2019 Hyundai Sonata: check engine light

Filed Sep 10, 2026 · Engine · 90,000 miles · IL

The contact owns a 2019 Hyundai Sonata. The contact stated that while driving 55 MPH, the check engine warning light illuminated, and the vehicle went into LIMP Mode. The contact stated that the vehicle failed to accelerate above 58 MPH. The contact retrieved DTC: P1326 (Knock Sensor Detection System) at O'Reilly Auto Parts and stated that the knock sensor had previously been replaced. The failure mileage was approximately 90,000.

Filed Sep 5, 2026 · Fuel system · AZ

The low-pressure fuel pump module assembly, located directly beneath the rear passenger seat cushion, experienced a plastic housing failure. A stress fracture on the upper plastic fuel outlet nipple caused raw liquid gasoline to actively weep and pool on top of the module inside the passenger cabin. This component is retained and available for inspection upon request. RISK TO SAFETY: Raw liquid gasoline pooling inside the interior passenger compartment creates an severe, immediate fire and explosion hazard. Additionally, vehicle occupants were exposed to toxic fuel vapors while driving. INSPECTION & DEALER CONFIRMATION: An authorized Hyundai dealership inspected the vehicle and confirmed raw fuel leaking at the top of the fuel pump module assembly. This exact module had previously been removed and disassembled during a 2024 manufacturer recall service to replace the internal fuel filter and tank seal. Stress applied to the plastic fittings during that recall service appears to have caused the plastic top-hat to fracture over time under line pressure. Hyundai Corporate was notified of the safety hazard and prior recall history, but refused assistance. WARNING SYMPTOMS: The failure began with a strong, persistent fuel odor inside the vehicle cabin. No dashboard warning lights, check engine lights, or diagnostic trouble codes (DTCs) triggered prior to or during the failure. SUMMARY: A stress-fractured plastic fuel pump housing allowed raw fuel to pool in the passenger cabin following a prior manufacturer recall repair involving the disassembly of the same component.

Filed Jun 20, 2026 · Engine · VA

The engine is the component or system failed or malfunctioned, and it is available for inspection upon request. Sudden loss of engine power while driving, including during highway speeds or intersections, increasing the risk of a crash. Engine stalling or failure to accelerate, preventing me from safely maneuvering away from hazards. Overheating events, which resulted in complete engine seizure and an unexpected loss of vehicle control, all which can potentially causing catastrophic incident without warning. To include, the increased risk of collision, especially if the failure occurs during traffic, merging, passing, or emergency situations. It has been reported to CC Transmission Auto Repair and independent service center. It was previously inspected by Hyundai dealer. Check engine light present September 2025.

Filed May 19, 2026 · Engine, Fuel system · FL

For the past several years, this vehicle has experienced a recurring and unresolved engine malfunction that creates a safety hazard. The problem manifests as follows: Symptoms when check engine light illuminates: • Idle RPM elevation to approximately 1500 RPM (normal idle: 800 RPM) • Sudden unintended forward acceleration when foot is removed from brake pedal • Significantly reduced acceleration performance during normal driving • Vehicle becomes difficult to control safely The malfunction occurs intermittently but follows a consistent pattern. This is not an isolated incident but a recurring defect that has persisted for years. Multiple diagnostic and repair attempts have been unsuccessful: • Coconut Creek Hyundai service center - unable to diagnose [DATE(S)] • Independent mechanics - unable to resolve [DATE(S)] • Issue remains unresolved despite multiple service visits Despite multiple attempts by qualified technicians, the root cause has not been identified and the defect has not been corrected. This malfunction creates a significant safety hazard: • Unintended acceleration increases risk of collision • Reduced acceleration capability limits ability to merge or accelerate safely • Check engine light indicates undiagnosed system failure • Problem is intermittent and unpredictable, making it unsafe to drive I am concerned this may represent a defect pattern affecting multiple 2019 Sonata vehicles. the federal safety agency should: 1. Investigate whether this represents a defect pattern in 2019 Hyundai Sonata vehicles 2. Determine if a safety recall is warranted 3. Contact Hyundai Motor America to address this systemic issue

Filed May 5, 2026 · Engine, Suspension · IL

Ecm, p0303, yes, not yet, no, cel light before the car was brought to the dealership, 2019 Hyundai Sonata SE, 2.4L Theta II GDI. Perryville Hyundai IL refused applicable TSB in writing 5/4/26 despite active P0303 misfire, fuel-in-oil smell, crankcase pressure. I have Photos prove falsified multi-point inspection: 1.0 inch (.0833') wheel well discrepancy, same mileage in/out. Vehicle has stall risk. Case Manager [XXX] non-responsive 2hr 45min after requesting written tow instructions on safety matter. RSPM escalated 1:00 PM CDT 5/5/26 with 3:00 PM deadline. No contact received as of 3:03 PM. Vehicle unsafe to drive. Theta II Lifetime Warranty Settlement violation. Case #XXX. Requesting federal investigation. Photo upload is not working, I'll need a email to send them in apparently INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 12, 2026 · Engine, Fuel system · NJ

My 2019 Hyundai Sonata has been experiencing excessive oil consumption since I purchased it. The vehicle requires oil to be added approximately every two weeks, which indicates a serious internal engine issue. Recently, the check engine light turned on, and I took the vehicle to a dealership for inspection. I was told that the engine is “operating normally,” despite the ongoing oil consumption problem. I was also informed that the engine would only be replaced under warranty if it fails completely, such as through connecting rod bearing damage. This means I am expected to continue driving a vehicle that may suddenly fail without warning. I drive daily with my children, and I am concerned about the risk of sudden engine failure, loss of power, or engine seizure while driving, which could lead to a serious accident. I believe this is a known issue with these engines, and it represents a significant safety hazard that should be addressed before a catastrophic failure occurs.

Filed Dec 29, 2025 · Engine · NH

The engine is burning oil around 1 quart every 700 miles. I check the car oil level around every 10 days. I have experienced when I didn't check the oil and the low oil engine light would come on in the instrument panel. Hyundai shows no recall for this 2019 Hyundai Sonata Limited edition. I believe that this type of incident occurred back around 2011 with Hyundai's models for that time

Filed Dec 17, 2025 · Engine · IN

The contact owns a 2019 Hyundai Sonata. The contact stated that the vehicle was experiencing excessive oil consumption. The vehicle was taken for an oil change, and the contact was informed that the vehicle required an oil change every 10 days. Additionally, the contact stated that the vehicle was taken to the dealer after driving 1,000 miles after an oil change, and the dealer informed the contact that a combustion cleaning was needed. The dealer performed the combustion cleaning, but the failure persisted. The check engine warning light was illuminated. The contact stated that an independent mechanic and the dealer had diagnosed the vehicle and had determined that the catalytic converter needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and declined to cover the cost of the repair. The failure mileage was unknown.

Filed Nov 29, 2025 · Engine · IL

My oil light came on after driving it about 4700 miles from purchase date. I checked the oil and there was no oil on the dipstick. 200 miles and 2 days later the check engine light came on and put it into limp mode. It was about a half quart low. I was put at risk for having to go slow on a main highway to get back home. I took it to a local Hyundai dealership they did a diagnostic and bearing clearance test for $572.00. They said it passed. Then I did a 1000 mile oil consumption test. They over filled my oil and it passed. The 2nd 1000 mile oil consumption test they did not over fill my oil and it failed. They told me they would submit a PA to Hyundai corporate and as long as the maintenance was done they would most likely replace the engine. He also told me my engine could blow anytime. They never called me back so when I called the dealership they said they denied it needed a new engine. They wanted me to pay another $800 to run a combustion test. I am not paying for anymore testing when they clearly have engine problems with many of their engines. I had warning signs and that’s when I called the dealership I purchased it from and went on this path. I was also told that this was covered under an extension warranty of 120, 000 miles. Only to be told by Hyundai corporate that it is not covered. This is an issue Hyundai is well aware of and they refuse to fix it.

Filed Sep 12, 2025 · Engine · 150,000 miles · WV

The contact owns a 2019 Hyundai Sonata. The contact stated that while driving at various speeds, there was a knocking sound coming from under the hood. The contact stated that the engine was consuming an excessive amount of engine oil. In addition, while attempting to drive, the vehicle failed to exceed 5 MPH. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed with a blown piston and cylinder #2 failure. The vehicle was repaired; however, the failure reoccurred. The contact stated that while stopped at a stop sign, there was black smoke coming from under the hood, with an abnormal sound coming from the vehicle. The vehicle was taken to another local independent mechanic, where it was diagnosed, and determined that the catalytic converter needed to be replaced. The manufacturer was not made aware of the failure. The failure mileage was approximately 150,000.

Filed Aug 4, 2025 · Engine · 81,000 miles · OH

The contact owns a 2019 Hyundai Sonata. The contact stated that within the 4-5 months of vehicle ownership, the vehicle experienced excessive oil consumption. The contact stated that oil had been added to the vehicle approximately 8-9 times and an oil change had been completed twice. The contact stated while driving at various speeds, there was an abnormal rattling sound coming from the front of the vehicle. The check engine warning light was illuminated intermittently. The vehicle was taken to the dealer to be diagnosed, but the cause of the failure could not be determined. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 81,000.

Filed Jun 25, 2025 · Engine, Fuel system · OH

Car has 39,495 miles. First owner of vehicle. Have advised dealership since 2024 that there was a oil issue as i have only went to them for oil changes. I advised that as they can see the car is barely driven and the oil is disappearing. They claimed nothing was wrong and made me pay for a oil change again. Come this year, I advise again there is a issue, they tried to have me pay for a oil change again and I advised something else needs done. They argued I was not the first owner and the car was not in warranty however I bought the car from their lot and I am the original owner. Then they stated I had to pay for another oil change for the oil consumption. Then they claimed they would just do the oil consumption and then to drive 1,000 miles and bring it back. After the oil consumption engine light is on. I drove 1,000 miles, brought it back and the engine failed the test. The dealership changed the engine. 5 days later engine light is on, car is stalling and brake locked up, then car would not start and was smoking under the hood. Car was then towed to the dealership. They claimed nothing is wrong and they reset the code for the engine light to go away. They stated evap code was on but was not persistent so it's fine. Few days later engine light comes on again and once the car has been running, you shut it off go to start it again it won't start unless you have it sit for a while. I Take it back to the dealership they point next to the engine saying a purge valve, but the wants money for a diagnostic. They do the diagnostic and still provide maybes, as they claim the filler neck is rusted and corrosion. I take the car to another place who states the filler neck is fine.