2013 Hyundai Sonata fuel system problems

Filed Nov 9, 2026 · Fuel system · GA · fire

Vehicle: 2013 Hyundai Sonata GLS Recall: 22V‑312 / Hyundai 227 Incident: Engine-compartment fire Date: November 8, 2026 Description: Smoke appeared while driving. I pulled over and turned the vehicle off, then it caught fire.

Filed Oct 12, 2026 · Engine, Fuel system · CA · fire

My 2013 sonata caught fire from the engine I was barely able to get out safely

Filed Sep 10, 2026 · Fuel system · PA

The safety recall (Hyundai Recall 227, the federal safety agency Recall 22V‑312) repair on my 2013 Hyundai Sonata (previously completed by a Hyundai dealership prior to my purchase in April 2026) has suffered a critical mechanical failure. In May 2026, within 30 days of driving the vehicle, the recalled safety component completely failed while the vehicle was in operation on a public roadway. This sudden failure created an immediate safety hazard, resulting in complete fuel loss, forcing me to immediately pull over and have the vehicle towed to a repair facility (Meineke).An independent mechanical inspection confirmed that the exact component covered under the manufacturer's original safety recall had failed again. Because a critical, manufacturer-designated safety recall remedy failed to permanently correct the underlying defect within 30 days of use, this vehicle remains an active safety hazard.

Filed Jul 17, 2026 · Engine, Fuel system · PA · fire

When my father was driving, the vehicle stalled out with no prior odd activity. He pulled over to the side of the road and attempted to start the vehicle. He saw smoke, opened the hood, saw flames and cleared the area of the vehicle. Due to the large Hyundai/Kia engine recall for his year of vehicle, the engine had been replaced 2-3 times and ONLY EVER been serviced by the dealership. We do not know if all recall repair work had been done, because there was also a fuel line recall which was "fixed" in 2020 and 2022.

Filed May 19, 2026 · Electrical, Fuel system · TX

This is a well-known and widely reported issue: 2013 Hyundai Sonata Hybrid car, which has recently experienced the following dashboard alert: "Hybrid system warning! Safely stop and do not drive." When the car is pulled over and shut down and sits for roughly 10 minutes, it starts up just fine and runs again for an undetermined amount of time, and then the alert will go off unexpectedly. This has happened twice, once the car was driven about 4 miles, and the alert came on, and the second time the alert came on as the car was started for the first time of the day. The car repair shop indicates that there are no codes saved when this happens. This is apparently a documented issue, where the codes are not saved, and difficult to diagnose by repair shops and dealers. It could lead to the vehicle completely shutting down while driving at highway speeds within traffic, which could cause a serious accident involving multiple vehicles and people. Why is this not recalled by the dealer and fixed? This has been reviewed by the dealer and by an independent repair shop. Is the federal safety agency waiting for the death count to require the manufacturer to address the issue?

Filed May 12, 2026 · Engine, Fuel system · VA · crash

Engine was replaced in 2023. In March 2026 there was a fuel line leak to include fuel misting near heat components. The vehicle was in a fender bender but Hyundai determined this did not cause the leak which eludes to this being a faulty installation of the engine replacement associated with the recall. I’ve reviewed my 2023 engine replacement invoice. I see the Service Kits were used to transfer parts from my old engine, but the High-Pressure Fuel Pipe (35340-2G710) is not listed. Per Hyundai's GDI service protocols and Recall 180, that pipe is a one-time-use safety component that should not be reused during an engine swap due to fire risk. Since it is leaking now, it’s clear the old pipe was reused and has failed. I'm asked for a goodwill replacement because this was a procedural error during the 2023 warranty work and was denied. This is a safety issue.

Filed May 8, 2026 · Airbags, Engine · CA

I went shopping notice needed gasoline filled the tank 3/4 the next day I smell gasoline on My2013 Sonata Hybrid VIN [XXX] inside the car and I did not notice any light alerts etc., just the smell of gasoline inside the car. I ask for a ride I was scare to drive to the dealer on Monday 5/6/26 around 12:30 pm I called the dealer I was gonna dropped the car they told me diagnostic would take 3 days , I was afraid to cut on fire since my gas left a big stain and was wet gasoline in the parking lot at work., I called Hyundai USA mentioned the problem i notice there is a recall for gas pump leaking and causes gas tank to crack Recall for 17V‑226 for fuel pump leaking 0n Hyundai sonatas hybrid 2011-2016 my car is in the Hyundai Dealership [XXX] [XXX] They called me telling me my gas tank is cracked cost of repair labor 2800.00 and 280.00 diagnostic charge and is ready for pick in 30 min No recalls I must pay for this service INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 27, 2026 · Engine, Fuel system · FL · fire

Car engine caught fire. Allstate notified pictures provided below.

Filed Apr 23, 2026 · Fuel system · FL

the federal safety agency Recall Number22V312000 I am writing to formally file a complaint regarding my 2013 Hyundai Sonata (VIN: [XXX] ), which is subject to a manufacturer recall #189 due to a fuel line defect posing a fire risk and potential severe injury. Today, I visited Wallace Hyundai in Fort Pierce, Florida, and the service manager Mr. Louis LaRussa and associate employed what I can only describe as a warranty circumvention tactic. They repeatedly delayed my recall repair by claiming I must first complete other optional recalls, unrelated to the fuel issue. They stated that they would not be paid by the manufacturer unless all recalls were done together. This is not only unprofessional but also a disregard for the serious safety hazard posed by this fuel line defect,they prioritize dealership financial interests over customer safety and contradicts the purpose of a safety recall. Furthermore, I was told I would need to leave my car for days or even weeks because parts supposedly must be ordered. As this is a nationwide recall, I expect a swift, ready-to-implement solution. I demand immediate action from Hyundai to honor the recall and ensure my safety is prioritized. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 31, 2026 · Engine, Fuel system · AZ · fire

Engine was replaced couple of months ago due to a recall and today 3/30/2026 I'm pulling up to my driveway getting home from work in my car starts smoking it catches on fire