My vehicle suffered a sudden engine failure that Hyundai confirmed was caused by a recall defect. Hyundai replaced the engine but is refusing to reimburse several necessary expenses incurred solely because of the recall-related failure. There was no warning lamps or messages prior to failure. Expenses: Monthly loan payment while car unusable – $242.55 (REFUSED) First tow: Highway → Old Ox – $160.00 (REFUSED) Second tow: Old Ox → Alexandria Hyundai – $170.00 Third tow: Alexandria Hyundai → Exxon – $200.00 Fourth tow: Exxon → Fitzgerald Hyundai – $205.00 Alexandria Hyundai inspection – $199.99 (REFUSED) Old Ox diagnostic fee – $539.24 (REFUSED) Rental car 10/4–10/8 – $208.90 Rental car 10/29–11/1 – $151.00 Total requested: $2,076.68 Total refused: $1,141.78 Hyundai claims the initial tow isn’t covered because it wasn’t to a Hyundai dealer, that independent diagnostics “don’t qualify,” that a Hyundai dealer’s inspection fee is not reimbursable because dealers are “separate entities,” and that my loan payment is not covered. These denials contradict Hyundai’s recall guidance and the requirement to reimburse reasonable and necessary costs caused by a recalled defect. This engine failure also placed me in real danger. The engine died suddenly at highway speed, leaving me stranded in an unsafe location with no control over the tow provider. Hyundai Corporate then instructed me to bring the car to Alexandria Hyundai, creating the clear impression those fees would be reimbursed. I relied on their guidance in good faith, and only after following their instructions did they refuse reimbursement. I feel misled, financially harmed, and exposed to unnecessary risk. Due to Hyundai’s conduct and selective denial of valid recall-related expenses, I am preparing to escalate this matter civilly and pursue punitive damages in addition to reimbursement. I request the federal safety agency’s assistance, as Hyundai’s actions appear inconsistent with recall obligations. Thanks, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMAT
2015 Hyundai Sonata engine complaints
Page 4 of 23: complaints 71 to 100 of 651, newest first, as owners wrote them.
Engine failed on 10/24/2025. Hyundai will not honor class action suit to repair engine at no cost to owner. Hyundai state recalls were not completed on the car prior to engine failure. We agree, recalls were not completed prior to failure. Because we never received notification. Had we received notification we would have acted on the recalls immediately and not put our safety, that of our children or the general public at risk by driving a vehicle with an engine that could fail at any moment. We have contested Hyundai's rejection several times to no avail. We are seeking guidance in resolving this mater.
My 2015 Hyundai Sonata has a defective engine. The motor failed unexpectedly even though the car has low usage and has always been maintained properly. I was informed that many Hyundai engines from these years came with manufacturing issues, and mine appears to be one of them. I am requesting that Hyundai replace the engine or provide a proper solution since this defect is not due to misuse but a faulty motor that came from the manufacturer. I need this resolved as soon as possible because the car is not running at all.
While I was driving at approximately 55mph, a loud clank happened and the car stalled, and smoke started pouring out of the hood and through the vents into the cabin, and I was leaving burning pieces behind on the road. I pulled over, ran to the back to get my dogs out of their crash tested kennels in the backseat, and both rear doors & passenger front door were locked. I ran up front to unlock them, and the unlock button did not work. I tried the unlock on the keys and it did not work. Due to having a recommended crash safe kennel set up it was not possible to crawl into the back to open it from the inside. My dogs were trapped in a car that was filled with smoke and on fire for over 2 minutes while I debated breaking the windows. I managed to fish a wire into the back to unlock and pull the door open from the inside of the back doors. The car stopped burning but was still smoking for several minutes after & I was able to clear the smoke to make it safe for my dogs to wait for a tow. When the mechanic looked at it he said the engine blew up due to the rod shattering into the block, destroying the entire engine and spilling oil which lit on fire. Mechanic recommended I contact Hyundai for engine replacement as this was a known issue with other 2015 Hyundai sonatas which were recalled due to risk of a defect rod knock causing the rod to shatter causing high speed stalling. Hyundai says my engine was not included in that specific recall. I included photo of the shattered rod which fell out when the mechanic lifted the vehicle
I heard noises immediately after purchasing the Sonata. I took it back in to Carmax ( where I bought it from) multiple times and was told they didnt find anything wrong. As time went on, I took my sonata to Hyundai dealer to get checked out. 1st time they told me, Hyundai wouldnt cover the cost to check out engine & that it would be $700 to take a look. The 2nd time, I was told we cannot check it out because the engine light isnt on. Basically they couldnt scan/check codes without the light being on. I suggested that if they just rode around the block, that they would notice that there's an issue. They still said no. Then back in February, I took back to Hyundai dealer again & they did check it out because the engine light was now on. That inspection came back as the cylinder was bad. Hyundai doesnt cover it because at that point it was past 100k miles and I was not the original owner. I asked about 100 mile.warranty when I bought it at carmax and was told yes 100k warranty still applies. So upon further research, hyundai has had problems with this year/make/model/ engine type before. If they knew something was wrong with it, why not just say so & fix it? Or as soon as I seen the first issue, check it out and repair it for me?
On the highway, my 2015 Hyundai Sonata suddenly began making a squealing or metallic rattling noise. At first, I thought it might have been something loose inside the vehicle. Within moments, the check engine light began blinking, followed by several additional warning lights and a pronounced knocking noise from the engine area. Immediately after the warning lights appeared, the vehicle entered a reduced-power “limp mode” and began rapidly losing speed, even though the engine was still running. Because this occurred at highway speed while surrounding traffic was traveling normally, I had to pull onto the shoulder to avoid being struck. This created a significant safety hazard. I was stranded for approximately 45 minutes on the shoulder, at risk of being struck by other vehicles passing at high speeds. A tow truck arrived before the highway patrol, and the vehicle was towed home. When I returned home, my code reader pulled two versions of diagnostic code P1326, which is associated with potential engine bearing failure in Hyundai Theta II engines. The issue has since been inspected by the dealership, who confirmed the presence of the P1326 code. The vehicle is currently available for further inspection upon request. There were no prior symptoms that I was aware of leading up to the incident other than the brief squealing/rattling noise and the sudden warning lights immediately beforehand. The failure happened suddenly and without warning, causing an immediate and unexpected loss of speed and creating a dangerous situation on the highway.
1. Description of Safety Problem: My vehicle experienced a sudden catastrophic engine failure while driving, resulting in a complete loss of power and severe engine knocking. This is a known safety defect related to the Theta II engine (specifically, connecting rod bearing failure, often referred to as the KSDS defect) that poses a severe risk of stalling and engine fire. The failure rendered the vehicle inoperable and unsafe. 2. Manufacturer's Failure to Honor Safety Recalls & Warranty: Despite this being a known, documented defect covered by Hyundai's own Technical Service Bulletin (22-EM-00H-1-1) and the TXXI Class Action Settlement—which provides a "Limited Lifetime Warranty" for this issue—Hyundai Motor America has repeatedly and wrongfully denied my warranty claim. Furthermore, I discovered through Hyundai's official campaign portal that my specific VIN had multiple unperformed safety and service campaigns, including critical Engine Control Module (ECM) updates (Campaign #953) designed to monitor and prevent this exact type of engine failure. Hyundai's failure to ensure these critical updates were performed constitutes negligence and directly contributed to the safety failure I experienced. 3. Evidence of Manufacturer Bad Faith: I have obtained documented proof that Hyundai has approved and performed zero-cost engine replacements for the identical defect on vehicles with mileage exceeding 180,000 miles. This proves that my denial is arbitrary, discriminatory, and demonstrates a pattern of bad faith in applying their safety-related warranty extensions. 4. Escalating Consequences: Due to Hyundai's refusal to honor its warranty, the dealership has now threatened a mechanic's lien and is charging $50 per day in storage fees. The manufacturer's failure to address a known safety defect is now causing active financial harm. 5. Requested Action: I urge the federal safety agency to: Investigate Hyundai Motor America's systemic failure to honor the safety warranties and complete
The contact owns a 2015 Hyundai Sonata. The contact stated that while driving at 40 MPH, there was an abnormal sound coming from the engine before the vehicle stalled. The contact pulled over to the side of the road. The check engine warning light was illuminated. A dealer was contacted. The vehicle was taken to the dealer, where it was diagnosed and determined that the knock sensor had failed, and that the engine needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and offered a buyback. The approximate failure mileage was 155,000.
The contact owns a 2015 Hyundai Sonata. The contact stated that while driving at 40 MPH, there was an abnormal sound coming from the engine before the vehicle stalled. The contact was able to pull over to the side of the road. The check engine warning light was illuminated. A dealer was contacted. The vehicle was taken to the dealer, where it was diagnosed and determined that the knock sensor had failed, and the engine needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and offered to buy back the vehicle. The approximate failure mileage was 155,000.
Knock sensor has gone bad
Engine malfunction putting my safety at risk. This is a known issue under Hyundai’s active campaign, and the issue was verified by the manufacturer. A PA was required and Hyundai is refusing to repair vehicle due to service records prior to my ownership not being available. This issue was identified on 9/4/2025.
I was driving (I4 highway) when my car suddenly stalled, causing engine failure and almost putting my life at risk, causing an accident. This car has a factory recall for engine damage. I took it to the dealer, and Hyundai refuses to accept the engine repair because the title is rebuilt. The car has no damage to its original engine and is ready to be replaced. They don’t want to assume responsibility.
Engine Failure for a 2015 Hyundai Sonata SE 2.4L In-Line4 (144CI) VIN(F) Odometer 141477. Engine starts then runs hot starts clunking and sputtering and then shuts off. Burns oil and has caused a complete exhaust failure. Vehicle cannot past emissions text. The vehicle was a safety risk as the engine may catch fire and the vehicle was use for transportation to work and children to school. The Engine Light stays on constantly the engine oil light comes on as oil is burned off. Vehicle was purchased at a third party dealer and as the new owner did not receive recall notice or settlement notice.
The engine light started to come on and go off. I had the spark plugs changed and I kept regular maintenance done on oil changes and tune ups. Now my engine is knocking and the vehicle is in limp mo. I took to dealership for extended warranty it was denied due to not properly maintained I turned an additional maintenance records the claim was never reevaluated I took my car home which is only 3 mi away in the engine caught on fire before I could get home $9,000 loss I don't know what to do
Vehicle lost power leaving me stranded. All lights on dash came on, lost power, and barely able to steer to get off the road. We had to have it towed. The vehicle was towed to our mechanic, who states the motor seized up. Mechanic states there is no repair for this issue. Car has just been paid off. Now we have nothing!
I started taking my car to the dealer in 2023 for engine problems, including high oil consumption and stalling. The dealer kept telling me to return in 1,000 miles instead of fixing it. The issue was officially documented again in March 2024 (RO #131797) with ‘Cause: high oil consumption.’ Despite paying \$356.46 for repairs, the problem was never resolved and now the engine has failed
The engine light started to come on and go off and when I got the codes ran, it said something along the line of misfire. I had the spark plugs changed and I kept regular maintenance done on oil changes and tune ups. Now my engine is knocking and the vehicle is in limp mode.
Investigations Team, We are the owners of a 2015 Hyundai Sonata, purchased in 2016 and still in use today. This vehicle is suffering from severe engine issues linked to the Theta II engine defect, which has been the subject of recalls and class action lawsuits. For nearly a year, we have been forced to add approximately 2 quarts of oil every week due to extreme oil consumption. This is unsustainable, unsafe, and clearly linked to the known recall defect. The most serious incident occurred when my wife was driving on [XXX] in North Carolina, and the vehicle suddenly lost power. It could not maintain safe highway speed and had to be pulled off the interstate, requiring a tow more than an hour back to our home. This was a frightening event that could easily have caused a crash. We later discovered that our vehicle was included in the Theta II engine recall, but we never received notice due to a change of address. Despite this, Hyundai Motor America has refused to help, citing that the recall was “closed.” Shockingly, one representative even told us to “keep putting oil in it until the engine blows,” at which point they might reconsider. This is an unsafe and negligent response to a well-documented safety defect. To make matters worse, when reviewing our VIN for other recalls, we found that the panoramic roof air dam recall was falsely listed as “repaired.” We never received notification of that recall, and the repair was never performed. The air dam detached years ago, and we have avoided using the sunroof since then due to noise and safety concerns. We have contacted Hyundai corporate multiple times, and we also filed a formal complaint with the North Carolina Attorney General’s office. To date, we have received no resolution and no meaningful response to our case from either Hyundai or their representatives. Summary of Issues: 1. Failure to notify us of the Theta II engine defect recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2015 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the vehicle failed to accelerate above 10 MPH. The vehicle was driven to the shoulder of the road. In addition, the check engine warning light was illuminated. The vehicle was towed to the dealer, where it was diagnosed with a failed knock sensor. The contact was informed that the engine needed to be cleaned. The vehicle was not repaired. The contact referenced an unknown extended warranty for the knock sensor; however, the contact was informed that the repair was not covered under warranty or recall. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 103,500.
P1326
I had a standard oil change done on my car and it was running fine afterwards. Later that evening, my car started smoking and spontaneously burst into flames from the hood. The fire originated in the hood of the car and melted the entire front of my car as well as the entire inside. It burned a lot of fuel and oil, which leaked onto the ground and continued burning on the ground. My car was overtaken by flames in a matter of a few minutes. It burned so fast that there was nothing I could do to stop it. I was not aware of anything wrong with my engine or fuel lines, or anything like that. However, something was very wrong for the engine area to catch fire like that spontaneously.
The contact owns a 2015 Hyundai Sonata. The contact stated that she checked the engine oil every Sunday and became aware that the oil level was low. The contact stated that the vehicle was consuming an excessive amount of engine oil. The contact was adding one quart of engine oil every ten days. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 84,000.
I have contacted the guy that sold me the car he Refused to fix the recall which is my motor I need Something done , Hyundai won’t Honor their Recall .
My car 2015 (Hyundai Sonata)started leaking oil, it only had 50,000 miles. my mechanic said the motor had too much pressure and kept pushing oil out. He advised me to take it to the dealership for a motor recall. The dealership gave it back with a list of things to fix. replaced the valve cover gasket but still leaked oil. I found out these cars have an oil leak problems that are not being addressed. My car went up in flames 2 weeks later. I have done everything I could to save this car but nothing saved it. My grandkids were in the car and it had traumatized them.
I bought this sonata one month ago. Driving down [XXX] in bonita springs Fla the car shut down. No noise all dash lights came on I got to a safe place. Sat in the parking lot of fresh market for at least 30 minutes went to start it and nothing happened. No crank nothing. AAA came towed it to my house. The filling day I checked the battery it is good. So had it towed to Scotty’s automotive. They called me Friday morning and said the motor was locked up. According to Carfax the car was at brand ton Hyundai in May of 25. I called after I bought the car Carfax said they found the alignment was off. I called to see if they did the alignment they said they did not do it. The wholesale it. My thinking is they did service it according to Carfax report and knew there was signs something and wholesale it. I did not buy it from Brandon Hyundai I bought it from a guy in Leigh acres Fla. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
We were informed by our mechanic that the engine needed replacement due to a timing chain issue. The engine warning light was blinking continuously, and the RPM would not rise above 1.9 even under acceleration. Upon further inspection, the mechanic found that the issue extended beyond the timing chain - the entire engine appeared to be failing. When we changed the engine oil, it became dirty almost immediately, and visible metal shavings were present in the oil, indicating internal damage. These symptoms suggest potential engine failure, which is consistent with known issues in some Hyundai Sonata models. We believe this may be related to broader engine defects and request that this be investigated for potential recall eligibility.
Using 5 quarts of oil in 3 days.
The car was on a major highway, went to pass another car and the engine stopped working. While trying to get the car off the road there was almost an accident involving on coming traffic.
The turning signal gives the opposite signals sometimes.
The car burns oil. I have to put oil in it every few weeks. Also will start shaking while acceleration. I replaced engine coils several times. Main issue is burning oil, don't know why.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2015 Hyundai Sonata?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history