Jeep Cherokee fire or smoke problems

Filed Oct 25, 2026 · Transmission · NJ · fire

Whilst driving on the highway at approx 65mph there was a clunk from under the car, followed by lack of acceleration, smoke was coming out from under the hood. We were unable to pull onto the shoulder immediately due to highway construction. We eventually pulled over and stopped the vehicle. We immediately popped the hood to check the source of the smoke and there was a fire coming from behind the engine with visible flames. The flames were burning and we could smell a strong chemical / oil burning smell. Fortunately we had a fire extinguisher and extinguished the flames quite quickly. We were towed off the highway and our insurance then towed us home. On inspection it was determined that the transfer case (PTU) had failed causing a catastrophic failure and a fluid thermal event caused by pressurized, superheated oil directly spraying onto the scorching exhaust pipe sitting right behind the engine block, triggering the immediate underhood fire. There were no warning lights on the dashboard and the car had been meticulously maintained. As serious PTU failures are common in 2015 Jeep Cherokees, I reported this immediately to Jeep, they sent a technician to inspect and he confirmed that the transfer case had failed, causing a fluid leak ignited by the hot exhaust. There are no recalls attached to my VIN and I am fighting with Jeep/Stellantis for a repair since this is a known and acknowledged issue across this model. I had the vehicle towed to the Jeep dealership on instruction of the Jeep call center and am waiting for Jeep to inform the dealer what to do. The dealer is angry to receive my damaged car and hold it. I am extremely angry with the lack of clarity from Jeep on next steps. We could have been seriously injured / died in this incident, if there was a car behind us when this failure occurred it would have hit us.

Filed Oct 5, 2026 · Transmission · OK · fire

Warning message of 4 Wheel drive overheating and disengaging. a few minutes later a loud pop occurred, and flames overtook the engine and drive train. I pulled off the road and the fire department came and put out the fire. It is a total loss. I believe that this is a safety recall but I was never notified of any repairs needed.

Filed Oct 5, 2026 · Transmission · WI

Service four-wheel-drive light came on mileage was at 83,000 miles approximately took it to the Chrysler dealer and they replaced my PTU motor. I believe this motor was recalled on an earlier years as a recall I think this year should be a recall . Also, now, September 27, 2026 I drove my vehicle /Jeep to church I parked it and it lit on fire and burned to the ground. Nothing left of it. Don’t know if it had anything to do with that PTU unit.

Filed Sep 24, 2026 · Engine · MI · fire

Engine caught fire while parked

Filed Aug 19, 2026 · Transmission · NC

While driving my 2015 Jeep Cherokee on an interstate trip, we began noticing a strong unusual odor inside the vehicle. At first, we thought we were simply driving past a paper mill or another external source of the smell. A short time later, we noticed other vehicles beginning to merge out of our lane and realized something might be wrong with our vehicle. We exited the highway and pulled over as soon as we could safely do so. We did not see any smoke or steam while the vehicle was moving. After we had pulled over and stopped, we noticed steam coming from under the hood. When we opened the hood, smoke came out and there was a strong burning smell. Because we were concerned that the vehicle was unsafe to continue driving, we did not continue the trip and the vehicle had to be towed by AAA. An independent mechanic subsequently inspected the vehicle and diagnosed a leaking Power Transfer Unit (PTU) that requires replacement. There were no warning lights, warning messages, or other dashboard alerts before the incident, during the incident, or afterward. The unusual odor was the first symptom we noticed. I later contacted Jeep/Stellantis and was informed that the required OEM replacement PTU is currently unavailable, and they could not provide an estimated availability date. As a result, there is currently no clear OEM repair timeline for the vehicle. My safety concern is that this problem developed while the vehicle was being driven at highway speeds, with no dashboard warning, and resulted in smoke/steam and a strong burning odor once the vehicle was stopped.

Filed Jul 23, 2026 · Electrical · MA

My Jeep caught on fire in the area of the power lift gate control module . A fire department report was filed.

Filed May 19, 2026 · Electrical, Steering · NY

2020 Jeep Cherokee Limited AWD, VIN [XXX] , approx. 111,355 miles. Reporting serious safety concern: repeated/worsening electrical system failure with intermittent loss of power steering assist. For nearly a year, Auto Start/Stop warning and battery warning lights have appeared. During episodes, power steering assist can stop working, especially at complete stops, making steering extremely difficult when stopped, parking, or pulling out. Battery, alternator, battery cables/connections, and belt have been replaced, but issue continues and is worsening. Recently while driving, radio shut off, dash/instrument cluster began shutting down, blower motor cycled on/off repeatedly, and windshield wipers slowed while raining. Warnings included battery/charging, Auto Start/Stop, Service Electronic Stability Control, Service Park Brake, ABS, traction control, check engine, and Blind Spot Alerts Unavailable. Vehicle vibrated/ran rough, sounded like it might stall, then revved back up. Burning smell noted after failure and possible smoke near rear after shutdown. Vehicle was towed home due to safety risk. After tow, vehicle restarted but same warnings returned within minutes and radio/dash failures repeated. Concerned this is system-wide electrical, charging, power distribution, ground, or steering assist failure that could cause loss of steering assist, visibility systems, or safety systems while driving INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 6, 2026 · 76,000 miles · NH · fire

The contact owned a 2016 Jeep Cherokee. The contact stated that twenty minutes after her husband parked and turned off the vehicle in a parking lot, the vehicle caught fire while unoccupied. There was no warning light illuminated. The contact stated that she noticed sparks coming from beneath the rear driver's side taillight before the vehicle caught fire. The fire consumed half of the vehicle, causing extensive damage. The firefighters arrived and extinguished the fire. There were police and fire department reports filed. The fire department informed the contact that the fire was caused by an electrical failure. The vehicle was towed to a collision center, but was not yet deemed totaled by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was approximately 76,000.

Filed Jan 6, 2026 · Transmission · 114,000 miles · IA

The contact owns a 2018 Jeep Cherokee. The contact received notification of the federal safety agency Campaign Number: 25V011000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that while driving at 35 MPH, there was smoke coming from underneath the hood with a burning odor. The contact pulled over to the side of the road to allow the smoke to clear. There was no warning light illuminated. The contact was able to drive to the residence. The vehicle was later towed to the dealer, where it was diagnosed that the power transfer unit had failed and needed to be replaced; however, the recall remedy part was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 114,000.

Filed Dec 10, 2025 · Engine · 64,000 miles · AA · fire

The contact owned a 2021 Jeep Cherokee. The contact stated that there was an abnormal sweet/alcohol smell in the vehicle. There were no warning lights illuminated. The vehicle was taken to an independent while in the process of performing a stress test drive. There was a popping sound from the ignition, and it stopped on the interstate. Upon opening the hood, he noticed smoke and flames, and the vehicle fully ignited and caught fire. The fire department was on the scene to extinguish the fire and determined that the cable installation or hose installation failure of equipment/leak resulted in an electrical fire. There was no reported crash, air bag deployment, or police report filed. The local dealer was contacted, who referred to the manufacturer and the federal safety agency hotline. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 64,000. The vehicle was deemed a total loss by the insurance company.