Hyundai Tucson Hybrid sunroof shattered problems

Filed Oct 22, 2026 · Visibility · 70,000 miles · ND

The contact owns a 2024 Hyundai Tucson. The contact stated that while driving at 70 MPH, there was a loud sound like a gunshot coming from the vehicle. The contact stated that the panoramic sunroof unexpectedly exploded and shattered. The vehicle was taken to a service center to be repaired. The service center confirmed the failure. The vehicle was scheduled to be repaired. The service center referred the contact to the manufacturer to report the failure. The manufacturer was made aware of the failure by telephone and referred the contact to the dealer for additional assistance. The approximate failure mileage was 70,000.

Filed Sep 12, 2026 · Body · CA

Sunroof exploded on the freeway while i was driving I heard a very loud bang and thought it must be the car next to me. When I arrived home later- saw the hole in my roof.Next morning I took my car to the delearship and after assessment they agreed the sunroof exploded. They told me the car was not safe to drive and gave me a loaner. I have tried to upload images but they are too large for your portal.

Filed Jul 22, 2026 · CO

I own a 2025 Hyundai Tucson Hybrid Limited AWD with approximately 15,000 miles. While driving, I heard a loud, sudden noise and then discovered that the glass panel above the windshield, below the moonroof, had shattered/damaged. The incident occurred at a slight bump in the road, but not a pothole. I did not observe any large road debris, object, or vehicle ahead of me that appeared to cause an impact, and I saw no obvious evidence of a specific impact event. The damaged area allows water to enter the vehicle, making it unsafe and impractical to drive in rain or other inclement weather. There is also concern about loose glass debris. The dealership and Hyundai denied warranty coverage, stating the damage was impact-related. An independent automotive glass shop inspected the vehicle and provided a written assessment stating that the damage cannot be conclusively attributed to a rock or other road impact and could be consistent with a manufacturing defect. The vehicle has been inspected by both the dealer/manufacturer and an independent glass service provider. Hyundai corporate has also been contacted, and a corporate case manager was involved. There were no warning lamps or warning messages before the failure. The first symptom was the sudden loud noise while driving, followed by discovery of the damage to the glass panel above the windshield.

Filed Oct 4, 2025 · CO

My new Hyundai Tucson has less than 5K miles on it and while driving on a fairly empty road the panoramic sunroof exploded for no reason (as we know nothing hit it). Fortunately the screen was closed at the time, but had it been open then glass shards could have entered the car. I often have my grandchildren in car seats with the screen open and this could have caused serious eye damage to them. Hyundai and other manufacturers know this is a common problem but refuse to do anything about it. The local dealer will not cover the repair even though the car is under warranty. When the roof explodes it sounds like a gunshot and we swerved, but fortunately no cars were near us at the time. I can see where this can easily cause accidents.

Filed Jul 16, 2025 · Visibility · TX

VIN: [XXX] Component Failed: Panoramic Sunroof Type of Failure: Spontaneous Explosion/Rupture from the Inside Occurred: Saturday [XXX] at [XXX] Road Conditions: Smooth Road, Clear Day (No Rain or Hail), Temperature mid 80’s degrees Fahrenheit, No Other Cars on Road. Milage on Car: 19640 Initial Event: Driving on the road when passengers hear what sounded like a gunshot (no firearms present in the vehicle). Pulled over to the side of the road to check tires. Tires were okay but noticed the sunroof had spontaneously shattered. Initial Event Photo Indicates Rupture occurred from the inside of the vehicle and not an external force, but there was no access from the inside of the vehicle as the additional fabric roof prevented shrapnel from entering the vehicle. The glass continued to crumble as the driver returned the vehicle to the house for safety concerns. Patterson Hyundai dealer in Tyler, Texas, tried to submit warranty claim and subsequent appeal, but Manufacturer refuses to own manufacture defect. Drivers contacted glass repair companies in the area, and companies explained they had seen this occur several times before. Evidence: Initial Event Photo Indicates Rupture occurred from the inside of the vehicle and not an external force. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 30, 2025 · Visibility · 20,000 miles · NY

The contact owns a 2023 Hyundai Tucson. The contact stated that while driving approximately 60 MPH, there was a loud explosion coming from the roof of the vehicle. The contact pulled over to the side of the road and discovered that the rear of the sunroof had exploded, and there was glass inside the cabin of the vehicle. The vehicle was taken to the dealer but was not diagnosed or repaired. The Insurance Company was contacted and referred the contact to Paul Island Glass and the sunroof was covered with tape. The glass was scheduled to be replaced, but the vehicle was not yet repaired. The manufacturer was informed of the failure. The failure mileage was approximately 20,000.

Filed Mar 3, 2025 · CO

- Component that Failed: The Panoramic Sunroof (glass side that opens) - Safety Risk: Glass shattering above your head while driving, tons of glass falling below to the driver & passengers in the car | Shock of a loud gunshot while driving - causes wrecks - Vehicle Inspected: Currently at Hyundai, figuring out what to do - Warning signs: ABOLSUTLEY NONE - spontaneous explosion My husband, two friends, and I were traveling down the interstate at 55 mph, we heard a loud bang (like the sound of a gunshot)! Our panoramic sunroof sunshade was pulled back with the sunroof closed. Instantly, the sunroof exploded into a million tiny pieces of glass that partially rained down on our heads and shoulders and all over the rest of our car. It was quite a startling sound. There was a hole about 10 inches across in the sunroof and more pieces were continuing to fall out. To protect our heads, I closed the sunshade. Then, we could hear pieces hitting the shade and glass falling behind us on the road. Once we got home, the hole became much larger.

Filed Jun 7, 2024 · Body · AZ

While driving at a freeway speed of 70mph, my panoramic sunroof basically exploded raining glass everywhere. It sounded like a shotgun blast. There was zero indication of an outside object hitting it. The damage was so extensive it would have to have taken a fairly large object to cause this. It also seemed to have blown the glass outward, which indicates to me that there was some faulty component in the sunroof itself. I've read and watched other people who've had similar incidents

Filed May 20, 2024 · Visibility · 23,027 miles · IL

The contact owns a 2023 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the panoramic sunroof exploded without impact. The contact stated that the cloth liner was in place and kept the glass from entering the cabin of the vehicle. No warning lights were illuminated. The contact also stated that there was a class action lawsuit related to the failure. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was 23,027.

Filed Feb 7, 2024 · Body · MO

I was driving at highway speed on the interstate and first heard a loud pop that sounded like something striking the windshield. Just a few minutes later, the sunroof shattered and sent glass fragments raining down on both me and my passenger.