2023 Hyundai Tucson engine problems

Filed Jul 23, 2026 · Electrical, Engine · PA

The vehicle developed an intermittent but potentially dangerous engine control malfunction. After the engine reached normal operating temperature, the engine speed (RPM) would repeatedly surge while the vehicle was stopped in Park and Neutral, fluctuating from approximately 1,000 RPM to over 3,000 RPM without any throttle input from the driver. The condition occurred with the air conditioning turned off and could be reproduced multiple times. At approximately the same time, the Auto Start/Stop system stopped functioning and displayed a warning indicator. A malfunction indicator lamp (check engine light) also appeared during the incident. The warning light later turned off, but the engine surging continued. This unexpected increase in engine speed raises concerns about unintended vehicle movement or loss of driver control if the condition were to occur while shifting into gear or while driving. The unpredictable nature of the malfunction presents a potential safety risk to the occupants of the vehicle and to others on the road. The vehicle has been taken to an authorized Hyundai dealership for diagnosis and repair and remains under inspection. The problem is available for inspection. During my research, I found numerous reports from other Hyundai owners describing similar engine surging, idle fluctuation, and Auto Start/Stop malfunctions involving comparable vehicles. Because similar complaints appear to have been reported by multiple owners, I am submitting this report so the issue can be evaluated for a possible broader safety defect. I have videos of the incident

Filed Jul 8, 2026 · Acceleration, Engine · NC

I was on the highway on the way to work when my car started stalling. Every time I pressed the gas to give it some power, it would not go anyway where. after getting it towed to get looked at some of the fuel injectors failed and were misfiring. The warning message about ‘check engine’ popped up 2 minutes before it happened. this is the third time now in less than 6 months.

Filed May 14, 2026 · Engine · CT

The car has 57,000miles and needed a new transmission. Safety concern of the transmission failing while driving. There was a persistent and worsening rubbing noise once the car ran for 20 minutes or so. 4 visits to the dealer later, they confirmed the issue and Hyundai issued a warranty to replace the transmission with a remanufactured transmission. When I asked the dealer what happened, he said this was there 4th one in a few weeks. There were no indicator lights or anything besides the noise to indicate there was a problem.

Filed Apr 29, 2026 · Engine, Fuel system · NY

Sitting at a red light the vehicle seemed to almost stalled then lunged forward about eight feet almost colliding with the vehicle in front of me. To my knowledge the vehicle has not been inspected by the manufacturer nor has the problem been reproduced by a dealer or independent service center. To my knowledge there were no warning lights, messages or symptoms. I am somewhat unfamiliar with this vehicle since I've only owned it for 5 days. I picked it up on 4-25-26.

Filed Jan 28, 2026 · Engine, Fuel system · ME

All four cylinders misfired in my car while driving causing the catalytic converter and all four fuel injectors to need to be replaced. My car suddenly stopped driving in a rural area with only a few minutes of warning when the engine light came on. I was not even able to drive to a nearby shoulder. I was stranded on the side of the road in 5 degree weather until a tow truck could come.

Filed Oct 15, 2025 · Acceleration, Engine · 19,241 miles · PA

The contact owns a 2023 Hyundai Tucson. The contact stated that while driving at approximately 5 MPH in a parking lot and slowing down to park the vehicle, the vehicle independently accelerated. The contact depressed the brake pedal with force and stopped the vehicle, and was able to shift to park(P). The contact stated that the RPM revved up to 8,000 RPM, and the contact turned off the vehicle. There were no warning lights illuminated. The contact had taken the vehicle to a local dealer, and the dealer was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was 19,241.

Filed Sep 16, 2025 · Acceleration, Engine · FL

My 2023 Hyundai Tuscon has 36000 miles. Started running rough with a slight noise. First noticed on Wed [XXX]. On Thursday [XXX] I went to start my car and it stalled. Finally after letting it sit a few minutes it started but only to have the SGI light flash yellow and stay yellow for the remainder of the drive. That day I made an appt at my local Hyundai Dealership in Brandon Florida. They kept my car. Fast forward, Monday September 15th I was notified that the car had lost a significant amount of oil. Car was inspected and free of any leaks. Tech stated because of the low oil & oil pressure the battery life was significantly impacted. I would need an oil change & new battery. Upon arriving back I came across an article stating that excessive oil consumption is common among these vehicles and the dealer wasn't even going to notify me of this issue. They were not honest and I want to file a formal complaint knowing that this is well known issue. I feel unsafe driving my children around and am upset that a recall has not been issued to fix this. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 11, 2025 · Electrical, Engine · 26,500 miles · OH

The contact owns a 2023 Hyundai Tucson. The contact stated while driving approximately 45 MPH, the accelerator pedal was depressed while merging onto a highway, but the vehicle lost forward momentum. The contact stated that the message "Limited to 20 MPH" was displayed on the instrument cluster. The contact depressed the accelerator pedal, and the vehicle failed to respond as needed. The contact stated that the engine was not revving. The contact pulled off the highway and into a parking lot. The contact turned the vehicle off and on, and normal driving was resumed. The contact stated that the failure was intermittent and was occurring while accelerating. Additionally, the contact stated that upon starting the vehicle in the morning, the vehicle would jump forward while still in park (P). Additionally, the contact stated that the horn had stopped functioning after the last loss of forward momentum but had returned to normal function a few days later. The vehicle was taken to a local dealer, however, the dealer was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 26,500.

Filed Jul 3, 2025 · Brakes, Engine · IN

Engine misfiring, causing low power on interstate 70 also losing brake control.

Filed Apr 13, 2025 · Acceleration, Engine · AZ

2023 Hyundai Tucson with just over 14,000 miles failed to accelerate. After completing a right turn the vehicle seemed like it went into neutral. A green warning light appeared stating limit 20 mph. I now know this is “limp mode”. Turning the vehicle off and back on seemed to resolve the issue. The vehicle was towed to the dealer. They found nothing wrong. I was told to take a picture of the warning next time. I was fortunate to not have caused an accident. This is incredibly dangerous.