Hyundai Sonata misfire problems

Filed Sep 10, 2026 · Engine, Transmission · VA

In March 2026 Hyundai did an emissions update Campaign 9C2. Since that update my 2015 Hyundai Sonata SE has run rough and shifted hard. Hyundai stopped doing the update in May 2026. Hyundai has not provided any update to fix the problem they created. I am worried the update is damaging the motor and transmission of a car that was running just fine prior to the update.

Filed Aug 25, 2026 · Engine · NC

Since I had Service Campaign 9C2 completed, the car hesitates to start, does a mini-lurch upon cold start and runs rough. Two weeks ago, it was put in park, lurched backwards, then died. The starter and battery have been replaced but this has not helped. The car ran fine before this update was done.

Filed Aug 18, 2026 · Engine · 140,000 miles · FL

The contact owns a 2019 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the vehicle experienced severe overheating and excessive oil consumption. The contact also stated that there was a misfire in the engine even though the spark plugs and ignition coils were replaced. Due to the failure, the vehicle could not be driven with the air conditioning activated. Additionally, the engine was knocking and shaking abnormally, causing an oil leak and a smoke odor due to the oil burning. The vehicle was taken to a dealer, where an engine replacement was recommended. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 140,000.

Filed Aug 6, 2026 · Engine · MD

Since the 9C2 update on June 24, 2026, my vehicle has not driven the same. I'm experiencing clunky or harsh gear changes at low speeds, especially during stop-and-go driving. When I slow down and then accelerate again, the vehicle sputters or hesitates before responding. While driving at lower speeds, I also feel intermittent skips or small surges, almost like bubbles or brief misfires. These symptoms were not present before the 9C2 update, and they have noticeably affected the drivability of the vehicle. It was suggested the transmission needed time to "relearn" driving patterns, but it has been several weeks with no change

Filed Jul 13, 2026 · Engine · TN

Cylinder 3 misfire code and rough idle/driving car tries to stall out, engine is consuming a quart of oil every 500 miles and has 30psi compression in cylinder 3. Car only has 129k miles

Filed Jul 7, 2026 · Engine · CA

Engine misfiring and low compression

Filed Jul 2, 2026 · Engine, Transmission · GA

My vehicle began experiencing excessive oil consumption several years before the engine failed. In approximately 2019, I reported the oil consumption to an authorized Hyundai dealership and expressed concern that my vehicle might have one of the known Theta II engine defects. I was told the Knock Sensor Detection System (KSDS) campaign had been completed and that my vehicle was not one requiring engine replacement. The excessive oil consumption continued. On June 6, 2026, the engine developed severe metal knocking, misfires, and became unsafe to operate. I was concerned the engine could fail completely or lose power while driving, creating a safety hazard for myself and others. The vehicle had to be towed to a Hyundai dealership on June 7, 2026. Hyundai of Kennesaw inspected the vehicle and verbally advised that the engine failure was caused by connecting rod bearing failure. Although the dealership identified connecting rod bearing failure, Hyundai Motor America declined to replace the engine and instead advised that it would not proceed with repairs because of the settlement provisions related to the vehicle's age and mileage. As a result, the vehicle remains inoperable. I am submitting this report because I believe this engine failure presents a significant safety concern due to the potential for sudden engine failure or loss of power while driving. I am also concerned that I reported symptoms years before the failure, yet the engine ultimately failed from the same type of defect associated with many Hyundai Theta II engines.

Filed Jun 30, 2026 · Engine · MD

Driving home from work on [XXX] (not a safe location)when my car lost power and engine light began to flash. I pulled off to the side of road and called my dad. He came with a code reader and said there was a code P1326. He cleared the code and car drove normally again. 2 days later it began to run rough. I was told about the engine recall so I called Hyundai corporate and told them this same story. I was advised to take to dealership and have the “rod bearings inspected” and shouldn’t matter that my dad cleared the code. The dealership(Massey Hyundai MD) said it had a burnt valve and not part of warranty. But never checked rod bearings. When I called corporate. They said nothing they could do. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 16, 2026 · Engine, Transmission · OH

Check engine light solid/engine failure while driving. 2018 Sonata SE purchased new in fall 2018. Around 50,000 miles started noticing oil level drop and had to add more before next scheduled change. Dealership service center said I just had to shorten the mileage between changes which didn't seem appropriate for a vehicle with 50,000 miles but I did. Continued to have oil consumption problem with no signs of leak, no burning oil smell or exhaust issues. Dashboard display would go off and when I immediately checked dipstick there was barely any oil so I'd add more then go in for full change. At 67,000 or so miles in June 2026, without oil display going off the engine light was now solid. Got to reputable service center near my home and oil was under a quart left yet the warning lamp hadn't gone off. They ran the engine error code P0304 and was misfire #4 cylinder and after compression test, #3 was very low and #4 very high. NOT drivable at that point then towed to dealership so yes, available for inspection by the federal safety agency at the dealership. For now they claim a 'tune up' is needed for spark plug replacement, valve cover gasket replace and fuel induction service that's my cost to incur which seems to just be fixing the damage of an engine oil consumption problem not fixing the issue that caused the damage. The engine seized/stalled without warning while I was driving the vehicle (granted at low speed in my neighborhood when the engine light turned on). I would not say the engine warning lamp occurred prior to the engine fail, it happed at the same time. This should not happen for a vehicle with my mileage and regular maintenance. I looked up the federal safety agency for potential recall or other helpful information and started to see extremely similar scenarios to mine and wanted to add complaint as well. This is getting very expensive outside of whatever cost the dealer wants as a fix with rental car needed and tow services. Thank you for your consideration of this engine safety issue.

Filed Jun 6, 2026 · Engine, Suspension · PA

[XXX] [XXX] [XXX]; [XXX] [XXX] [XXX] Date: XXX To: the federal safety agency Office of Defects Investigation (ODI) Subject: Formal Safety Defect Complaint – 2017 Hyundai Sonata Theta II Engine Failure, Excessive Oil Consumption, Intake/Engine Component Failure and Safety Hazard Dear Sir or Madam: I am submitting this formal complaint and request for immediate investigation into the dangerous and ongoing mechanical failures involving my 2017 Hyundai Sonata equipped with the Theta II engine. I believe this vehicle contains a serious manufacturing and/or engineering defect that presents a substantial safety hazard to consumers. My vehicle has experienced a pattern of progressive mechanical failure beginning with abnormal and excessive oil consumption, which appears to be directly associated with malfunctioning engine airflow and intake-related components. Specifically, the lower engine airflow system and intake functionality appear defective, placing excessive strain on the intake manifold system and contributing to cascading engine failures. As a result of these failures, the vehicle has experienced: Severe and excessive oil burning/consumption Intake manifold malfunction and abnormal operating stress Suspected overheating and/or premature head gasket failure Ignition coil failure and electrical shorting/misfires Progressive engine deterioration rendering the vehicle unsafe and unreliable Increased risk of sudden engine shutdown, stalling, fire hazard, or catastrophic engine failure while operating The vehicle has become increasingly unreliable and inoperable due to these conditions. These failures raise significant concerns regarding public safety, especially given the known history of complaints and recalls associated with Hyundai Theta II engine defects. I am deeply concerned that this vehicle may reflect a broader pattern of defective manufacturing, insufficient quality control. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)