2020 Hyundai Santa Fe transmission problems

Filed Sep 2, 2026 · Driver assistance, Engine · FL

Hyundai Motor America & Wallace Hyundai of StuartVEHICLE: 2020 Hyundai Santa Fe (2.4L Theta II GDI Engine)VIN: 5NMS23AD5LH181669INCIDENT MILEAGE: 181,000 MiHYUNDAI CASE NUMBER: 42981944SECTION 1: CATASTROPHIC INTERSTATE SAFETY INCIDENTOn July 16, 2026, while navigating heavy, high-speed traffic on Interstate 95 (I-95) at approximately 80 to 85 MPH, my vehicle suffered an un-commanded, catastrophic mechanical engine seizure. The vehicle instantly dropped from highway speeds down to a 21 MPH "limp mode," creating an immediate multi-car pile-up hazard on a major interstate. Physical inspection immediately after the failure proved that the engine oil level was completely full. The internal components catastrophically failed due to a documented, systemic factory defect involving premature rod bearing failure and oil starvation mechanisms, entirely unrelated to consumer maintenance.SECTION 2: PRIOR SAFETY COMPLAINTS & DOCUMENTED TIMELINEHyundai Motor America has intentionally forced me to operate a known, life-threatening safety hazard for 17 months, during which I drove an additional 31,000 miles under extreme duress. I filed formal oil consumption complaints with Hyundai Corporate every three to four months. I was forced to manually replenish the engine oil every 1,000 miles due to excessive oil loss.Specific safety reports detailing hazardous engine behavior were formally logged with Hyundai on November 25, 2025, and again in April 2026. Rather than remediating the vehicle, Hyundai corporate claims adjusters and dealership supervisors ignored these warning tracks, effectively throwing a consumer out into active traffic in an unsafe, defective vehicle.SECTION 3: AUTOMATIC SHUTDOWN TRAUMA & ACCIDENT RISKThe manufacturing defects caused an intermittent, un-commanded automatic The manufacturing defects caused an intermittent, un-commanded automatic engine shutdown condition. On 5 to 10 separate occasions while stationary at active traffic lights, the vehicle stalled10times

Filed Aug 31, 2026 · Engine, Transmission · NY

My car is consuming an immense amount of oil, the manufacturer recommends oil changes every 7,500 miles, I get an oil change less than 3,000 miles and on my last oil change i was told that there are oil shavings in my oil filter. I just got the SC9C2 update and now my engine is knocking. Car drives super rough and has signs of rod bearing failure. My engine is the Theta II 2.4GDI, a class action lawsuit was filed against Hyundai but my car wasn't included. I don't understand how Hyundai can know about this issue with this engine and not cover replacement. A car should at the very least last for the life of the loan, I am going to end up with no car and still making payments.

Filed Aug 12, 2026 · Transmission · 74,558 miles · NY

The contact owns a 2020 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the vehicle lunged forward. In addition, the vehicle almost stalled. No warning lights were illuminated. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact was informed that no fault codes were displayed. The contact was informed that the issues with the vehicle were just a case of bad luck. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact stated that the failure had occurred shortly after the vehicle was repaired under Technical Service Bulletin: 9C2, in May 2026. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 74,558.

Filed Jul 20, 2026 · Engine, Transmission · AR

I am currently burning through 2.5 quarts of oil approximately every 800 miles.

Filed May 26, 2026 · Engine, Transmission · 25,051 miles · NE

The contact owns a 2020 Hyundai Santa Fe. The contact stated that he received an unknown service campaign from the manufacturer indicating that a software update for emissions was needed. The vehicle was taken to a dealer where an ECU update was completed and an NP001-SC9C2 was installed for the engine and transmission. The contact stated that when his wife drove the vehicle home from the dealer, she noticed that something was wrong with the vehicle but did not specify the failures. The contact stated that the next day, while driving at an undisclosed speed, the vehicle hesitated and shifted improperly, and while depressing the brake, the vehicle accelerated forward. The contact stated that the failure persisted and became more prevalent in the morning after sitting overnight. The vehicle was then taken to the same dealer where a shift engine value reset, transmission value reset, shift adaptations were made (Part number 95447-6G200). The vehicle was repaired, but the failure reoccurred the next morning and has persisted every morning thereafter. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 25,051.

Filed Feb 26, 2026 · Engine, Transmission · GA

I was driving on the road and all of the sudden my car went limp and would only move 45 miles per hour. I took it to the dealer which I have lifetime powertran on my car. It has been there for over a month at the dealer. They asked me to provide all oil changes,services, and registrations. I did that and then fidelity asked them to tear down the engine again to see if I had carbon build up. Then after the dealer did that they ask the dealer to tear the motor down even further to see if the exhaust valve was bad and if it was bad they would not replace my motor. My car consumed so much oil that I was changing my oil so often. I have been renting a car just to get back and forth to work. In my contract it says that the exhaust valve is covered under my lifetime powertran. I feel like hyundai and fidelity are giving me the run around. I took very good care of my car and I have shown that. Hyundai has had alot of problem with there motors with the oil consumption and motors just going limp. I feel I will never buy a hyundai again. I am losing money everyday because of the dealer and fidelity. I need the motor replaced and it was no abuse on my part I took care of my car. I want fidelity to tell me how I abuse the exhaust valve. I did my oil changes and took care of my car. I am still paying on my Hyundai and can't afford another car. I have alot of medical bills that I pay. Any help would be great. Sincerely [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Dec 25, 2025 · Transmission · CA

Transmission issues with DTC light coming on, dealership did software update which did not resolve the problem. Transmission has rough shift and shuddering. Dealership is recommending complete transmission replacement.

Filed Dec 23, 2025 · Engine, Transmission · NY

2020 SantaFe Limited AWD with ~81200 miles. This is the 3rd or 4th time the P07410 code pops up with the Engine Check light. Hyundai said they found no issues and cleared the code, again. There was once when the code came up and it cleared itself after 50 miles. Not sure exactly what the cause is and Hyundai is saying "there is nothing wrong". Most recent occurrence Sept.4.2025.

Filed Dec 6, 2025 · Engine, Transmission · MO

I had been driving about 1.5 hours when I exited the Interstate and the car engine shut off at a traffic light. When I shifted the car into park and tried to restart the car, smoke filled the cabin. Unbeknownst to me, an oil leak occurred while driving. No warning lights or other indicators that anything was awry. I had the vehicle towed to the nearest Hyundai dealer. Though the suv is under warranty, they say the oil leak was caused by improper oil plug installation at the last oil change. The oil leak caused the motor to seize and the resulting damage is in excess of $10,000. Hyundai says the warranty won't cover this as it is a service issue. Jiffy Lube says their technician did nothing incorrect and they won't take responsibility for the repairs.

Filed Oct 1, 2025 · Engine, Transmission · 98,000 miles · CO

The contact owns a 2020 Hyundai Santa Fe. The contact stated that while driving at 45 MPH, the check engine warning light illuminated. After scanning the vehicle, the contact received a code for torque converter damage. The vehicle was taken to the local dealer, where it was diagnosed, and the TCM update was needed. The vehicle was repaired, but the failure recurred. The vehicle was taken back to the local dealer, where it was diagnosed with transmission failure. The vehicle was repaired, but the failure persisted. The oil light was illuminated and then turned off. The contact became aware that the engine oil was 4 1/2 quarts low, and it was determined there was an oil consumption issue with the engine. The vehicle was taken back to the local dealer, where it was determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and a complaint was filed. The failure mileage was approximately 98,000.