2024 Hyundai Tucson: engine stalls while driving

Filed Jul 7, 2026 · Engine, Fuel system · VA

Subject: Urgent Drivability Concern – 2024 Hyundai Tucson (6/22 Incident) Vehicle: 2024 Hyundai Tucson Date of Incident: XXX Trip Details: [XXX] to [XXX] (~160+ miles) Summary of Issue: During a long-distance drive on XXX, the vehicle experienced severe and consistent drivability issues that created unsafe driving conditions. Symptoms Observed: •Severe loss of acceleration / stalling behavior throughout the entire trip •No check engine light illuminated at any time •When pressing the accelerator: oTachometer increased (RPMs rising) oVehicle speed decreased or failed to increase appropriately •Significant delay in acceleration, especially when: oMerging onto the interstate oPassing other vehicles •Cruise control behavior: oSeemed to manage acceleration more effectively than manual throttle oHowever, still exhibited slow response when additional acceleration was required •Auto Start/Stop system: oSystem automatically disabled itself oWould not allow reactivation during the trip Safety Concern: This condition made it difficult and unsafe to: •Merge into traffic •Maintain appropriate highway speeds •Execute passing maneuvers Dealer Visit (Near [XXX]): •Vehicle was inspected after sitting for a couple of hours •Dealer reported no issues found •However, the problem was persistent and clearly present during operation under driving conditions Took vehicle to a dealership in Raleigh and asked that they look at the fuel injectors. They determined that all 4 injectors were failing and replaced them under warranty. Concerned that Hyundai America has not issued a recall as driving the vehicle with this issue creates a serious safety concern that would lead to injury or loss of life INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 4, 2026 · Engine, Fuel system · GA

Component: Engine/Powertrain/Electrical System Incident Description: I am reporting a recurring, life-threatening "Loss of Motive Power" (Dead Pedal) in a 2024 Hyundai Tucson (Alabama-built). On multiple occasions, the vehicle has failed to respond to throttle input during high-risk maneuvers, specifically while merging into 45+ MPH traffic. The vehicle "chugs" and stalls, refusing to exceed 15 MPH despite full accelerator depression. This defect leaves the vehicle and its occupants stranded and defenseless in the path of oncoming high-speed traffic. Technical Context: This vehicle is currently subject to the federal safety agency Recall 23V‑526 (Hyundai Campaign 246) for electronic controller damage that can cause "CAN communication disruptions." I believe the "Dead Pedal" failure is a direct result of these communication disruptions between the engine and transmission control modules. Furthermore, Hyundai has issued TSB #24-AT-001H-1 for "Hesitation when accelerating," yet the authorized dealer (Ed Voyles Hyundai) has been unable to remedy the defect after 84 cumulative days out of service. Safety Risk: This is not a convenience issue; it is a critical safety failure. The unpredictable nature of the power loss makes it impossible to safely judge gaps in traffic. The vehicle effectively becomes a stationary object on active roadways without warning. Manufacturer Response: The manufacturer has been formally notified via certified legal counsel. Despite 79 consecutive days in the current repair attempt (since Jan 16, 2026), the manufacturer has failed to provide a fix or acknowledge the severity of the safety risk. An informal third-party evaluator attempted to dismiss the claim despite the vehicle's documented inability to maintain motive power. We are requesting that the federal safety agency investigate the adequacy of Recall 23V‑526 and TSB #24-AT-001H-1, as these measures have failed to resolve this life-threatening "Dead Pedal" condition in my vehicle.

Filed Mar 2, 2026 · Engine · NJ

On October 8, 2025, my car's tachometer started to dip and my car began to shake like it was going to stall as I approached a traffic light. The check engine light came on. I was close to my destination (about a 1/4 mile) so I drove to the parking lot and turned off the car. I started it again and the check engine light turned off and the car was running fine. On October 13, 2025, I took my car in for a routine oil change to a local repair shop and when they tried to reset the oil change reminder, the system would not work. Within a day, the entire computer system for the radio, warning systems, air conditioner/heat, etc, would not work. I took it to Burlington Hyundai on October 15, 2025 and they had to replace the CPU in the car. I got my car back on October 22, 2025. They said the check engine light did not come on again. It was covered under my warranty. I had my brakes replaced while they had the car out of convenience.

Filed Mar 2, 2026 · Engine · NJ

On Saturday January 31, 2026, I was driving and the tachometer started to go low like the car was going to stall out and the car began to shake. Then the check engine light came on. I was afraid to drive it, so I parked it in a church parking lot and had it towed to Burlington Hyundai on Sunday February 1, 2026. On Monday February 2, 2026 Burlington Hyundai said there was a problem with the spark plugs and that was why the check engine light came on. They replaced the spark plugs and it was covered under warranty. I got my car back on Tuesday February 3, 2026.

Filed Mar 2, 2026 · Engine · NJ

On Wednesday February 4, 2026 my car began to shake and shudder and almost stall out and the check engine light came on again. I had just gotten my car back from Burlington Hyundai the day before for the same problem. I drove it straight to the dealership for service. This time, they said it was a problem with the EGR system. They replaced some things and I got my car back on Friday February 13, 2026.

Filed Jun 6, 2025 · Fuel system · NY

On multiple occasions the vehicle has not transferred from EV to mechanical mode and has stalled out. Shutting the car and restarting it resolved the problem each time. Hyundai has not been able to find the fault after multiple trips to the dealership and no code is recorded or reported. I bought a code reader and the last time this occurred recorded a code. P1120 $07e8Pd I brought the car back into Hyundai and reported the code to- It was not saved in the car's memory. They have had the car for over 3 weeks now and repairs have not been completed.

Filed May 5, 2025 · Electrical, Engine · 18,000 miles · TX

The contact owns a 2024 Hyundai Tucson. The contact stated while driving approximately 60 MPH, the vehicle stalled. The contact stated that before the vehicle stalled, there were several unknown warning lights illuminated before the instrument cluster went black. The contact pulled over and shifted to park(P) and was able to restart the vehicle after several attempts. The contact stated that the failure had occurred intermittently and at various speeds. The vehicle also occurred while stopped at a traffic signal. The contact had taken the vehicle to a local dealer who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 18,000.

Filed Aug 13, 2024 · FL

I had the windshield recall repaired and my car still leaked. It has been at the dealership for over 2 weeks for repair. I am concerned whether this vehicle will be safe to drive even after a new windshield is in stalled and all of the carpeting has been replaced. The vehicle is only 8 months old from the time I purchased it from the Hyundia Dealership