2022 Hyundai Tucson Hybrid: engine stalls while driving

Filed Aug 19, 2026 · Driver assistance, Engine · MA

System/Component Failed & Inspection: The vehicle suffers from recurring failures across the engine, powertrain, electronic throttle control, and exhaust gas recirculation (EGR) control systems (DTCs P0524, P0642, P2118, P022100). The vehicle is fully available for inspection upon request. Safety Risk: While driving, the vehicle suffered a complete, sudden loss of motive power on an active highway entrance ramp. The engine stalled in moving traffic with zero throttle response, creating an immediate collision hazard before requiring a tow. Confirmation by Dealer: Technicians formally confirmed these defect patterns. In May 2026, diagnostics logged major engine and emission/EGR control codes, but corporate refused goodwill repair. In August 2026, the highway stall recurred. Diagnostics confirmed active low oil pressure and throttle failure codes, which the dealer resolved by applying 4 factory ECU software updates under TSB 25-01-010H. Service personnel explicitly confirmed these engine control issues are manufacturing defects, not wear-and-tear or mileage-related. Inspections: Inspected, diagnosed, and serviced by authorized dealership service department technicians during both the May and August 2026 failure events. Warning Symptoms & History: Engine issues began at 341 miles when purchased new (settled). In May 2026, check engine lights returned with diagnostic codes for engine and EGR/emissions systems. In August 2026, total power loss occurred, preceded by check engine, forward collision camera, and radar sensor warnings.

Filed Feb 13, 2025 · Engine · 20,000 miles · WA

The contact owned a 2012 Kia Optima. The contact stated while driving 65 MPH, the vehicle lost motive power and was driving slowly. There was no warning light illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The contact stated that the failure persisted. The contact stated that recently, while driving 65 MPH, the vehicle lost motive power and stalled with an unknown message displayed. The contact was helped over to the side of the road. The vehicle was restarted. The manufacturer was made aware of the failure. The failure mileage was approximately 20,000.

Filed Feb 4, 2025 · Engine, Transmission · CO

1. What component or system failed or malfunctioned, and is it available for inspection upon request? The hybrid powertrain system, transmission, or engine appears to be malfunctioning. The vehicle hesitates or stalls when pressing the gas, losing power as if it doesn’t recognize when to transition between EV and gas mode. Yes, the vehicle is available for inspection upon request. 2. How was your safety or the safety of others put at risk? The issue caused the vehicle to lose power unexpectedly, particularly while driving at highway speeds, which forced me to pull over multiple times for safety reasons. This happened on [XXX] before the [XXX] Tunnel, creating a hazardous situation in heavy traffic. If the vehicle stalled at the wrong moment—such as in an intersection or while merging—it could significantly increase the risk of a crash. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? No. I have taken the vehicle to a Hyundai dealership, but no official errors or diagnostic trouble codes (DTCs) have been detected. The dealership has not confirmed the issue unless I agree to high-cost diagnostics that may not guarantee a resolution. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The vehicle has been looked at by a Hyundai dealership, but no official findings or resolutions have been provided. The issue persists, and no recall or technical service bulletin (TSB) has been mentioned to me as a possible cause. 5. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? No warning lights, error messages, or dashboard alerts appeared before or during the power loss. The issue first started occurring at approximately 35,000–40,000 miles and has continued to around 50,000 miles. The first time I noticed the problem was during a long-distance drive from Los Angeles to CO INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5

Filed Oct 3, 2023 · Engine · 25,714 miles · CA

The contact owns a 2022 Hyundai Tucson Hybrid. The contact stated while driving approximately 45 MPH, the vehicle independently decelerated to 20 MPH with the RPMs falling and the vehicle almost stalling. There was no warning light illuminated. The contact stated that the vehicle failed to exceed 20 MPH. The contact pulled over to the side of the roadway, turned off the vehicle, and waited for approximately 5 minutes. The vehicle was restarted and operated normally. The vehicle was taken to the dealer however, the cause of the failure could not be determined. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 25,714.

Filed May 11, 2023 · Electrical, Engine · NE

I bought a ‘22 Tucson Hybrid in Sept of ‘22. Upon delivery there were issues w paint & a dent on the rear qtr panel. The bigger issue however, is disconnect in communication between the EV motor, gas engine & transmission. All work is done @dealership and well maintained. History of EV over 8 months: @1000 miles noise under vehicle began. Dealership inspected, all checked out. The dealership has done all servicing as scheduled. From 1000 to 12,000 miles, the vehicle drove best if in sport mode. Sport mode utilizes the gas engine and not EV. When in EV modes, the vehicle runs high rpms or it’s sluggish. It’s never consistent. In some instances; the vehicle will actually stall for 2-3 seconds and kick back on. 1 instance was at a stop light, turning left. Mid turn, gas to the floor, the vehicle stalled for 3 seconds before responding. I was almost hit at 50 mph in the intersection as both motors failed me. The next day, 3 lights came on: An EV, check engine and Hybrid motor light came on, 3 total. My Hyundai app stated: issue communicating EV and Gas motor, EMS communication error. This cleared itself in 36 hrs but I couldn’t drive it safely for a week. I took it to the dealership, everything checked out. 3 days ago @ 17,400 miles, I received a text: Hyundai stated car unfit to drive. DTC code U062300, U111200, U02BB0:Powertrain EMS issue. The techs had it 2 days, fixed it. 3 blocks from dealer, check engine light came on again. I returned it to dealer. I’ve found 32 accounts of these codes resulting in a Hyundai buy-back, new engine, new transmission or settlements. I’m told my EV motor, gas engine and transmission won’t communicate even after software / firmware updates & mechanical changes. I don’t feel the vehicle to be roadworthy and I don’t feel safe driving it, if Hyundai has no fix. I’m told, many sales of this model @ my dealer have the same issues. Bad batch? I paid $47k (car & warr) I’m hoping for a buy back or to get into a Toyota hybrid of = value

Filed Mar 17, 2023 · Electrical, Engine · CO

Within only two weeks of purchase this new car would suddenly stall in the middle of the road. The computer tells you to pull over. We continued to try and get the dealer to fix this issue, they first ignored us, then they secondly tried and successfully replicated the issue. They said there is no way they can fix the issue. This dangerous stalling in the middle of the road happened numerous times. You will push the pedal all the way to the ground and it won’t go over 20mph. This is a very dangerous issue and these vehicles need to stop being sold. It is very dangerous. We have been left without our money back and without a car to drive for months. We cannot drive the Tucson as it is simply too dangerous and must be towed to go anywhere for salvage.

Filed Feb 27, 2023 · Electrical, Engine · IL

When driving my car at any speed it will suddenly begin to get sluggish then it becomes unresponsive to me giving it gas and starts to decelerate. When this happens suddenly warning signs on the vehicle go off stating to check the hybrid system and stop the vehicle. When this happens the car then stops functioning. I never know when it is gonna happen. I have been in the middle of heavy traffic and at high speeds stuck in the middle of the road. I have brought it in now four times to different dealerships and contacted corporate and No one can find a problem. I have pictures of the warning signs going off, all I am being told is we don’t find anything wrong when they run their test or try to reproduce the issue, so they can’t help me. This is a very serious and dangerous situation to be driving a car that has and will stall at any given time.

Filed Jul 27, 2022 · IA

Car died while driving and would not go.