Tl* the contact owns a 2001 isuzu rodeo sport. While inspecting the vehicle, the contact noticed corrosion on the undercarriage. The vehicle was taken to the dealer where it was confirmed that the rear suspension lower link bracket was corroded and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 180,000.
The worst 2001 Isuzu Rodeo Sport problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Body20
- Suspension13
- Fuel system8
- Electrical5
- Brakes4
- Engine4
- Acceleration2
- Steering2
- Transmission2
- Visibility2
- Airbags1
- Wheels1
Specific symptoms reported on the 2001 Isuzu Rodeo Sport
Recalls 1
Fuel system, gasoline: delivery: hoses, lines/piping, and fittings
- What is wrong
- Vehicle description: sport utility vehicles. During the manufacture of certain fuel return hoses, incorrect rubber material for the outer layer was used.
- Risk
- The fuel return hose does not meet ozone-resistant specifications, and could ultimately crack, causing fuel leakage. Fuel leakage in the presence of an ignition source could result in a fire.
- Remedy
- Dealers will inspect the vehicle to determine if the vehicle was equipped with an incorrect hose. If it is incorrect, dealers will replace it.
Recall number 00V298000 · Recall details
See all 1 recalls for the 2001 Isuzu Rodeo Sport
Defect investigations
Rear suspension lower link failure
During preliminary evaluation pe09-030, isuzu motors america, inc (isuzu) noted two primary differences once the rear suspension lower link separation occurs between the alleged defect (separation of the lower link from the frame) of this investigation and a safety defect involving lower link separation from the rear axle addressed by isuzu in safety recall 00v‑058.in the case of the defect condition identified in recall 00v‑058, isuzu stated that the attachment bolt could detach fully, causing separation of the lower link from the rear axle possibly creating a loss of vehicle control. Isuzu also stated that this condition occurs early in the service life of the vehicle.in this investigation isuzu noted lower link separation from the frame is a progressive corrosion issue with prior warning to consumers.isuzu also stated that in the event of a lower link separation from the frame, the vehicle is still controllable and can be safely stopped. The office of defect investigation (odi) analyzed complaint data provided by isuzu and america honda motor company, inc (honda), as well as vehicle owner questionnaires submitted to odi from consumers.in total, there were 60 unique reports of lower link separations from the frame including 1 alleged crash and 7 loss of vehicle control incidents that may be related to the alleged defect.most of these complaints indicated that there was no warning prior to the link separation.this preliminary evaluation has been upgraded to an engineering analysis (ea09-018) to further assess the scope, frequency and risk to motor vehicle safety of the alleged defect in the subject vehicles.
PE09030
Technical service bulletins for the 2001 Isuzu Rodeo Sport 23
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This bulletin outlines the procedures for using the Alpine Exchange Program (the "Exchange Program"). The...
- Isuzu Commercial Truck of America, Inc. (ICTA) is providing the following procedural recommendations to...
- The following is a list of the Isuzu-recommended Threebond product part numbers identified in the various...
- The Isuzu Commercial Truck of America (ICTA) Service Technical Assistance Center (TAC) provides diagnostic...
- Rear brake rotors
- Shift lock solenoid removal and replacement procedures
- Poor and/or loose door weatherstrip position
- Throttle body mounting bolt torque specifications
- Replacement odometer programing
- Door check arm popping sound
What 2001 Isuzu Rodeo Sport owners say
Most recent owner complaints, unedited.
Tl* the contact owns a 2001 isuzu rodeo sport. The contact stated that the frame was severely corroded and the rear lateral arm was fractured. The vehicle was not repaired. The contact was made aware that the federal safety agency campaign number: 104v36000 (suspension) had expired. The manufacturer was made aware of the issue. The failure mileage was 180,000.
I got a letter from isuzu asking me to come in for a recall due to pre-mature frame rusting I was told they had to lift the body off the frame to inspect it and I was having the gas-level sender replaced at the same time. I was told by the service department that bolts holding the cassis to the frame had a tendency to fail so they were being replaced with stainless steel hardware. When I got the truck back the new shiny bolts and nuts were visible externally and I was assured that my truck was not that bad and it was just a precautionary measure. I was told the frame was in pretty good shape and that they applied some anti-rust treatment to the areas and for added strength, 2 reinforcement bars were bolted to the sides of the frame ( this was dome and verified visually by me ). About two years later, while having my exhaust manifold replaced due to excessive rot, I was informed that my frame was not safe because it was almost completely rotten in numerous areas and told that whoever tried to fix it knew that it was in terrible shape and simply put a band=aid on it and hit it with some anti-rust paint to make it look better. Just the frame was rotting, not the body or other parts. The official tsb apparently to shore up the frame by bolting two steel bars along the sides, unless the frame is so rotted out that it has to be replaced. So if I had not garaged my truck and been extra careful about washing the undercarriage, I could have gotten a brand-new frame, (or a trip to the emergency room if the frame broke while I was driving at almost any speed never mind highway speed). I am the original owner of this truck and have followed all tsb/recalls and recommended maintenance schedules. I love the truck, but I need it to be safe and very soon it may not pass safety inspection in my state. I have read about many people trying push for some sort of legal action on this.
While driving in vehicle, approximately 35 MPH, normal dry conditions, driver-side rear suspension trailing arm bracket broke free from frame. Vehicle veered right slightly and generated a groaning sound. Pulled vehicle off the road. Upon inspection underneath vehicle realized frame section corroded completely through allowing trailing arm bushing mounting bracket to completely separate from frame. Low mileage (considering year) well cared for vehicle in otherwise good condition. Have sense learned this to be an all too common problem known by oem but not by secondary buyers, these vehicles should not be on road. Less than a years use from this vehicle after loan/purchase.
The frame is so badly rotted out that it won't pass a safety inspection .
Eroding frame underneath car. My car shakes and squeaks horribly! My car is so badly rusted that I have holes and I can see through the car underneath!
Tl* the contact owns a 2001 isuzu rodeo sport. The contact stated while the vehicle was being inspected rust was found around the frame. The vehicle was not repaired. The manufacturer was notified of the defect. The approximate failure mileage was 130,000. The current approximate mileage was 140,000.
Tl* the contact owns a 2001 isuzu rodeo sport. The contact stated that after receiving notification of the federal safety agency campaign I.d. 10v436000 (suspension:rear), the vehicle was taken to the dealer for recall repairs. After inspecting the vehicle, the dealer advised the contact that the rust on the frame was too excessive and could not be repaired. In addition, the dealer advised the contact that the vehicle was unsafe to drive. The vehicle was not repaired. The failure mileage was 53,123.
I had a mechanic look at my truck because of an exhaust leak, while inspecting, he found a break/separation of the right frame where the forward mounting rear suspension bracket attaches. The left side of the frame is also rotted but not yet broken. I took it to an isuzu dealer in massachusetts, & they took pictures of the problem, then reported it to isuzu. I called isuzu's (800) help line to ask what they could do to repair my truck, they said nothing, they were not recalling that particular truck model but took my information.
2001 isuzu rodeo sport. Consumer states corrosion frame cracks *tgw the consumer stated a recall was issued for the 4-door models, but not the 2-door models. *jb updated 07/03/12 the consumer wanted to know why the manufacturer was allowed to limit its fix of vehicle's regarding the recall. Updated consumer letter 06/29/12*jb updated 05/25/12
Compare the 2001 Isuzu Rodeo Sport
Other model years
Questions about the 2001 Isuzu Rodeo Sport
Is the 2001 Isuzu Rodeo Sport reliable?
Owners have filed 49 complaints about the 2001 Isuzu Rodeo Sport, 2.1 times a typical Rodeo Sport model year.
What is the 2001 Isuzu Rodeo Sport year score?
The 2001 Isuzu Rodeo Sport scores 47 out of 100 (below average). The score compares it with the other model years of the Isuzu Rodeo Sport: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2001 Isuzu Rodeo Sport?
Body and structure, with 20 complaints, typically around 103,000 miles. Next is suspension (13).
How many recalls does the 2001 Isuzu Rodeo Sport have?
1 recall, covering fuel system, gasoline.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2001 Isuzu Rodeo Sport?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history