2018 Hyundai Sonata: misfire or rough idle

Filed Aug 25, 2026 · Engine · NC

Since I had Service Campaign 9C2 completed, the car hesitates to start, does a mini-lurch upon cold start and runs rough. Two weeks ago, it was put in park, lurched backwards, then died. The starter and battery have been replaced but this has not helped. The car ran fine before this update was done.

Filed Jun 16, 2026 · Engine, Transmission · OH

Check engine light solid/engine failure while driving. 2018 Sonata SE purchased new in fall 2018. Around 50,000 miles started noticing oil level drop and had to add more before next scheduled change. Dealership service center said I just had to shorten the mileage between changes which didn't seem appropriate for a vehicle with 50,000 miles but I did. Continued to have oil consumption problem with no signs of leak, no burning oil smell or exhaust issues. Dashboard display would go off and when I immediately checked dipstick there was barely any oil so I'd add more then go in for full change. At 67,000 or so miles in June 2026, without oil display going off the engine light was now solid. Got to reputable service center near my home and oil was under a quart left yet the warning lamp hadn't gone off. They ran the engine error code P0304 and was misfire #4 cylinder and after compression test, #3 was very low and #4 very high. NOT drivable at that point then towed to dealership so yes, available for inspection by the federal safety agency at the dealership. For now they claim a 'tune up' is needed for spark plug replacement, valve cover gasket replace and fuel induction service that's my cost to incur which seems to just be fixing the damage of an engine oil consumption problem not fixing the issue that caused the damage. The engine seized/stalled without warning while I was driving the vehicle (granted at low speed in my neighborhood when the engine light turned on). I would not say the engine warning lamp occurred prior to the engine fail, it happed at the same time. This should not happen for a vehicle with my mileage and regular maintenance. I looked up the federal safety agency for potential recall or other helpful information and started to see extremely similar scenarios to mine and wanted to add complaint as well. This is getting very expensive outside of whatever cost the dealer wants as a fix with rental car needed and tow services. Thank you for your consideration of this engine safety issue.

Filed May 6, 2026 · Engine, Fuel system · TX

I am submitting this complaint to report a serious and ongoing safety defect involving the engine of my 2018 Hyundai Sonata Sport equipped with the 2.4L Theta II engine. The vehicle has been officially tested and documented by Hyundai as consuming more than two (2) quarts of engine oil per 1,000 miles, which Hyundai has acknowledged following completion of its oil consumption test procedure. Despite this confirmation, Hyundai has declined to fully correct the defect. As the condition has progressed, the engine now fouls spark plugs every 350–500 miles, resulting in: •Engine misfires •Loss of power during operation •Rough running and hesitation •Risk of sudden engine stalls while driving This condition occurs without warning and requires repeated roadside or emergency repairs simply to keep the vehicle operable. The condition has deteriorated further, requiring replacement of fouled spark plugs every 350-500 miles. Loss of power and engine shaking can occur at any time, presenting a safety hazard for me and other drivers.

Filed Mar 9, 2026 · Engine · TN

Excessive Oil Burning and Oil Consumption. Oil turns black abnormally quickly (within the first 500-1000 miles) even though recommended Full-Synthetic Oil is used. Engine has intermittent rough idle once engine is warm. Occasionally engine experiences "near-stall" and "misfire event", causing the battery light to flash on dashboard. >>>Oil consumption rate is approximately 3-4 quarts per 1,000 miles<<< ***Maintenance completed since purchase*** Coolant Flush - Replaced PCV Valve (NEW) - Replaced Valve cover Gasket + Oil Pan / Oil Pan Gasket (recommended by dealer) (NEW) - Replaced Spark Plugs (recommended by dealer) (NEW) - Replaced Battery (NEW) - Replaced Alternator (NEW) - Replaced both engine accessory belts (NEW) - Replaced 150A main fuse (located on positive battery terminal) (NEW) - Used Hyundai brand oil filters - Used Chevron/Techron Complete Fuel system cleaner twice, between and at oil change (as recommended by "Twin City Hyundai" dealer in Alcoa, TN) ***Had dealership inspect it for approval of known Federal Recall on GDI Engines for excessive oil consumption / engine seizing issues; dealership claimed it did not pass re-call approval*** SYMPTOMS STILL PERSIST Mileage is now approx. 80K

Filed Jan 9, 2026 · Engine · 138,000 miles · MS

The contact owns a 2018 Hyundai Sonata. The contact stated that while driving approximately 60 MPH, the vehicle started to vibrate roughly. The contact felt the vibration in the steering wheel. The check engine warning light was illuminated. The contact slowed down and pulled off the roadway. The contact turned off and restarted the vehicle and was able to shift to drive(D); however, the vehicle was hesitating and failed to accelerate as needed. The contact drove the vehicle to an independent mechanic at speeds no greater than 40 MPH. The mechanic scanned the vehicle and retrieved codes for a misfire in the engine. The mechanic advised the contact to take the vehicle to a dealer for assistance. The vehicle was towed to the local dealer. The vehicle was not yet diagnosed or repaired. The manufacturer was informed of the failure. The contact requested an engine replacement that was denied by the manufacturer. The failure mileage was approximately 138,000.

Filed Nov 25, 2025 · Engine · TX

Car started misfiring while driving and engine light came on. It kept losing power but I was able to pull off highway. This put myself and others in danger because speed was significantly reduced suddenly. Dealer said problem was due to oil leaking on spark plugs. The car had been using excessive oil. Dealer said this is known issue but I had to pay for any repairs since I was the second owner. Hyundai still pays for the original owner to get an oil consumption cleaning, but recently stopped paying for secondary owners. If the oil consumption cleaning does not work, then the next step is to replace engine, paid by customer if Hyundai refuses. Mileage on car is 75,769.

Filed Nov 22, 2025 · Engine, Fuel system · OH

I am submitting a formal complaint regarding ongoing and severe engine issues with my 2018 Hyundai Sonata SE. Despite proper maintenance, the vehicle has developed extreme oil consumption and misfire problems that have made the car unreliable, unsafe, and financially burdensome. Beginning around 118,000 miles, the vehicle started consuming oil so rapidly that I was forced to completely replace the oil every 1–2 weeks because it would run dangerously low or nearly empty. This level of oil loss is not normal, acceptable, or sustainable. I have detailed documentation, receipts, mileage logs, and maintenance history supporting this. In addition to oil consumption, the vehicle has repeatedly misfired, produced diagnostic trouble codes, and fouled spark plugs with oil. I have been forced to replace spark plugs approximately every two weeks, which is clearly abnormal for any modern vehicle. On multiple occasions, the vehicle has experienced violent knocking noises, severe loss of power, hesitation during acceleration, and near-stalling. One incident was so loud and aggressive that it felt like the engine was going to come out of the hood. These symptoms pose a serious safety risk while driving. I brought the car to a Hyundai dealership at approximately 118,000 miles for an oil-consumption test. The vehicle failed that test, clearly confirming excessive oil consumption. Despite this, Hyundai refused to provide repair, internal engine cleaning, or engine replacement, claiming the vehicle was already over 100,000 miles I have maintained this vehicle responsibly and have documentation of regular oil changes, spark-plug replacements, inspections, and diagnostic reports. Despite my efforts, the issue continues to worsen, and the vehicle remains unsafe and unreliable. This ongoing problem has caused significant financial strain, emotional stress, lost time, and fear of engine failure while driving. Based on countless similar complaints from other Hyundai owners, this appear

Filed Oct 20, 2025 · Engine · VA

Engine consumes oil, more than 1 quart a week. started misfiring on a trip and dealer stated that engine needs to be replaced since valve was burnt. have 116k miles on car and have been diligent in maintenance.

Filed Aug 7, 2025 · Engine · TX

My car is consuming oil. Hyundai knows this is happening with the theta II engines. I was told to bring it in and do an oil consumption test which shows my car is consuming 1 qt oil every 406 miles but was denied help due to it being high Mileage and not under warranty. My car has now started misfiring due to cylinder 1 & 2 consuming oil.

Filed Aug 6, 2025 · Engine, Fuel system · FL

Urgent Complaint About Repeated Engine Issues on 2018 Hyundai Sonata (VIN: [XXX] ) Hello, I’m writing to file a formal complaint regarding a 2018 Hyundai Sonata, VIN [XXX] , currently financed and still owing $9,700, but the vehicle is no longer reliable or functional. For over a year, the car has had constant mechanical issues, primarily: •Spark plug failures within weeks of replacement •Repeated misfiring •Constant oil consumption — requiring oil refills every few days •No clear cause ever detected by diagnostic machines Despite replacing the top engine cover, spark plugs, filters, and performing other repairs, the car continues to break down and remains unsafe to drive. These issues began shortly after the 2-year warranty expired in 2023, and have escalated rapidly. This has caused severe financial hardship for my family, who still have to pay nearly $10,000 on a loan for a failing vehicle. I am requesting Hyundai to investigate whether this vehicle qualifies for: •An engine recall, hidden warranty, or class action settlement •A buyback or goodwill repair INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 5, 2025 · Engine, Fuel system · MO

Multiple critical mechanical and safety issues have occurred with my 2018 Hyundai Sonata Sport. The vehicle has experienced persistent engine misfire, a severe oil leak, emissions system failure, and extensive paint deterioration. A certified technician confirmed an active oil pan leak with no dashboard warning lights, posing a fire and stalling hazard. To prevent further damage, I replaced the entire oil pan and spark plugs at a personal cost of approximately $800 at Firestone Complete Auto Care. The check engine light revealed diagnostic code P0420 – Catalyst System Efficiency Below Threshold (Bank 1). An O’Reilly emissions scan confirmed the catalytic converter failure, and emissions status was marked “RED.” The vehicle will not pass an OBD-based emissions test. At 149,219 miles, Hyundai refused warranty coverage due to mileage. A certified Hyundai dealership quoted $3,722 to replace both the catalytic converter and valve cover gasket, which remains unaffordable and unrepaired. In addition, the factory-applied white paint began peeling severely from the hood and roof. Although Hyundai issued a warranty extension for this known defect, the dealership refused to repaint the hood, citing a minor dent — even though the peeling is clearly unrelated. The exposed metal has started to rust, risking structural deterioration. All concerns have been evaluated by certified Hyundai service and independent professionals. These combined mechanical, emissions, and exterior failures raise serious safety and durability concerns. I am filing this report to document manufacturer-related defects that may affect other owners of this model and year.

Filed Dec 31, 2024 · Engine, Fuel system · NC

- Component or system that failed: engine (cylinder #4 misfire) - Safety was put at risk twice: once when knock sensor went off on interstate (October) and engine went into limp mode (aka protection mode). Required a tow from the, which was tricky with a vehicle full of passengers. Safety was put at risk gain when vehicle began to stutter/sputter on interstate (December). Drove 4-cylinder vehicle essentially on three cylinders an hour to dealership - Problem has been confirmed by dealer (Southern States Hyundai, Raleigh, NC) - vehicle has been inspected by warranty inspector, who requests approval before disassembling engine to diagnose issue. However, based upon maintenance records and manufacturer's history of engine issues (more on this below), owner should not be liable for investigating a well known issue. At the time of this writing, the issue has been escalated beyond the dealership and warranty to Hyundai Motor America, and currently awaiting the results of their findings. - symptoms of the problem include constant oil leak from vehicle purchase in May 2024 up to engine failure in December 2024. Various temporary remedies (oil changes and repairs, including oil drain plug gasket replacement, crush washer replacement, and replacement of cracked oil pan) did not fix the issue. Additionally, in the October incident, Hyundai dealership (Sport Durst Hyundai, Durham, NC) simply updated the knock sensor detection (KDS) software, despite the vehicle previously receiving the update in 2019 (this can be verified). Finally, owner, noted "engine knocking" (aka 'tapping') in vehicle prior to engine failure. - Hyundai (the manufacturer) settled a class action lawsuit in 2021. Vehicle is one of the vehicles listed under Class Vehicles, but dealer, nor warranty company, nor Hyundai seem to want to resolve issue, which both alienates owner and presents a safety hazard, as the vehicle is unsafe to drive. All claims here will be supposed via documentation and images.