Hyundai Sonata Plug-In Hybrid check engine light comes on

Filed May 11, 2026 · Electrical · OR

On 12/20/25, the car - a Sonata plug-in hybrid - failed to start. When I pushed the "start" button, the dashboard display lit up w many clearly irrelevant error messages. Each time I pressed start, somewhat fewer error messages blasted toward me, and finally, no response at all. On 12/21/2026, the tow driver said it was the 12-volt battery. He gave us a jump start and we drove a few blocks. However, it failed at the turn lane while waiting for the light to turn. We turned it back on, bought a new battery, had it installed. On 12/29/25, my husband was driving. He turned into the intersection with a traffic light. As he was making the turn, the car simply quit. No warning. The car was dead, and blocking traffic! He pressed the start button to turn off the car, then again to turn it on. He was able to complete the turn and parked on the side of the road. By this time it had a "check engine" light on. He then drove slowly the few blocks back to our house. On 12/30/2025, the car was towed to a local mechanic. He said it threw the code PODE7, "almost certainly for a failed High Voltage battery." It was still under warranty, and we had the car towed to the dealership. After keeping it for 2 or 3 weeks, they confirmed the code and that the control panel needed to be replaced. We finally picked up the car (w new control panel) on 2/20/2026. In the meanwhile, we looked up Hyundai control panel repairs on a reddit forum. We found lots of chatter about it. Turns out it's a recognized problem in Sonata and Ioniq EV and PHEV's! Clearly, a car failing in the middle of an intersection, highway, etc is a safety problem and needs to have repair/replacements made BEFORE THEY HAPPEN!

Filed Sep 12, 2025 · Fuel system · NM

While driving car stuttered check engine light and check hybrid system flashed. Check engine lights stayed on until getting home. Next day. I scanned and code p0b68 was set.

Filed Mar 17, 2025 · Electrical, Engine · NY

While driving at a high rate of speed propulsion to the vehicle suddenly and without warning ceased, the electric and internal combustion engine were non-responsive (ICE stopped; hybrid motor didn't provide propulsion), the warning light said "Check Hybrid System. Turn off engine" I was put at risk because I was traveling at highway speed and was given no warning before the vehicle shut down. This has occurred nine times, I've reported all to Hyundai, they have had the car in the shop three times, the issue is not fixed. No, despite ODB2 error codes, the car has not shut down while a dealership is driving it. Yes, the vehicle has been inspected multiple times by Hyundai. Yes, always "Check Hybrid System. Turn off engine", in almost all cases the check engine light comes on after that, and in some cases additional lights such as "auto hold". This first occurred in Dec 2023, I was told the car was fixed (it wasn't) and happened again in October 2024. I haven't been able to drive my car since then.

Filed Mar 26, 2024 · Electrical, Transmission · CA

While driving the 2017 Hyundai Sonata Plug-In Hybrid, the car will begin to stall, a rapid number of audible beeps will start, the "Check Hybrid System" notification will pop up on the dashboard, and the "Check Engine Light" appears.. The car therefore cannot be driven anymore, and I am forced to pull over to the side. In order to fix the issue temporarily, I need to turn the car off and turn it back on again. Once this is completed, both the "Check Hybrid System" and the "Check Engine Light" disappears and the car can be driven again. An OBD Scanner is unable to find exactly what is going on as the "Check Hybrid System" and the "Check Engine Light" no longer appear. This has happened 4 times now within the span of 3 months. The people at risk are me (the driver), my passengers, and potentially everyone else on the road in my nearby vicinity as the problem occurs. This problem has been confirmed by the dealer in their Hybrid vehicles. This vehicle has not been inspected yet but that is an ongoing process.

Filed Jan 4, 2024 · TX

About 3 weeks ago I had just left my house, battery fully charged and gas tank full. I was coming down a hill to a stop sign and started braking. Suddenly the car seemed to lose power and essentially stopped moving. There was an error on the dash saying "hybrid system failure". There was barely able enough power to slowly pull the car over to the side of the road. I turned off the car and checked the battery in the trunk - I didn't see any obvious concerns. My husband got there 10 minutes later and we tried turning the car on again. It came on fine but there was an engine warning light. We were able to drive it without difficulty back to my house. I was unable to get a timely appointment at my local Hyundai dealer, so a couple days later My husband drove it to a local garage to see if they could figure out what the problem was. When he turned the car on again the engine light was no longer on. However, at the garage they were able to pull up a history of the car alerts and it confirmed that it said hybrid system failure. I have done some research online and it sounds like there was a recall on Hyundai sonatas hybrids for 2017 but I did not see a recall for the plug-in version of the hybrid. I searched online, however, and there were many other owners of Hyundai sonata plug-in hybrids that reported the same incident. I am hoping that a recall gets is issued for the plug-in hybrid as well so that more owners don't have the same problem. If I had been driving on the highway at 65 mph in a middle lane and my engine suddenly lost power it could have been fatal. Oh - one other recent problem I had that I'm not sure is related is that my car recently started losing electric miles very quickly. From the time it was purchased until a few months ago, it was losing plug-in miles at about 1 mi per year (i.e. each year a fully charged battery gave me 1 mile less). Then about 6 months ago it started losing electric miles very quickly - about 1/mo. Dealer said it was normal aging.

Filed Jun 27, 2023 · Engine, Fuel system · 65,000 miles · MI

The contact owns a 2016 Hyundai Sonata Plug-In Hybrid. The contact stated that on three separate occasions while driving approximately 65 MPH, the “Check Hybrid System - Turn Off Engine” message was displayed. The check engine warning light illuminated. The contact then stated that the vehicle decelerated and went into LIMP Mode. The vehicle was towed to the dealer however, the failure could not be duplicated. The contact stated that the failure recurred. The vehicle was taken back to the dealer but the failure could not be duplicated; however, the contact stated that he provided diagnostic test data to the technician that displayed error codes however, the failure could not duplicated. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was provided a case number. The failure mileage was approximately 65,000.

Filed Apr 7, 2023 · Electrical, Engine · OH

Problem began Dec. 2021. Has occurred on 16 occasions since then. Warning light "Check Hybrid System; Turn off Engine" comes on while driving. The car then shuts off the engine and there is a 100% loss of motive power. Sometimes is associated with very rough braking with the car "knocking'." On 3 occasions there has been partial/near complete loss of braking power. All incidents have occurred while under power, so far all while under 45 mph. No accidents yet. Two near collisions from the rear. Hyundai was notified of the problem Dec. 2021/Jan. 2022. After a month of testing they stated the car needed a new plug-in hybrid battery. One was not available and due to "supply chain issues" is still not available 15 months later. Dealership provided a loaner vehicle Jan to Sept. 2022. They requested their car back and Hyundai initially agreed to cover the cost of a rental car. I rented a car for 6 weeks in Sept.-Oct. 2022 at which point a new case manager informed me that Hyundai would not pay for a rental vehicle any longer (note: they did reimburse me the cost of those 6 weeks rental). Hyundai is well aware of the safety issues involved in driving this vehicle. However, they have chosen to ignore them. Their attorney, in a letter to the Ohio Attorney General's Office, blamed the lack of a plug in hybrid battery on supply chain issues (letter was Nov. 2022, at which time the battery was supposed to be available March 2023) and only stated that my vehicle was "drivable." Another warning message "High System Temperature; Switching to Hybrid Mode" has been occurring for a couple of years periodically. Since October 2022, the malfunction indicator lamp is always on and 99% of the time the "Check Hybrid System!" warning light also comes on after about a minute after starting the vehicle. On 3 other occasions the vehicle has entered into "limp home mode" instead of complete shutdown.

Filed Mar 30, 2023 · Electrical, Engine · CA

While driving the car getting error message on dashboard "Check Hybrid System Turn Off Engine", The Gas engine turn off and switch to continue on electric till able to pull on the side of the road. Turn Off engine, wait a min. Start car again and working fine. This issue appears randomly many times in the last two years while driving. Car was at dealer shop multiple times with no repair, was told we don't see active error message or they can't re-create the error. however scan show P261F error. Open Ticket with Hyundai #21018148 while car at the dealers for weeks at the time. each time told check engine got back on but not the message they are looking for.

Filed Oct 20, 2022 · Engine, Fuel system · 66,000 miles · PA

The contact owns a 2016 Hyundai Sonata Plug-In Hybrid. The contact stated while driving 70 MPH or faster in Hybrid Mode, the vehicle stalled. The HEV error warning light was displayed on the instrument panel. The check engine warning light was also illuminated. The contact turned off the vehicle and disengaged the HEV Mode for the vehicle to restart and function as intended. The failure occurred three times. The vehicle had been taken to the dealer however, the mechanics were unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was made aware of the failure and opened a case. The approximate failure mileage was 66,000.

Filed Apr 18, 2022 · Engine · CO

In January of 2022, my vehicle experienced a complete power loss while driving to work, leaving the car coasting down the road. A Check Hybrid System warning came up on the dashboard, along with several other warning lights, including Check Engine. Luckily, I was able to pull over without an accident occurring. Once stopped, the vehicle did restart and got me to and back from work. A diagnosis effort made at a local Hyundai dealership was unsuccessful as they could not replicate the problem and found no error codes in the auto's CPU system. I continued to drive the vehicle, hoping it was a one time deal, but since then, the identical situation has occurred three more times. I was extremely lucky that I had been in a position to safely pull off to the side of the road. The car has not been driven since March 19, 2022. After researching this scenario online, it appears to be the exact situation reflected in the Hyundai Recall campaign 175 from 2018, where the dealership remove the original VPD module and replace it with a Battery Management System (BMS) that contains an Overvoltage Protection Device (OPD). The recall is said to have been done on my vehicle, but the exact situation has reoccurred. Every time time the car lost power, it was preceded by a shuttering feel in the car, an alarm would go off and the propulsion system would just shut down and the Check Hybrid light would come on. Hyundai's only response has been to drive the car until it fails again (can you believe that?) and bring it in again for diagnosis. Even if that were to be done, the technicians and others on the road, would then be put at risk, as well, if they drove the vehicle in an attempt to get it to fail. I am the second owner of this car and the recall was supposedly done prior to my purchase. I now wonder if the dealer knew of the problem and that is why it was $2K below KBB. I cannot safely drive the car and can't sell it without loss once this safety issue is revealed. Thank you.