I will take 10k$ for the car or a new engine and steering, damages fixed. . I also need a rental by April 10th and $300 for inconvenience thus far. The engine stalled twice when driving over 2 months! The lawyer won't be forgiving.
2015 Hyundai Sonata engine complaints
Page 3 of 23: complaints 41 to 70 of 651, newest first, as owners wrote them.
Engine seized driving down the interstate doing 65 MPH in rush hour traffic could have been rear ended or hit vehicles around me trying to get off the road. Complete loss of power. Power steering was still active brakes were barely working. No warning lights (I had the knock sensor recall performed). Engine simply locked up solid. I was able to safely make it to the disabled vehicle lane and put the car in park. Engine had no sludge buildup and looked excellent once it was disassembled by the dealer. All engine bearings had spun. Engine was completely replaced under the extended warrenty.
Hyundai dealership diagnosed my vehicle with engine failure, including a failed compression test and cylinder with no compression, and stated the engine required replacement. The dealership later refused to process the repair and attributed the issue to oil condition, contradicting their prior confirmed diagnosis. The vehicle became undrivable after the diagnosis and has remained in that condition. The refusal to address a confirmed engine failure raises concerns about a known defect and improper denial practices.
The bearing failure from the metal debris had been progressing silently for a long time. You can’t feel or hear it happening gradually. Then at some point the damage crosses a threshold where: ∙The oil can no longer circulate properly ∙The crankshaft bearings completely fail ∙Internal metal parts make contact with each other ∙Everything locks up instantly
My engine is a class action lawsuit and Hyundai refuses to honor their extended warranty because my title has a brand on it. (Odometer issues) My car has been a the dealer for a month and Hyundai refuses even though it's a safety issue and a defect in their design. I want a new engine. The car is perfect otherwise.
FEDERAL REPORT ON TECHNICAL OBSTRUCTION AND WARRANTY FRAUD (THETA II SETTLEMENT) TO: the federal safety agency FROM: [XXX] VIN: [XXX] REPAIR ORDER (RO#): XXX VEHICLE LOCATION: Hyundai Shop - [XXX] HYUNDAI CORPORATE CASE: #XXX STATE COMPLAINT (AZ AG): XXX I. CHRONOLOGY OF EVENTS AND EVASIVE TACTICS All documentary evidence has been formally submitted to Hyundai Motor America’s National Consumer Affairs Department, addressed to Case Manager Bryan, at [XXX] and via the official email: [XXX] . STEP 1: Falsification of Title Status (Code A99) Hyundai initiated its denial by alleging that the vehicle held a "Salvage" title status, citing internal code A99. EVIDENCE: I possess a Certified and Stamped Motor Vehicle Record (MVR) from the Arizona MVD, as well as my Clean Title. Mr. Bryan categorically asserted that code A99 "cannot be removed," thereby deliberately disregarding an Official State Certification. STEP 2: Allegation of Negligence (Karen) Corporate representative Karen claimed via telephone that the vehicle's failure was attributable to "negligent maintenance." EVIDENCE: The Official WebDCS report—printed by Mr. Ismael Barragán (Service Drive Manager)—completely refutes this claim; the Blue Link service history indicates "0 FINDINGS." STEP 3: Fabricated Diagnosis and Breakdown of Improper Charges After being compelled by Mr. Bryan to take the vehicle to the dealership for a diagnosis, the narrative shifted to an "Oil Pump Failure." Mr. Ismael Barragán (Service Drive Manager) presented a billing estimate to the customer under Repair Order (RO) #XXX, itemized as follows: Mechanical Diagnosis: $193.00 USD Engine Replacement/Rebuild: $11,980.58 USD TOTAL DEMANDED FROM CONSUMER: $12,173.58 USD TECHNICAL EMPHASIS: The Blue Link report (showing 0 Findings) serves as irrefutable INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine completely seized while driving.
Rod bearing failure
I was driving on the highway and the engine shut off but everything else remained on. I drifted to the breakdown lane and turned the car off. It would not start again and the car began acting up by turning lights on and off, telling me to check the tire pressure, and not unlocking the doors. I then saw some very light smoke from the engine compartment. I popped the hood and looked and saw a glow on the bottom side of the engine area. Then the car just went up in flames.
The contact’s daughter owns a 2015 Hyundai Sonata. While driving and coming to a stop, the vehicle lost motive power. There was no warning light illuminated. The vehicle was towed to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The dealer informed the owner that the failure would not be covered under warranty due to a lack of engine maintenance on the vehicle. The owner provided the maintenance records. The manufacturer was made aware of the failure, and a case was opened. The failure mileage was approximately 124,000.
Check Engine light is flashing on dashboard. Reduced Vehicle speed. Car will not drive beyond 62 miles.Lost of power during acceleration.
My 2015 Hyundai Sonata experienced Service Campaign TX3, TSB# 15-01-022, with an error code of P0010. My car was in the repair shop from Thursday, February 19th, until Thursday, February 26th, being repaired. This cost me roughly $2,300.00 out of pocket. When I attempted to file for reimbursement through Hyundai, I was told they were not reimbursing me. My car experienced failure the first of February. When my mechanic investigated what had happened, it was in fact, due to the service campaign.
I just got this car about 2 months ago and now I am being told I need a new engine. I just looked up 2015 hyundai sonatas and see that this model does have repeat issues of engine failure so I do not understand why this VIN number is not under the recall list since I am having the same issue
Engine has knocking sound. Sudden loss of power and hesitation when accelerating
The vehicle suddenly lost power while driving on a public roadway. Immediately after, the vehicle began producing a large amount of smoke. The smoke quickly filled the cabin, making it difficult to breathe and creating an urgent safety hazard. My passenger and I had to exit the vehicle right away due to the amount of smoke. We were exposed to smoke inhalation and were stranded on the side of the road in unsafe weather conditions for over an hour while waiting for a tow truck. I later learned that the vehicle had an open recall related to engine issues; however, I was never notified of this recall. Regardless of recall status, the sudden loss of power combined with heavy smoke and potential fire risk created a dangerous situation that could have resulted in serious injury or death. I believe this issue represents a serious safety defect and fire hazard that could endanger other drivers.
Component/System Failed: Engine – connecting rod bearing failure consistent with Hyundai Theta II engine defect subject to federal recalls and Consent Orders. The vehicle previously received Recall Campaign 953 (KSDS software update), intended to detect premature rod bearing wear. The engine is currently knocking and has been diagnosed as requiring replacement. The vehicle and engine are available for inspection upon request. Safety Risk: Rod bearing failure can cause sudden engine seizure or stall while driving, creating a significant crash risk due to loss of power steering and braking assist. Engine failure DID occurr despite prior recall software update, indicating potential recall remedy ineffectiveness. Sudden stalling in traffic placed myself and others at risk of collision. Dealer Confirmation: Hyundai of North Charleston confirmed through warranty history a prior engine replacement request (PA) was submitted by a previous owner but denied. The recall repair was never performed. Current diagnostic findings indicate engine failure consistent with known recall defect. However, Hyundai has refused to perform further inspection or goodwill repair solely due to the vehicle’s salvage branding. Inspection History: The vehicle has been inspected by a Hyundai dealership. No engine replacement was completed. Hyundai Customer Care has updated case notes but is declining remedy based on title status rather than mechanical condition. Warning Lamps/Symptoms: The vehicle previously received KSDS software update. Engine knocking developed consistent with rod bearing wear. The software did not provide effective prevention of engine failure. The engine now requires replacement. Hyundai is refusing recall-related remedy due to salvage title (predates my wonder ship by many years), despite federal recall obligations applying to the vehicle VIN. This complaint concerns potential failure of recall remedy effectiveness and denial of defect-related inspection.
While driving on the freeway, my vehicle experienced a sudden and catastrophic engine failure. The check engine light began flashing, the vehicle lost power, and I almost lost control of the car. I barely had time to pull over to the shoulder to avoid an accident. The vehicle was towed to a Hyundai dealership. The engine does not start and the engine block is cracked. Hyundai denied coverage stating that a software update (Campaign 953) was not installed. Campaign 953 is only a detection update and does not repair or prevent internal engine failure. This is a serious safety issue.
Was driving car and it went completely hot. Towed to a dealership and they said was not drivable and that the radiator support and radiator hose needs replacing and eventually the Drive CV left and front will need replacing or I will be stranded on side of road.
I have been dealing with issues with the turbo that cost over $3k out of pocket to get "fixed" only to have a part go bad and needed to be replaced. Now the engine is bad and needs to be replaced. The dealership is horrible at being honest and treat me as if that's not my only vehicle. I ask for a loaner car and thery never respond!!
The car is burning a quart of oil a week.
Engine locked up
On January 21, 2026, while driving on I-495 at highway speeds (e.g. 50-60 mph) in heavy traffic, my car made a "clunk" sound and I suddently was unable to accelerate. There were no warning lamps, messages, or other symptoms prior to the failure, but immediately when it happened several warning indicators, including the check engine light, oil light, and tire pressure indicator, lit up. The electrical systems and brakes appeared to still work, but the best I could to was coast onto the nearest shoulder and call for an emergency tow. I waited on the shoulder of a busy highway, in the dark, for over an hour. My car apparently has a type of engine that is known for catastrophic failure, so I assume that is what happened. I had the car towed to a Hyundai dealership and they confirmed that the engine needs to be fully replaced.
The oil in the car burns quickly. After driving 2000 miles, there is no oil left. I do not have any oil leaks anywhere. It’s just burning oil. This has been consistent since I’ve gotten the vehicle.
While driving my 2015 Hyundai Sonata, the vehicle suddenly lost power and entered limp mode. A loud engine knocking noise was present, and acceleration was severely limited, creating a safety risk in traffic. The check engine light illuminated at the time of the failure. An independent mechanic confirmed diagnostic trouble code P1326, related to the engine knock sensor detection system designed to detect early engine bearing failure. The condition occurred without warning. The vehicle is currently not being driven to prevent further damage and is available for inspection upon request. Sudden loss of power while driving poses a serious safety hazard. This appears to be a known engine defect affecting similar vehicles.
My 2015 Sonata will stall out dropping speeds to 12-24 when i slightly merge, when I turn ect. Then it won’t accelerate for what seems like 10 minutes realistically 2 minutes maybe 3 Then will slowly regain speed. I’ve almost wrecked twice Share care with daughter and she’s been victim to it way way more. This is scary and Hyundai won’t stay behind their product Local dealership won’t fix recalls so we have to go over 120 miles for repairs. The recall isn’t even for transmission engine
on the day of Friday may 16, 2025. I was returning from work on 35 going south in Dallas, Tx. the engine seized leaving my vehicle in a neutral state. I was in the furthest left lane(passing lane). Lord willing I had enough motion to safely exit on Illinois ave without injury of myself or others. the starter could no longer turn the flywheel indicating to me that the crank shaft had seized. i inspected the oil; it was low but no warning light ever came on(the dealer recently stated the oil was fine when they performed a multipoint inspection(5/10/25) when I went in for the gov mandated theft software update as my car had recently been attempted to be stolen), no sort of warning light came on, nor did the ksds update do anything just like countless other kia/hyundai owners who's engine seized on the interstate. I towed the car to clay Cooley Hyundai Dallas because my research indicated that theta 2 engines had government mandated extended warranty even for subsequent owners however as I didnt drive it often & had only replaced the oil(I change every 3k and was soon to do another) once, because I've only owned car for around 6k miles(purchased 10/30/24 I think)before it seized. Hyundai denied txxi claim, stating engine didn't seize due to connecting rod bearing failure, further stating, it was neglect. they said my valve train look terrible. well its going appear so as the theta 2 was inherently known for poor oil flow, major oil consumption, rough crankshafts & improper deburring, all of which lead to premature ware of internals&seizing. also they stated there weren't enough oil changes on the carfax in general, well not all shops report auto service so there isn't going to always be records. furthermore they were failing even in the range of 25k-60k, indicating they were still failing with records of timely service. to my knowledge they didnt perform what I believe they're Mandated to do i.e vid/pic evidence that they cant turn the crank, a bct test, oil level etc.
The vehicle experienced sudden engine failure due to rod bearing damage. The engine seized without warning and required towing. A Hyundai dealership confirmed rod bearing failure consistent with known Theta engine defects. Hyundai denied engine replacement coverage because a software update (Campaign 953 / KSDS) was not completed; however, I never received notice of this campaign. The campaign does not appear on the federal safety agency VIN lookup for my vehicle, and it was still listed as outstanding in Hyundai’s system at the time of failure. The sudden engine failure created a safety risk due to loss of power.
i've had my 2015 hyundai sonata now for A year. i took it to the hyundai place to have recalls on the security fixed. and told them about the valve cover gasket leaking. they said they fixed it. however every since i took it to the dealership i have had nothing but problems. my car makes a rattling noise when i accelerate, i smell a strong gas smell occasionally at random times but always while driving. my driver brake light has never worked, my driver headlight keeps blowing, my airbag light is now coming on randomly, my car has a bag vibration while going down the road, when i let off the gas it stops and i have replaced tires and still it won't go away no matter what i have done to fix it , and there has been many times after i return home the smell of something burning as off something is on fire is coming from my car. i have even been in panick thinking something today home was on fire but the smell was coming from my car. and others have even stated they smelled it as well. i've already taken out two loans to fix the valve cover gasket and the fuel pump filter, i can not keep taking out loans to fix problems that appears to be problems from the manufacturer and same problems others have had due to malfunctioning issues. i have children that ride in my car, i would hate for someone to get hurt or worse bc of manufacturing problems. then hyundai would have a bigger problem on their hands.
The engine has failed and I was then i formed that there was a arbitration settlement that Hyundai were replacing engines under this settlement. I was not informed of this and now they are saying it has expired. I would like for them to honor this and repair my engine under the Hyundai Theta engine defect lawsuit
Vehicle is putting out a very strong gasoline odor, especially when sitting idle. I looked up previous recalls on the vehicle and seen where there was a recall I believe in 2022 for similar issues.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2015 Hyundai Sonata?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history