2020 Hyundai Santa Fe: fuel pump failure

Filed Oct 9, 2026 · Fuel system · CA

THERE IS A RECALL FOR THE SAME ISSUE ON THIS MODEL … I HAVE A CLAIM INTO HYUNDAI TO ALLOW MY VEHICLE TO BE REPAIRED UNDER THE SAME RECALL. This is a very dangerously problem and wish it to be investigated for the 2.0 Turbo as well. X Hyundai issued two main fuel-related recalls for the 2021 Santa Fe equipped with 2.5-liter turbocharged engines due to risks of fuel leaks and fires: & • Campaign 206 (the federal safety agency Recall 21V308000 / May 2021): The fuel pipe connecting the high-pressure fuel pump to the fuel rail may not have been tightened to the proper torque during manufacturing. Dealers inspected and retightened the connection for free. • Campaign 207 (the federal safety agency Recall 21V524000 / July 2021): Covering select 2021-2022 Santa Fe and Sonata models with 2.5L turbo engines, this recall addressed fuel pipes from a specific production run installed with insufficient torque or improper concentricity. Dealers inspected and either retightened or replaced the fuel pipe at no charge.

Filed Sep 23, 2026 · Engine · NY

Codes P0172 and P016B. Oil has fuel in it due to high pressure fuel pump leaking. Possible premature engine failure or fire. This is a 2020 santa fe limited 2.0T.

Filed Aug 13, 2026 · Acceleration, Fuel system · NV

Vehicle began running sluggish, gas smell noticed. Vehicle was due for oil change, took car in for oil change to AAA and mentioned gas smell. AAA identified gas leaking from fuel pump posing immediate safety issue that needed to be resolved.

Filed Feb 21, 2026 · Engine · MI

HI! Leaking valve cover gasket which damages spark plugs, ignition coils and fuel injector. Defective High Pressure Fuel Pump and fuel injector causing fuel to spray into engine and into engine oil. Large amount of fuel found in oil pan when oil changed. Complaint filed with Hyuandia, no response at this time. Thank you, [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Dec 26, 2025 · Fuel system · IL

I have a 2020 Hyundai Santa Fe, 2.0T. I recently experienced the following issues; gasoline fumes coming into the car at low speeds, difficulty starting the car when it is cold and hesitation when trying to accelerate quickly. The check engine light came on and the dealer diagnosed a faulty fuel pump and high pressure hoses......on a car with only 49100 miles! The repair cars are estimated at over $1800. This is totally unacceptable and there should be a manufacturer issued recall on the car where Hyundai covers the cost of the repairs.

Filed Jun 8, 2025 · Engine, Fuel system · CO

Driving vehicle at highway speed, engine RPMs dropped to less than 1500, could not maintain any speed, CEL illuminated. As soon as vehicle was pull to side of road, it would no longer run. It would start, idle roughly then stall out. Vehicle was towed to Mountain Hyundai in Denver. High pressure fuel pump failed, fuel pump in one cylinder failed, fuel was dumped into oil fouling all spark plugs. This is the second high pressure fuel pump failure on this vehicle.

Filed Feb 26, 2024 · Fuel system · 63,000 miles · FL

The contact owns a 2020 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed and attempting to accelerate, the vehicle suddenly lost motive power. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that one bolt on the fuel pump was sheared off and another was extremely loose. The vehicle was repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 63,000.