2003 Itasca Sunrise problems

What is wrong

Winnebago is recalling certain recreational vehicles equipped with 1200-series norcold refrigerators. The population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. The response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.

Risk

The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.

Remedy

Winnebago is working with norcold to identify and notify any affected owners. Owners will be instructed to contact norcold dealers to receive the remedy free of charge. Please see norcold's defect report 10e-049 for additional information. The recall began during december 2010. Owners may contact norcold at 1‑800‑767‑9101 or winnebago at 1‑641‑585‑3535.

Recall number 10V525000 · Recall details

What is wrong

Winnebago is recalling 1,547 model year 2001-2003 recreational vehicles equipped with norcold model 1200lrim refrigerators, manufactured from march 1, 2001 to december 31, 2002, with serial numbers between 1273701 and 1536607, non-consecutively. A fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak. If a leak occurs and the refrigerator continues to be operated after solution circulation has ceased the heat source could generate very high temperatures. At such high temperatures, the cooling unit could rupture.

Risk

If a leak occurs and the unit is continues to operate, hydrogen gas may be expelled and can be ignited, resulting in a fire, possibly causing serious injury or death.

Remedy

Winnebago is working with norcold and norcold will notify owners and the vehicle's refrigerator will be repaired free of charge (please see 09e-027). Owners may contact norcold's recall center at 1‑800‑767‑9101.

Recall number 09V300000 · Recall details

What is wrong

Winnebago is recalling 2,331 my 2002-2004 brave and itasca sunrise my 2005 2006 winnebago voyage, adventurer, itasca sunrise and suncruiser motor homes. The propane tank mounting bracket may have an incomplete or improper weld.

Risk

Should the weld fail, the propane tank can tip or fall, possibly releasing propane which has the potential to ignitea fire, resulting in personal injury and/or vehicle and property damage.

Remedy

Dealers will inspect and properly weld the bracket free of charge. The recall is expected to begin during may 2009. Owners may contact winnebago at 800‑537‑1885.

Recall number 09V113000 · Recall details

What is wrong

On certain motor homes built on a 20,700 gvwr or greater workhorse chassis, there may not be sufficient clearance in the area where the fuel line crosses the frame cross member.

Risk

Without clearance, a condition could develop where the cross member may wear into the fuel line and a fuel leak may develop. Fuel leakage, in the presence of an ignition source, could result in a fire.

Remedy

Dealers will repair these motor homes by providing clearance between the fuel line and frame cross member. The fuel line will be inspected and, if necessary, replaced. The recall began january 7, 2005. Owners should contact winnebago at 1‑800‑537‑1885.

Recall number 04V609000 · Recall details

What is wrong

On certain motor homes equipped with samsung microwave ovens, these units were produced with a defective panel. An electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a "jumper" or jump wire. This may cause the oven to activate without pressing any key pads.

Risk

An electrical short can occur causing the oven to activate without pressing any key pads. This could result in excessive heat, smoke, or possibly a fire.

Remedy

Samsung will notify customers and repair the panel free of charge. In the meantime, consumers should unplug their microwave, if possible. If the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. Consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 800‑932‑3837 or winnebago at 641‑585‑3535.

Recall number 03V405000 · Recall details

What is wrong

Certain motor home chassis fail to comply with the requirements of federal motor vehicle safety standard no. 105,"hydraulic and electric brake systems." the brake system warning indicator may not function as required by the standard.

Risk

In some of the affected vehicles, the brake system warning indicator will not illuminate when the ignition is in the start position or for a low brake fluid condition, if the body builder relied solely upon ford's ivm compliance statement for the system warning indicator.

Remedy

Dealers will repair these vehicles. Owner notification began april 25, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact winnebago at 1‑641‑585‑3535.

Recall number 03V060000 · Recall details