiming there is a warranty there be should be way to make them honor it!!!
The engine seized. Driving at 55 mph on a 4 lane highway outside of city limits, the vehicle went into limp mode. Luckily, it was later in the evening with less traffic and I was fortunate enough to be able to turn into a left turn lane and coast into an office building parking lot. There was no shoulder available if I had been in the right lane and somewhat of a rural area. There were no sensors that alerted me prior to this happening. But, when it did happen the dash board lit up like a Christmas tree! It was 6:30 pm, I coasted into a parking spot in the lot and turned the car off. It would not start and I contacted a tow service. I had it towed to an automotive shop near my home. They confirmed the next morning, that there was no oil on the dip stick and the engine seized. They alerted me to the fact that this has become a common problem with this Hyundai engine. I then had the vehicle towed the Hyundai dealership where we purchased the vehicle. We are the original owner. The vehicle is sitting at Rosen Hyundai in Algonquin, IL and should be available for inspection. Monica at the dealership called me after the inspection and confirmed that this is a common issue with this vehicle. She at first used the word recall...and when I asked if there was a recall, she said not a recall, but Hyundai has issued a BULLETIN about this problem. At first, she stated that my maintenance records were in order and being the original owner I qualified to file a claim with Hyundai for engine replacement. 3 days later, she called and stated that Hyundai needed more proof of maintenance than what they could pull off Carfax or my claim was going to be denied. She sent me a picture of the engine and stated that the valves show neglect. I replied of course they do....the engine seized! There was never ever any low oil warning light, check engine or or any warning lights what so ever prior to the event! Hyundai admitted that there is no low oil sensor warning.
The contact owns a 2017 Hyundai Santa Fe. The contact stated while starting the vehicle, there was an abnormal ticking noise detected. There were no warning lights illuminated. The contact stated the noise was coming from cylinder #3 and the lifters. The vehicle was taken to the dealer, who was unable to duplicate the failure while starting the vehicle. The vehicle was not diagnosed or repaired. The vehicle was taken to another local dealer Service Center at Gurley Leep Hyundai (5302 Grape Rd Suite #3, Mishawaka, IN 46545); which determined that the cam shaft and pump electronic body sensor, ABS, and harness needed to be replaced. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 97,000.
While driving a 1/2 second squeal came from engine compartment. Motor immediately stopped. No power steering or brakes. Vehicle is available for inspection. We were on an interstate We coasted to shoulder. There issue is frequent on Internet forums. A trusted mechanic old us the engine was totally seized. Could be turned manually. No oil in crankcase. At this time only aforementioned mechanic has inspected the vehicle. No warning sounds or performance changes prior to incident. No warning lights or notice warnings were seen prior coincident.
Since this vehicle reached about 75,000 miles, it has been burning oil like crazy. We have to add a quart every 7-10 days. It drives fine, there’s no oil leaks, no smoke from the tailpipe. We took the car to Hyundai and they did their oil consumption tests. They came to the conclusion that this was within the normal range and would do nothing for us. This needs to be fixed, Hyundai!
The engine consumed all of the oil and now has to be replaced
Like many others, car consumed a quart of oil each 500-1,000 miles driven. Car received synthetic oil changes every other month along with additional quarts of oil in between oil changes. All service records maintained with receipts of additional oil quarts purchased. Car NEVER displayed any warning lights for low oil pressure or check engine lights. While driving on the highway at 65 MPH, engine seized. Was able to pull over safely and had car towed to the dealership. Service manager at dealer claims it will be over $20k to fix but Hyundai is only willing to cover 70% because it’s no longer covered under warranty and isn’t backed by their extended warranty offer. What a way to admit fault but gaslighting the consumer into believing it’s the consumer’s fault for a faulty product. Hyundai does not allow outside mechanics to look at vehicle or make repairs if you want them to take responsibility. So stuck with paying inflated dealer fees for repair and labor.
The contact owns a 2017 Hyundai Santa Fe. The contact stated while driving at an undisclosed speed, the engine was making an abnormal sound and the RPM increased. In addition, the contact stated that every 2,000 miles engine oil needed to be added to the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed with a cracked valve cover and excessive oil consumption. The vehicle was not repaired. The contact was advised to take the vehicle to the dealer. The vehicle was taken to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. In addition, the contact was informed that the repair was not covered under warranty due to the codes received per the diagnostic test. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 142,500.
We purchased a 2017 Hyundai Santa Fe SE ULTIMATE from Hampton Hyundai in December of 2019. The vehicle has the V6 3.3 Liter Lambda II motor. At the time of purchase it had 44,969 miles on it and we paid roughly $27,000 for the vehicle and associated service package. We routinely had the vehicle serviced according to the recommended service schedule. In early 2022 we realized that the engine began burning oil at an alarming rate. We were adding roughly 1.5 quarts every 1,000 miles to maintain a safe level. This was done at a certified mechanic. After inquiring with Hampton Hyundai we were informed that this is considered normal operation and to be expected. Based on that information, we proceeded to routinely check oil levels and maintain them accordingly. On December 23rd, 2022, with roughly 81,000 miles on the vehicle, we experienced a knocking noise coming from the engine. I immediately pulled the vehicle to the side of the road to investigate the possible cause. I checked the oil and inspected the engine for anything that seemed to be out of place. There was nothing that seemed uncommon to the layman eye, with this, we immediately returned home with the vehicle. From here we had it towed to Certified Automotive Repairs and Service (C.A.R.S) and then to Hampton Hyundai. Both locations told us we needed a full engine replacement. We have requested assistance from Hampton Hyundai and Hyundai Motor America to assist with the cost of replacement and have been denied. The quote for a new motor and labor to install is nearly $20,000 and we were told that the cost is so high because Hyundai does not make the motor anymore and each individual part would need to be ordered and assembled. Our vehicle is currently at Hampton Hyundai and we are planning on having it towed back to our home.
* Engine seized . No warning . No check engine light until i pulled over on the highway. *My safety , my child's safety and everyone behind me on the interstate had to avoid my rapid deceleration/ * vehicle has not been towed in yet, it will be as soon as the dealer lets me know they will see it *No lamps or bulbs. car seized and lost power
Engine suddenly stopped working on the highway, we towed the car to the garage and they mentioned that the crankshaft was misaligned and that the engine must be replaced. We were good with our oil changes over the life of our ownership of the car. It only has 119K miles.
The contact owns a 2017 Hyundai Santa Fe. The contact stated while driving 65 MPH, the vehicle stalled. There was no warning light illuminated. The vehicle was restarted; however, the failure recurred. The vehicle was towed to the dealer where it was diagnosed that the engine failed and needed to be replaced. The vehicle was repaired; however, the failure recurred. The contact stated while driving at an undisclosed speed, the vehicle stalled with several unknown warning lights illuminated. The vehicle was towed to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 95,000. The VIN was not available.
The engine in my 2017 Hyundai Santa Fe malfunctioned due to issues with the connecting rod bearings, a known defect for this model. While driving on the highway, the engine began to slow down and fail, creating a hazardous situation that jeopardized my safety and that of other road users. A diagnostic performed at World Car Hyundai South confirmed that the problem was with the connecting rod bearings. Despite the severity of the issue and the fact that it is a documented problem with this model, Hyundai's Goodwill Program and warranty did not cover the engine replacement. The manufacturer cited missing maintenance records from previous owners as the reason for denial. I provided comprehensive service records for the vehicle from the time it was in my possession. The refusal to cover the repair based on the absence of previous records on Carfax overlooks that previous owners may have used service providers not reporting to Carfax. Additionally, there were no warning lamps or messages before the engine failure. Hyundai's decision to deny coverage, given the known defect in this model, suggests an attempt to avoid responsibility.
The engine is suffering from excessive oil consumption that might result in the engine blowing up. Hyundai is aware of the issue with many reports filed but has refused to address the issue.
I was driving along 55mph on a 2 lane road when suddenly the car shut off. I was fortunate that it died at the top of a hill and I was able to coast to the safety of a side street. I was in a remote part of michigan and 20 miles from any service stations with my 3 children. The car would not restart. I was able to contact a tow truck who took it to my mechanic who said the engine had failed and I would need a new engine.
3.3l engine with 120k miles began making a noise and suddenly failed while driving at interstate speeds. No warning lights or messages appeared prior to this incident. All occupants, two adults and child, were placed in danger while attempting to exit the highway and were left stranded with an inoperable vehicle.
Complete engine failure at 150,000. No check engine or warning lights prior to failure. I was traveling at 75 mph on the freeway when the engine lost power and locked up. I was barely able to make it safely to an exit before it fully shut down. After stopping, oil was profusely leaking out of the vehicle. When levels were checked it was completely empty. I know for a fact the oil was full before driving because I checked it and topped it off. Vehicle has been inspected by the dealership it was purchased from and they confirmed engine failure.
Engine failed due to metal shavings and oil consumption issue. CHeck engine light came on and I immediatley took for service. IT has been examined by car dealer who got approval for 90% of engine replacement. Feel it should be 100% and fall under 11006230 and be covered 100%
car started doing a weird noise. car checked at dealership, mentioned that it was probably the engine but that there was no engine light on. Car released back to us since no warning light was on. Engine died about a week later while driving (luckily, we were in a parking lot and our kids were not in the car). vehicle has been at dealership for more than 3 months.
Current mileage is 80,000. For the last 30,000 miles the engine oil burns or leaks within a month of it being changed. When I return to the shop to get yet another oil change. They investigate for leaks and find nothing. They end up topping it off vs charging me. As I barely put a hundred miles on the vehicle since the last change. Even when I barely drive between oil changes, I end up checking the stick frequently to ensure it’s not leaking or burning oil until the next change. Yet it always does. It also randomly acts like it doesn’t want to start. Doesn’t matter if it’s cold, hot or normal kind of day. Take it to dealer or auto repair shop for a diagnostic check and nothing is found. They check the starter, circuits, battery, and alternator. Nothing. This happens multiple times a yr. I’ve never owned a vehicle that does this before. Even my old 200+ mile vehicle never did this. This Hyundai is only 7 yrs old and under 85,000 miles. It’s baffling.
My 2017 Hyundai Santa Fe has roughly 120,000 miles on it and an engine light came on. I brought the vehicle into an automotive shop where they stated the vehicle was very low on oil, they checked the code and then reset it. After they drove the vehicle, it began "knocking" and the code came back on. They stated in the paperwork, "[t]his code is caused by the ecm getting a response from the solenoids that the camshaft is off; engine is not timed properly. This can be caused by a stretched timing chain or if the chain jumps a tooth." The oil has been changed less than 2,500 miles prior, no light ever came on to indicate that it was low, there was no indication that it was burning excessive amounts of oil, and I park in the same spot each day with no sign of oil leakage. There were no warning signs that the oil was low or that there were issues with the engine. This engine easily could have overheated and seized with absolutely no warning that it was coming. I was set to drive with my family across the country right before this happened and we easily could have been driving on the highway if/when the engine seized. The automotive repair shop quoted $9,149.01 to fix the issues and I owe a little more than $10,000 on it. I don't want to risk repairing it since the faulty engine will likely have this issue again in the near future and I am at a loss for how to proceed, especially with many having the same issue.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2017 Hyundai Santa Fe?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history