2016 Hyundai Tucson: engine stalls while driving

Filed Jul 28, 2026 · Engine, Transmission · FL

While stopped at a traffic light, the engine began producing a loud metallic clattering and clanking sound, consistent with connecting rod bearing failure (rod knock). There was no prior warning light or indication of this specific failure. When the light changed, the vehicle would not accelerate normally, leaving me stalled in a lane of moving traffic. I was forced to make an emergency turn to get the vehicle out of the way of oncoming and crossing traffic. The engine would not hold an idle afterward and has not run since. The vehicle was towed to a Hyundai dealership, where a service department employee stated by phone that this 1.6L turbocharged engine family has a known, documented history of severe factory defects affecting the connecting rod bearings.

Filed Jun 3, 2026 · Engine · 125,000 miles · TN

The contact owns a 2016 Hyundai Tucson. The contact stated while driving 50 MPH, the vehicle failed to accelerate as intended and stalled. There was no warning light illuminated. The contact was able to pull over to the side of the road, where the contact restarted the vehicle. The contact drove to his workplace and parted the vehicle. However, the vehicle later failed to start. The vehicle was towed to the dealer it was purchased from, and the contact was informed that the engine had failed. The vehicle was not repaired. The vehicle was then towed to Affordable Towing and Repair, where it was diagnosed that the engine had failed and needed to be replaced. The manufacturer was not contacted. The vehicle was towed to 125,000.

Filed Mar 30, 2026 · Engine · 94,000 miles · OH

The contact owns a 2016 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the engine compartment. Moments later, the vehicle stalled after driving a very short distance. An independent mechanic arrived at the residence to perform an oil change and found metal shavings inside the oil. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 94,000.

Filed Mar 25, 2026 · Engine, Transmission · IN

Hyundai Tucson Sport 2016 GDI engine. I am the original owner of this truck I have taken care of this truck so much it being my first brand new purchase. No oil leaks NOTHING! When I first purchased the vehicle I noticed that it would stall when I would accelerate but did not think too much of it since it was brand new. A few years passed started to notice frequent oil changes were supposed to be made. Another few years turbocharger went out had to get it replaced. The engine consumes so much oil at first I thought it was because the turbocharger was out so when I got it fixed I thought that would fix that issue and it didn’t. I got an oil change March 2, 2026 and on March 21, 2026 I was on the highway and the truck started to shake really bad I exited the highway went straight to the oil place they said I had no oil on the dipstick I got ANOTHER oil change (expensive) and when I turned on the car to leave the car shook again and the engine light was flickering on and off and finally stayed on the dash board. Barely made it home. Got a tow truck to tow it to Hyundai dealership they told me they will not see it unless I pay the diagnostic fee of $200 and even then they think it’s the engine with everything I described to them. They said since there are no recalls on the Tucson that Hyundai will not do anything for me I would have to pay out of pocket for everything. Had to pay the tow truck again to tow it to my house ($250). My car has all the symptoms all the other cars have that they have recalled. This is a huge safety issue because i drive on the highway a lot and everyone knows a car with no oil is extremely dangerous.

Filed Jan 5, 2026 · Engine · NY

While driving under normal conditions, my engine experienced a sudden and catastrophic failure. The check-engine light illuminated, the vehicle began shaking violently, and I was forced to pull over immediately due to safety concerns. There was no prior warning and no oil pressure or oil warning light activated at any time before or during the failure. After stopping safely, I checked the oil level and found it lower than expected. I added oil as a precaution, but the condition did not improve and the vehicle became inoperable and required towing. The engine assembly remains intact and available for inspection upon request. This failure posed a serious safety risk, as the loss of engine function occurred without warning while the vehicle was in motion, creating the risk of stalling or loss of control. The vehicle was inspected by an authorized Hyundai dealership. Hyundai Motor America denied warranty and goodwill assistance, citing mileage and alleged insufficient maintenance documentation, despite the vehicle being within the 10-year powertrain period and despite the nature of the failure. Routine maintenance was performed throughout ownership; however, some historical service records are unavailable due to the age of the vehicle and changes in service locations over time. Multiple facilities no longer retain records from that period. Notably, no oil warning indicators never activated, which raises concern regarding the failure mechanism. Hyundai has acknowledged widespread engine issues in this engine family involving oil consumption, bearing failure, and sudden engine seizure. The symptoms and progression of this failure closely align with those known defect patterns. This complaint is submitted to document a sudden engine failure presenting a clear safety concern and to assist in identifying potential defect trends. This car has undergone previous engine repair, AC condenser and entire turbo by their service department previously 2022 & 2024 respectively.

Filed Dec 6, 2025 · Engine · PA

Vehicle is showing KSDS-related engine warning behavior and the Hyundai dealership performed a diagnostic scan. The service manager told me, “I don’t recommend you driving it,” due to a potential engine safety issue. However, Hyundai Motor America’s National Consumer Affairs team is refusing to authorize towing or a loaner/rental until after a full diagnosis is completed. The dealership cannot complete the diagnosis unless the vehicle stays on-site, but I am unable to safely leave it because Hyundai is refusing transportation assistance and I was told not to drive it. This forces me to drive a vehicle they identified as unsafe in order to complete the required inspection. This involves KSDS/engine failure risk, which has been associated with stalling, loss of power, and possible fire hazards. Being advised not to drive while being denied towing or transportation creates a serious safety concern for myself and my children. I am requesting the federal safety agency document this incident because Hyundai is creating a safety hazard by refusing support for a vehicle they identified as unsafe to operate.

Filed Nov 21, 2025 · Engine · PA

Part(s) Affected: Engine / Engine Control / Stall / Loss of Power Summary: My 2016 Hyundai Tucson (VIN: [XXX] ) has an active P1326 – Knock Sensor Detection System (KSDS) code, which indicates rod bearing wear and imminent engine failure. The vehicle experiences: •loss of power •inability to accelerate •engine hesitation •risk of stalling while driving These are serious safety risks. This issue is part of the Hyundai/Kia engine defect settlement XXX), yet Hyundai refuses to provide towing or address the safety risk despite the P1326 code being a known precursor to engine seizure. The vehicle is currently unsafe to drive, and Hyundai Customer Care has refused to escalate my case according to settlement requirements. This is a safety hazard that can cause engine seizure and sudden loss of power while driving. Details: •Hyundai Case #: XXX •Engine settlement code P1326 confirmed •Hyundai refusing proper support •Vehicle should not be driven the federal safety agency intervention is needed due to Hyundai’s failure to address a known safety defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Nov 17, 2025 · Engine · CA

The contact owns a 2016 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. In addition, the contact stated that the vehicle stalled, and there was an abnormal sound coming from the engine. The check engine warning light was illuminated. The contact took the vehicle to Auto Zone, and a scanner was used to diagnose the vehicle. And it was determined that the catalytic converter had failed. The contact took the vehicle to an independent mechanic, who diagnosed the vehicle with oil intrusion into the catalytic converter. The contact stated that the failure persisted. The contact stated that on a separate occasion, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact stated that the engine was consuming an excessive amount of engine oil, and an abnormal sound was coming from the engine. The contact stated that the vehicle stalled again. The contact was adding seven quarts of oil for every 3,000 miles driven. In addition, the catalytic converter failed to function as intended. No warning light was illuminated. The contact was concerned that the engine could fail. The manufacturer was made aware of the failure. The failure mileage was unknown.

Filed Nov 7, 2025 · Engine · IL

My 2016 Hyundai Tucson has a severe engine defect that causes excessive oil consumption and poses a safety risk while driving. It constantly throws the P1326 engine issue, which is the knock sensor.The issue is not due to any misuse or neglect on my part. The vehicle consumes approximately one quart of oil per week, and I have been advised by two different Hyundai dealerships not to invest any money into repairs because the engine should be replaced under Hyundai’s extended engine warranty (15 years/150,000 miles).Despite multiple attempts to get the issue resolved over the past year, Hyundai continues to deny the engine replacement, leaving me with no resolution and forcing me to drive an unsafe vehicle.The engine burns an excessive amount of oil and needs frequent refilling to prevent damage.The vehicle has stalled and runs rough at times, creating a safety concern.Both Hyundai dealerships I’ve visited confirmed that this is a known issue and advised me not to spend money on repairs since the engine qualifies for replacement under the extended warranty.Hyundai corporate continues to deny coverage and has not repaired or replaced the engine despite the clear warranty terms.The issue has persisted for nearly a year, and the vehicle continues to deteriorate.I believe this defect poses a serious safety hazard because the engine can fail without warning while driving. The excessive oil consumption also increases the risk of engine seizure, stalling, or fire. I am currently forced to operate the vehicle in unsafe conditions due to Hyundai’s inaction. I am requesting that the federal safety agency investigate this ongoing engine defect and Hyundai’s repeated denial of warranty coverage for affected Tucson models. Owners should not be forced to drive unsafe vehicles or pay for repairs that should be covered under Hyundai’s extended

Filed Sep 29, 2025 · Acceleration, Engine · TX

Engine or transmission The vehicle has stalled randomly multiple times on the freeway, business roads and intersections, not accelerating and burning through oil Dealership says they cannot figure out or replicate the issue No check engine light or warning of any kind given

Filed Aug 21, 2025 · Engine, Fuel system · MD

1. "Transmission or ECU" 2. There is a lag and sometimes almost stall when accelerating from a stop. I was turning into a lane from a stop sign and the car decided to not move for 3-4 seconds after pressing accelerator. If people had come around the blind corner when that happened I would have been T boned. 3. All four people living in my house...... and our mechanic. Yes 4.No, because were not paying for something that has had a recall. 5. We inherited this car from my grandmother and she knows nothing about cars so she never thought anything was wrong. Since the day we got it, it has been doing the same thing "DCT CONTROL LOGIC UPDATE & P0128 DTC LOGIC UPDATE (RECALL 149)" #17-01-023

Filed May 31, 2025 · Engine, Transmission · TX

I’ve been having ongoing issues with my 2016 Hyundai Tucson where the car struggles to accelerate, especially after stopping at red lights or pulling out into traffic. Sometimes, when I press the gas pedal, the car either hesitates badly or doesn’t move at all. A few times it’s completely stalled while trying to make turns or cross intersections, which has been really scary and dangerous. I did some research and found there was a known recall for this exact problem related to the Transmission Control Module software and the dual-clutch transmission. The symptoms described in the recall match mine perfectly, but when I checked my VIN, my vehicle isn’t included. I haven’t taken it to the dealer yet because I’m worried I’ll have to pay out of pocket for something that I believe is part of a known manufacturer issue.