2019 Hyundai Sonata engine problems

Filed Oct 4, 2026 · Engine · IL

My car's engine is burning oil. I have maintained service of oil changes and fluids, etc. since I purchased my car. It is not that old in my opinion.

Filed Sep 10, 2026 · Engine · 90,000 miles · IL

The contact owns a 2019 Hyundai Sonata. The contact stated that while driving 55 MPH, the check engine warning light illuminated, and the vehicle went into LIMP Mode. The contact stated that the vehicle failed to accelerate above 58 MPH. The contact retrieved DTC: P1326 (Knock Sensor Detection System) at O'Reilly Auto Parts and stated that the knock sensor had previously been replaced. The failure mileage was approximately 90,000.

Filed Aug 18, 2026 · Engine · 140,000 miles · FL

The contact owns a 2019 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the vehicle experienced severe overheating and excessive oil consumption. The contact also stated that there was a misfire in the engine even though the spark plugs and ignition coils were replaced. Due to the failure, the vehicle could not be driven with the air conditioning activated. Additionally, the engine was knocking and shaking abnormally, causing an oil leak and a smoke odor due to the oil burning. The vehicle was taken to a dealer, where an engine replacement was recommended. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 140,000.

Filed Aug 18, 2026 · Engine · NY

The oil is low, went to get looked at by another mechanic besides Dealer cause they want to hit you over the head with prices. Was told car burning oil. Took to dealer for Oil Consumption Test. Had to pay for oil change. Came back a little before 1,000 miles and car failed. They charging me 900.00 for next step because I can’t find ALL the oil changes. I just don’t get it, if this is a known issue with this model engine why do I have to pay.

Filed Aug 13, 2026 · Engine · NJ

On January 26, 2026, my 2019 Hyundai Sonata SEL suddenly became inoperable overnight. The vehicle had been operating normally with no warning signs—no check-engine or oil-pressure light, abnormal engine noise, overheating, loss of power, or other indication of an impending failure. The following morning, the engine would not start. The vehicle was towed to an independent mechanic on January 28, 2026, who determined that the engine was locked/seized. On February 11, 2026, it was towed to Wayne Hyundai for further diagnosis. The vehicle had only 51,533 miles and had received Hyundai’s Knock Sensor Detection System (KSDS) update. Hyundai denied warranty coverage, citing engine sludge, despite my providing a complete service history after resubmiting the missing receipts I had previously misplaced. My primary concern is safety, not the warranty dispute. A sudden engine seizure without warning could cause an unexpected loss of propulsion or create a dangerous situation if the engine fails while the vehicle is being driven. This concerns me because Hyundai Theta II engines have previously been associated with engine seizure and stalling, including issues addressed through The Hyundai Theta II Engine Settlement: and subsequent litigation involving certain 2019 Sonata vehicles. I respectfully request that the federal safety agency investigate whether a continuing or insufficiently addressed engine defect exists in affected 2019 Hyundai Sonata vehicles, particularly sudden engine seizure/no-start failures occurring without warning. I also ask the federal safety agency to examine whether existing recalls, campaigns, software updates, warranty extensions, and other remedies adequately protect owners when an engine fails suddenly before the KSDS system provides a warning.

Filed Jul 23, 2026 · Engine · 172,000 miles · VA · fire

The contact owns a 2019 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, smoke started coming from the hood and the vehicle was pulled over into a parking space. While opening the hood, the contact saw that fire was coming from the top of the engine. The contact stated that the fire consumed the front of the vehicle, including the windshield and the dashboard. The smoke coming from the vehicle was dark gray and turned black afterwards. The contact called 911, and the Fire Department was able to extinguish the fire. There were no injuries reported. A vehicle parked next to the vehicle was damaged by the flames. The contact's vehicle was not inspected or officially deemed a total loss. The vehicle was towed to an independent mechanic where an oil change had been performed prior to the failure. The mechanic stated that there might have been a high-pressure fuel valve on top of the engine that possibly caused a gas leak, which started the fire. The vehicle was not diagnosed or repaired. The dealer was not contacted. The manufacturer was not made aware of the failure. The failure mileage was 172,000.

Filed Jun 20, 2026 · Engine · VA

The engine is the component or system failed or malfunctioned, and it is available for inspection upon request. Sudden loss of engine power while driving, including during highway speeds or intersections, increasing the risk of a crash. Engine stalling or failure to accelerate, preventing me from safely maneuvering away from hazards. Overheating events, which resulted in complete engine seizure and an unexpected loss of vehicle control, all which can potentially causing catastrophic incident without warning. To include, the increased risk of collision, especially if the failure occurs during traffic, merging, passing, or emergency situations. It has been reported to CC Transmission Auto Repair and independent service center. It was previously inspected by Hyundai dealer. Check engine light present September 2025.

Filed May 19, 2026 · Engine, Fuel system · FL

For the past several years, this vehicle has experienced a recurring and unresolved engine malfunction that creates a safety hazard. The problem manifests as follows: Symptoms when check engine light illuminates: • Idle RPM elevation to approximately 1500 RPM (normal idle: 800 RPM) • Sudden unintended forward acceleration when foot is removed from brake pedal • Significantly reduced acceleration performance during normal driving • Vehicle becomes difficult to control safely The malfunction occurs intermittently but follows a consistent pattern. This is not an isolated incident but a recurring defect that has persisted for years. Multiple diagnostic and repair attempts have been unsuccessful: • Coconut Creek Hyundai service center - unable to diagnose [DATE(S)] • Independent mechanics - unable to resolve [DATE(S)] • Issue remains unresolved despite multiple service visits Despite multiple attempts by qualified technicians, the root cause has not been identified and the defect has not been corrected. This malfunction creates a significant safety hazard: • Unintended acceleration increases risk of collision • Reduced acceleration capability limits ability to merge or accelerate safely • Check engine light indicates undiagnosed system failure • Problem is intermittent and unpredictable, making it unsafe to drive I am concerned this may represent a defect pattern affecting multiple 2019 Sonata vehicles. the federal safety agency should: 1. Investigate whether this represents a defect pattern in 2019 Hyundai Sonata vehicles 2. Determine if a safety recall is warranted 3. Contact Hyundai Motor America to address this systemic issue

Filed May 5, 2026 · Engine, Suspension · IL

Ecm, p0303, yes, not yet, no, cel light before the car was brought to the dealership, 2019 Hyundai Sonata SE, 2.4L Theta II GDI. Perryville Hyundai IL refused applicable TSB in writing 5/4/26 despite active P0303 misfire, fuel-in-oil smell, crankcase pressure. I have Photos prove falsified multi-point inspection: 1.0 inch (.0833') wheel well discrepancy, same mileage in/out. Vehicle has stall risk. Case Manager [XXX] non-responsive 2hr 45min after requesting written tow instructions on safety matter. RSPM escalated 1:00 PM CDT 5/5/26 with 3:00 PM deadline. No contact received as of 3:03 PM. Vehicle unsafe to drive. Theta II Lifetime Warranty Settlement violation. Case #XXX. Requesting federal investigation. Photo upload is not working, I'll need a email to send them in apparently INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 22, 2026 · Electrical, Engine · TX · fire

On April 14, 2026, my 2019 Hyundai Sonata was parked at a retail store parking lot. Returning from the store, I attempted to start the car, and it did not start. I attempted to start it again, and I saw smoke coming out from under the hood. I immediately exited the vehicle and opened the hood. I saw open flames coming out of the engine area, about 4” high. I called 911 and waited about 10 minutes for the fire department to arrive. During this time, the flames engulfed the entire engine compartment and extended vertically above the hood height. The hood eventually melted and fell back onto the engine area. The fire department came and put out the fire. The car is totaled. There were no injuries, thank God!