2015 Hyundai Tucson: engine knocking or ticking

Filed Jul 21, 2026 · Engine, Transmission · IN

While driving on a US highway, the check engine light illuminated and the vehicle lost the ability to start/run normally, requiring the vehicle to be pulled off the road and towed to an authorized Hyundai dealership. Dealer diagnostic testing found the engine failed a bearing/performance test, consistent with connecting rod bearing wear. This failure mode — Check Engine light, DTC P1326, abnormal noise, or a no-crank/no-start condition caused by connecting rod bearing wear — is described in the manufacturer's own internal dealer service bulletin covering an engine warranty extension program for multiple engine families (Theta II MPI and Nu GDI engines) across several model years and vehicle lines. That bulletin acknowledges the failure as a known condition and extends coverage to 15 years/150,000 miles for original and subsequent owners. The failure occurred suddenly and without warning while the vehicle was in active use on a highway, creating a stall/loss-of-power hazard in moving traffic — the vehicle could not be restarted at the roadside. The dealership's own multi-point inspection performed shortly after intake confirmed engine fluid levels and oil grade were within normal range, indicating the failure was not attributable to a lack of lubrication at the time of failure. Despite this, the manufacturer denied warranty coverage for the repair, citing an inability to produce maintenance receipts for a prior period, even though the dealership's own inspection findings do not support a maintenance-related cause. This report is submitted because of the safety hazard posed by unwarned loss of engine power/starting capability while driving, and because this failure pattern appears consistent with a defect the manufacturer has already acknowledged for closely related engine platforms, raising the question of whether additional vehicles with this engine design should be included in that existing warranty/defect campaign.

Filed Apr 2, 2026 · Engine · AL

My 2015 Hyundai Tucson with the 2.4L engine developed a loud engine knocking sound while driving. The knocking became worse and the vehicle became unsafe to drive due to the possibility of sudden engine failure. The vehicle is currently at a Hyundai dealership and has been there for over a month. The dealership denied the warranty claim stating that a different engine component failed instead of the connecting rod bearing. This engine is part of the known Theta II engine defect issue that has caused engine failures in many Hyundai vehicles. A sudden engine failure while driving could result in loss of power, difficulty steering or braking, and could increase the risk of a crash. I am filing this complaint because the engine failure symptoms match the known defect pattern, and the vehicle may be unsafe if the issue is not properly addressed. Hyundai Tucson with 113,000 miles and failing engine. I’ve been told repairs have amounted to $10,000. I was told my car has severe engine failure and must be replaced by Hyundai of the shoals in Tuscumbia, AL. Engine failure is dangerous as a fire may start from a metal piece and also loss of control of vehicle is possible. Hyundai has denied warranty as they say the exact part in theta 2 engine settlement is not failing. I have had to complete recalls on this car since the first payment I made on it. The engine knocking began a month ago and that’s about how long the dealership has had my car.

Filed Sep 25, 2025 · Engine · UT

The engine failed two years ago at 86000 miles. Hyundai replaced the engine for it to start knocking and stop working a year later. I completed all of the first oil changes, slow driving, ect. Seems like an engine problem with Hyundai itself.

Filed Sep 24, 2025 · Engine · SC

I started having oil issues 3 years after purchasing my hyundai Tuscan 2015. I took my vehicle to hyundai several time all of which I was told by service guy and I quote “Hey its Hyundai, just following up so right now we have a consumption issue. It is currently 2.5 quarts low. The tech recommends re doing the oil change and returning in 1000miles and recheck. When you return and we see that the oil level is more than a quote low then we would have you reduce the service interval from 5000miles to 3000miles, let me know if you have any questions. I had many questions and also wanted to know why it was my responsibility to do all these things if they know the engine is faulty. Had another diagnostic and the code P1326 populated. That means indicates an issue with the Knock Sensor Detection System (KSDS), often pointing to actual engine knocking caused by worn connecting rod bearings, but also potentially to a faulty knock sensor, wiring problems, outdated ECM. The Theta II engines are documented to have clogged oil galleys, preventing proper lubrication and causing premature wear. They do everything the can NOT to fix the issue even with a lifetime warranty on that engine.

Filed May 7, 2025 · Engine, Fuel system · GA

On [XXX], my husband and I were driving on [XXX] (Highway) in the slow lane, when the engine shutoff without any Service engine light warning. It was frightening because an tractor trailer was directly behind the car as we lost power. There was no sounds of engine parts knocking or pinging when the problem occurred. The only thing was observed was (two) 2 puffs of smoke seen from the tailpipe, witnessed by my son who was following behind in his vehicle. The vehicle was not able to start after shutdown and had to be towed to my home. We purchased a new battery after assuming battery failure--with no resolve. The vehicle was towed to(two) 2 repair shops with the same conclusion: Seized Engine After checking Open Recalls on my vehicle, I contacted Hyundai to check for assistance. The vehicle is now at the Hyundai dealership in McDonough, Georgia for inspection. I am thankful that my husband and I were not injured or laying in a Morgue after this frighten ordeal on the highway when the Engine suddenly shutoff/Seized. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 9, 2024 · Engine · ID

Our 2015 Hyundai Tucson check engine light started flashing and went into "limp mode" while driving on the freeway. Limp mode means the car loses power to accelerate, struggles going up hills, and limits speed. Thankfully I was not pulling out. The vehicle was towed that day to a mechanic who found traces of metal in the oil (see documentation). The vehicle was then towed to the Hyundai dealer. The dealer explained there is a common problem with Hyundai engines failing due to rod bearing issues and PistonSlap. I later learned the dealership covers the rod bearing issues due to a court settlement from being sued for so many engine issues. The dealership said if they found it was an engine bearing rod issue (ring connecting to the piston) they would replace the engine since it was a safety issue. They claimed if it was a piston slap it would not be covered (even though the bearing rod is connected to the piston and could potentially cause PistonSlap). After checking that the car had been taken care of extremely well with oil changes around every 3 months and all safety procedures had been taken they performed a bearing clearance test. The test passed without error detection so they changed the existing knock sensor. We were directed to drive the car and if the sensor turned on again to bring the 2015 Tucson back. We did and a week later, the new Knock Sensor reported there was something wrong with the engine again. I also noticed when checking the oil that smoke came from the dipstick tube. We took the car to the Hyundai dealer again. They did the bearing clearance test again. It passed again but this time they detected a rattling noise coming from the engine block. According to the records the noise was loudest to cylinder 4. The dealer claimed we needed a new engine that would cost about $9,500. Clearly, this is a piston-manufactured defect. With metal floating in the oil and a limited piston warranty it encourages the owner to drive the car until it brakes.

Filed Jun 28, 2024 · Engine · MI

Ticking sound (loud noise ) from the engine and the check engine light is flashing. The mileage on the car is 142600km.

Filed Jun 22, 2024 · Brakes, Electrical · PA

Bought the vehicle as is with "1 owner, who was older" drove it off the lot and rest drove it, at 57,000 miles. Perfect...that was november 2023.. 3 days later my car was a little low on gas due to they didn't fill it and I left it be, started it drove about 15 miles and it starts sputtering and almost stalls out. Now here I am in June and beginning of June I hear ticking under hood, thinking it's my oil, I changed it (myself) and here it is 3 weeks later oil keeps burning hot, the oil.pressue light comes on when I brake and off when I give it gas, and I don't have any power what so ever when trying to accelerate and doesn't pick up speed unless I'm going downhill. I have 2 small children and a single mom working 5 days a week, I need this car to work. Please hellllpp me . We were going up a hill and I almost got rear ended because my car didn't have power. Not to mention the driver seat fuse keeps blowing out and the bolt keeps breaking so now I can't fit comfortably while.driving and my seat bounces constantly up and down when going over bumps. This was supposed to be my new beginning family car as this is the newest car I've ever owned and it's become an absolute nightmare and I'm scared for me and my children that the engine is going to blow up because that's what it sounds like or I'm going to get smashed by another vehicle due to the fact I have no power

Filed Jun 15, 2024 · Engine · AZ

Vehicle code P1326 Flashing engine light Knocking noises while accelerating Indicates of low oil level When accelerating in doesn’t want to accelerate and it feels like it wants to stall out and shut off

Filed Feb 29, 2024 · Engine · TX

I went to get my car looked at a couple months ago and was told the oil pan was leaking . So the day I get it changed the car shuts off while I’m driving ; I began to loose acceleration, the oil light starts to flash , the engine light is flickering while the car is shaking making a knocking noise .

Filed Dec 29, 2023 · Engine · WI

I have a 15 Hyundai Tucson that has been shutting off on me while driving on a highway going between 55 mph to 70 mph. Engine went into limp mode, CEL is on and flashing. Knocking noise heard from engine and consuming oil. Diagnosed with P1326 code. Brought to local Hyundai dealership. Even though road test stated normal operation, technician notes that vehicle DID stall, shut off, on return to the shop. No codes. Was told Hyundai would not pay for man hours to look into further. So allowed me to drive off their lot. Upon re-search I found, with NO help from local Hyundai or the dealership I purchased vehicle from, that my VIN number is associated with the E2 class action settlement that just went live May 2023, that my engine is indeed infected, like a cough before the cold, and has the potential of starting on fire/failure. Now I purchase this vehicle in 08/2023 with no disclosure of this very concerning problem. I am told by Hyundai USA that there is a paper trail that every affected VIN in the settlement has been notified, by law, to owners of affected VIN’s, and still not disclosed. I reached out to Hyundai USA at the national level, was given a case manager, who sent my case to the buyback/legal department. My case manager reached out and stated that my case has been denied due to age and mileage of vehicle (even though automatically extended to 15yr/150,000 miles) I asked what my next steps should be as my vehicle is still shutting off on me while driving and was told to have a different Hyundai dealership diagnose vehicle, but to not tell them all of the information of it already going to one Hyundai dealership. I was told if I hear a noise from the engine that I should pull off to the side of the road and call for a tow truck. I said so Hyundai USA feels good allowing this vehicle to be operated on highways knowing the symptoms I am experiencing. They obviously do not care for my safety let alone passenger safety, nor other motorist on roads.

Filed Mar 9, 2023 · Acceleration, Engine · NY

I am writing to express my concerns regarding the recall repair performed on my 2015 Hyundai Tucson on October 5th, 2022. I have received numerous letters from Hyundai regarding an open recall and finally received a notice stating the remedy was ready. I scheduled an appointment with Matthews Hyundai of Syracuse and took the vehicle for the recall. Unfortunately, after taking the vehicle back to the dealership, I was advised that the check engine light was on and the issue was a result of a faulty knock sensor and purge valve. I was asked to pay more than $100 for the repairs. However, after further discussion, it was concluded that I wouldn't be charged. However, after only two days, the engine check light came on again, and the speed reduced to 45 MPH on the highway. I was then told that the problem was from the ignition coil and was charged $232.72 for the repairs. Despite paying the full price, the same problem occurred again, and I had to take the vehicle back to the dealership seven times, paying a total of $1,160.67. Throughout this recall repair failure, the vehicle's check engine light would come on, or it would randomly lose power, making a knocking sound and reducing speed even while driving. I no longer feel safe in this vehicle, and it has resulted in thousands of lost wages as it is the only vehicle I use for my work and personal use. On December 1st, I wrote a complaint to the New York division of vehicle safety and was advised to take the vehicle to a different Hyundai authorized dealership for diagnostics. I took the vehicle to Burdick Hyundai of Cicero, and after a week, they stated they were able to find the problem. However, Hyundai denied the claim for repairs on the vehicle. Since then the vehicle inspection has expired, and I took the vehicle to a shop for inspection. They stated they could not pass the inspection as the vehicle speed would not exceed 45MPH.