2018 Hyundai Sonata: fuel pump failure

Filed Oct 22, 2026 · Fuel system · AL

The vehicle experiences a severe delayed start/extended crank condition before finally starting. This is caused by a loss of fuel pressure prime due to the defective fuel filter housing leaking internally, creating an unpredictable and unsafe vehicle operation hazard. The dealership is denying coverage under the 15-year/150,000-mile extended warranty (Campaign TXXS), claiming the issue is a standard fuel pump failure while completely ignoring that the integrated fuel filter housing defect causes this exact failure."

Filed Sep 4, 2026 · Fuel system · TX

My car stalls while driving and then I try to restart it but nothing happens. After reading online about the fuel pump issues and extended warranty related to the fuel pump I took the car in for repair. My car has 75,000 miles and the extended repair on this is for 150,000 miles/15 years. The dealer is refusing the repair because my car has a branded/ theft title. The car wasn't damaged just stolen. This is creating a serious safety concern and should be repaired by the dealer. Thank you for your time.

Filed Jul 24, 2026 · Fuel system · 92,000 miles · MS

The contact owns a 2018 Hyundai Sonata. The contact stated that while operating the vehicle, there was an abnormal fuel odor inside the vehicle. The vehicle was taken to the local dealer and was diagnosed with an inoperable low-pressure fuel pump. The contact was informed that the low-pressure fuel pump needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The contact stated that the manufacturer had issued an extended warranty coverage for the failure. The failure mileage was 92,000.

Filed Jun 13, 2026 · TX

I was only in the car for about 4 minutes then came to a stop light. Once the light had turned green I pressured down on the gas, my car rolled for a second then died on me, causing it to go into accessory mode. Instantly three lights came on: the check engine light, battery light, and low oil light. The car would take at least 5 seconds to turn back on then would fall back into accessory mode randomly. Tried to jump the car 4 times, issue still remains. What sucks about this is that the mechanic shop can’t even figure out what’s wrong. They thought it was the high pressure fuel pump..turns out it’s not.

Filed Apr 21, 2026 · Fuel system · WA

Throttle response intermittent problem no acceleration since new. No codes available. When entering traffic engine stall factor flat spot. Been to dealer many times (Bud Clary) and just recently (04/26) confirmed the fuel pump is the problem. Unable to confirm because of no "codes". Will not replace or register for recall without proper codes. No check engine lamp. No inspection by police or insurance only the dealership service department is aware of the problem.

Filed Apr 2, 2026 · Engine, Fuel system · UT

Had an oil change, then 2 weeks later car making noise, checked the oil and it was completely empty, so we refilled the oil. Then a month after again same issue no oil, refilled it again and now a week later it's 2 quarts low already. Also when I come to a complete stop when it is time to go again it's very slow at going or if I try to excel it takes it a very long time to actually excel I think something's wrong with the fuel pump

Filed Aug 7, 2025 · Fuel system · TX

The fuel pump filter housing is the cause of the malfunction, it is available for inspection upon request. When I am driving I intermittently lose fuel delivery altogether and my car comes to a halt for a second until I press on the gas pedal to get the car going again, this puts myself and other people in danger if my car randomly stops while I am driving around others and causes crash risk. An independent service center ran a diagnostic and stated it was the fuel pump filter housing. It has not been inspected by the manufacturer, police, or insurance reps. But it has been inspected by the service center near me. An engine code was produced that pointed to the gas cap, but the gas cap was fine, which indicates fuel delivery issues. There was also shaking during acceleration prior to the incident happening. My VIN does not fall under the current extended warranty, but the issues are identical to the issues of the VINs that do fall under the extended warranty.

Filed Mar 17, 2025 · Engine, Transmission · FL

I was going 80 mph on the interstate and suddenly my car went into limp mode and shooked really hard and dropped to 60 mph. I had to swerve to go onto the side of the road. The car behind me almost rammed into me. I contacted hampton hyundai for days to schedule an appt. I finally was able to drop off my vehicle to them but now they are telling me they have to do an oil consumption test but my car is in limp mode and it shakes when I drive it. The car is dangerous and they are trying to charge me $500 for a fuel pump replacement ( which I have a warranty of but they notified me that does not count but it matches exactly the possible reason). As you can see in the documents, they did not note that my fuel pump was broken. They just asked if I wanted to pay it so they can get started. I get normal oil changes done. They haven't even done a rod bearing test but just looked at the knock sensor and was telling me that they wanted to charge me to get that changed.

Filed Mar 27, 2023 · Fuel system · GA

Fuel pump started going out. My brothers vehicle also started going out too in the same vehicle as this. It's clearly a wide issue. Car stalls when gas is at half tank.

Filed Sep 20, 2022 · Engine, Locks · 23,944 miles · FL

The contact owns a 2018 Hyundai Sonata. The contact stated the vehicle had failed to start. On other occasions while driving at various speeds, the vehicle was not running correctly, bucking, lost motive power and stalled. Additionally, the door and trunk failed to lock securely. There were no warning lights illuminated. A signal was sent to the vehicle however, the vehicle failed to respond. The vehicle was towed to the local dealer but the vehicle was not diagnosed or repaired. The vehicle was then towed to an independent mechanic who informed the contact that the fuel pump failed and caused the starter to burn out and drain the battery. The manufacturer was notified of the failure and provided a case number and referred the contact to the local dealer for assistance. The approximate failure mileage was 23,944.

Filed Dec 7, 2020 · Engine, Fuel system · 147,000 miles · FL

In feb 2020 my sonata went into safe mode after exiting highway and dealer ended up replacing "knock sensor". In december 2020 my engine "stuttered" throwing me forward as if I had hit brakes hard. No warning lights or messages occurred and after a few seconds car acted normally mostly. A few days later after exiting highway again the engine warning light (orange) came on along with error message "possible condition with engine control system" has been detected. Car did not go into "safe mode" and seemed to be operating normally. I contacted dealer who assured me safe to drive over hundred miles back to dealership in this condition to check. I drove back from east coast fl to west coast fl to turn car in. I believe engine issue experienced is related to the theta engine issue and repair would be covered under settlement. Dealership disagrees and has indicated issue is with fuel pumps (both are being replaced) and charging me $2300.