2016 Hyundai Sonata: engine stalls while driving

Filed Sep 15, 2026 · Engine · IN

I am concerned that the engine may seize or stall without warning while driving, creating a risk of crash, injury, or death. The Theta II engine defect is known to cause engine seizure, stalling, and fire. Hyundai has denied warranty coverage based on mileage and second-owner status — both of which are explicitly prohibited as denial grounds under the Settlement — leaving me driving an unsafe vehicle.

Filed Aug 11, 2026 · Engine · PA

My Sonata 2016 suddenly lit up the Check Engine icon, which was blinking. It is available for inspection request, as it's in the shop right now. Added 2 qts of oil just to be safe. Was hoping the light would go away in the morning. It didn't. The car was sputtering and jerking while I was attempting to get where I was going, so I drove a little slower so it wouldn't stall out, which would have caused someone behind me to crash into me if it stopped suddenly. My mechanic said it was engine failure, possibly due to oil burning. Hyundai Dealer told me there is no recall for this issue, but my mechanic said there had been. I was never notified of such, and when I called them, they said that there was no recall, and she acted like she had never heard of the problem. I find that amazing, since on your website, there are some 717 claims of the same problem.

Filed Jul 13, 2026 · Engine · TN

Cylinder 3 misfire code and rough idle/driving car tries to stall out, engine is consuming a quart of oil every 500 miles and has 30psi compression in cylinder 3. Car only has 129k miles

Filed Jul 8, 2026 · Engine · MN

My 2016 Hyundai Sonata 2.4L suffered an in-transit engine failure and entered emergency limp mode with an active P1326 rod bearing defect code, which is a recognized fire and safety hazard under the federal safety agency mandates. Service Campaign 953 was successfully completed on August 12, 2019, qualifying the vehicle for a lifetime settlement engine replacement. Walser Hyundai Brooklyn Park (RO #257457) has issued an administrative denial based solely on a prior-salvage title flag from a cosmetic theft recovery. The manufacturer is actively stalling a court-ordered federal safety recall remedy based on an administrative title brand, despite the engine compartment being structurally original and undamaged. Hyundai Corporate Case #42869828 is open but unresolved.

Filed May 12, 2026 · Engine, Transmission · NC

My 2016 Hyundai Sonata is experiencing severe oil consumption due to a known Hyundai engine defect. The engine burns oil rapidly and loses more than a quart between oil changes. This creates a safety hazard because the engine can stall, seize, or fail while driving. The Hyundai dealership did NOT perform the official Hyundai oil-consumption test. They only checked the dipstick, noted the oil was low, and submitted a request for a paid combustion cleaning. Hyundai declined to pay for the cleaning, and the dealership is refusing to perform the required oil-consumption test unless I pay $750.00. Hyundai Corporate also refused to authorize the test, stating the vehicle is out of warranty, even though this is a known engine defect affecting many Hyundai vehicles. Without the official test, Hyundai will not review the engine defect or consider a goodwill engine replacement. This is a safety issue because the engine can fail without warning. The dealership and Hyundai are refusing to perform the required diagnostic test unless I pay $750, and refusing to review the defect without that test.

Filed Apr 20, 2026 · Engine · CA

While driving my car with no warning light or any type of sound just cut off engine while driving. I was on busy highway going slightly uphill and was almost rear ended causing car behind me to swerve to avoid hitting me swerving to other lane and almost colliding into another car. I was able to get to middle divider almost but back end of my car sticking out in #2 lane. I was stuck in car for about 10 minutes then got across Street to sidewalk. There was no warning, no smoke etc prior to engine cutting off. Everything still works lights, a/c, radio etc . Engine tries to turn over but then slowly dies out like a battery issue however I have a 2 year old battery and when I charge it or try to jump start it it doesn't start also everything else powers on. I have had it stall 2 times before on L.A. freeway in which I somehow was able to cross over 4 lanes coasting to side of freeway. And at that time was sideswipped by another vehicle to front of car and car kept going and I really didn't have time to think about that while just trying to maneuver safely to side of freeway. The 1 and 2nd time it stalled it did restart after about 10 min. But this 3rd time it hasn't started again. The most recent incident was4/15/26. Another issue is the massive amounts of oil it consumes. I put in 2 quarts a week . But there is never oil leaking on driveway or anywhere its parked so where is oil going. I've had it checked several times and they said that these cars burn through oil and I also told Hyundai dealer about both issue and nothing was ever done. My s Check engine came on and I took in to shop and picked it up after paying alot of money and light was off but about a week later on. Took it back and pick up and lights off running good another couple thousand again. And on and off just randomly and auto mechanic shop said I would need to take to hyundai dealer to see whats happening. Called and told them never heard back. I have more pic of repairs but couldn't load more

Filed Apr 17, 2026 · Engine, Fuel system · AZ

I am writing about my concerns on a 2016 Hyundai Sonata SE that I purchased for my daughter in October 2023. After purchasing I took it to my local Hyundai dealer to have it checked out. It was one of the cars that came with a lifetime warranty for the rods DO TO A DEFECT.On January 2024 my daughter was driving on the freeway when all of a sudden it just stopped accelerating and when checked it was a Knock sensor detection system. The dealer took it in and inspected and said it was a defective sensor and replaced it.This made me uncomfortable as I felt the sensor did its job and it was just a matter of time before the rod blew through.During the next few months it became very apparent that the car was going through unbelievable amounts of oil.It had a ticking so we replaced all the spark plugs and noticed oil saturating the plugs and realized a leak in the valve cover gasket which was also replaced.We thought this might be the cause but no oil was on the ground and nowhere on the engine.I just thought it was burning oil but no indicator lights were going off. The car could have no oil and it would not let us know. She's lucky to drive 300 miles a month.She has complained of a strong gas oder and we replaced 2 gas caps and went back to the Hyundai dealer.They told us there's a problem with the fuel filter and pump.If we pay $273 of inspections it might cover it if it's a failing part, and when I did the oil change the car was very low on oil despite the fact that we check it monthly and put 3 quarts of oil in the car.Her car is consuming 3-4 quarts of oil per every 250 miles.This could cause her engine to fail and possibly throw a rod which given the fact she has already taken out one Knock sensor it is just waiting to happen.So as oil disappears every few hundred miles without a warning the engine locks up and if a rod punches through onto the exhaust this can cause it to stall and potentially catch on fire especially when it wreaks of gas from the fuel filter.

Filed Mar 18, 2026 · Acceleration, Brakes · SC

I contact the Hyundai dealer about my 2016 Hyundai sonata. for all I know those vehicles have recalls with engine failure/stalling due to premature rod bearing wear, fire risks from malfunctioning electric oil pumps. My car is having those exact problems with the abs lights being on and is also have problems with the VVT sprocket. And the oil I called Hyundai and they said my vehicle only has a recall with the JUNCTION BOX. But my car is unable to go over 60. And is unsafe to drive and the recalls with that type of model car is the same recalls I am having and soon as I've bought the car and had it for some time i am starting to have those problems so I would like to know what’s going on because it is unsafe and I can’t even drive my vehicle I also have a blinking check engine light. I’ve wanted to report this now incase risk of a fire because I’ve did my research and realize these cars that have these type of problems are known for catching on fire.

Filed Mar 16, 2026 · Engine · NE

code P1326 unable to accelerate, drive past 1st gear and knocking noise in engine area engine could stall out or lock up if problem is not fixed 3/14/2026- started engine light blinking warning light also code p1326 has had recalls for this particular car brand

Filed Mar 9, 2026 · Engine · OH

Vehicle started then stalled requiring tow. No initial illumination of warning lamps or messages. Findings upon inspection by independent service center: multiple cylinder misfires (P030100, P030300, P030400, P030200, P030000) and excessive debris buildup on vvt sensor screen. Car uses excess oil- a minimum of 3 qts per 600 miles. No warning lamps or messages occur when car is excessively low on oil.

Filed Dec 21, 2025 · Electrical, Engine · VA

Vehicle stalled while driving

Filed Dec 5, 2025 · Engine · GA

My 2016 Hyundai Sonata with the DOHC GDI Theta-II engine is experiencing severe engine oil consumption consistent with Hyundai's known TXXI/TXXC extended warranty defect. The oil pressure warning has flashed while driving or braking, the engine runs rough when slowing down, engine has made knocking noises, and there is smoke/vapor with a burnt oil smell when removing the oil cap after driving. The oil level drops rapidly between changes despite proper maintenance. This issue poses a risk of engine failure, stalling, or fire while driving. I have maintained the vehicle on time with all oil change receipts. A Hyundai dealership refused to perform the required warranty diagnostics even though this issue falls under Hyundai's extended warranty for Theta-II engines. This is a serious safety concern, and no corrective action has been taken.