2018 Jeep Grand Cherokee fuel system problems

Filed Aug 12, 2026 · Engine, Fuel system · CA

Vehicle Information: 2018 Jeep Grand Cherokee Overland 3.0L V6 EcoDiesel 4x4Component Affected: Fuel/Propulsion System (High-Pressure Fuel Pump) Safety Incident Narrative: The vehicle previously underwent a mandatory manufacturer safety recall replacement for the Bosch CP4 High-Pressure Fuel Pump under FCA Safety Recall Z46 (the federal safety agency Campaign Number: 22V‑406). At 111,948 miles, while operating the vehicle, the engine suffered a sudden, catastrophic mechanical failure accompanied by an immediate and total loss of engine oil pressure. This caused the engine to suddenly stall and lose all propulsion while in motion, creating an immediate and severe highway safety hazard to myself and surrounding traffic.The vehicle was towed to an authorized Jeep dealership under Repair Order #5823328. The manufacturer (Stellantis) and the dealership are currently refusing to authorize diagnostic teardown labor or a mechanical review of the internal safety recall componentry to investigate an acute internal fuel-pump shaft seal leak or residual micro-particle metallic debris from the prior campaign. An internal drive-shaft seal failure on this replacement pump architecture dumps raw diesel fuel directly into the engine's internal oil crankcase, causing severe oil dilution, an immediate collapse of structural oil pressure, and catastrophic engine seizure. The manufacturer is attempting to shift 100% of the financial burden ($25,000 engine replacement cost) onto the consumer, actively obstructing an essential safety failure investigation into a federally recalled component.

Filed Jul 15, 2026 · Fuel system · UT

I own a 2018 Jeep Grand Cherokee EcoDiesel that has experienced repeated high-pressure fuel pump (HPFP) failures despite completion of the federal safety agency HPFP safety recall. After the recall was performed, my vehicle developed the exact failure described in the recall. Metal contamination was found in the fuel system, requiring replacement of the HPFP and major fuel system components. Approximately 13,000 miles later, during routine fuel filter maintenance, I suspected the failure had returned. I asked the dealership to inspect the fuel filters for metal contamination, but they declined. I then removed and cut open the filters myself and documented visible metal shavings consistent with the recall failure. This is the second occurrence of metal contamination after the recall repair. I retained the filters, saved fuel samples, and documented everything with photos and video. I provided this evidence to the dealership and Stellantis. A STAR case was opened, but the Stellantis District Manager instructed the dealership not to perform any repairs because the vehicle has no check engine light and remains operable. The recall warns that HPFP deterioration can contaminate the fuel system and cause a sudden loss of engine power, increasing the risk of a crash. It also states this failure may occur without warning lights. My concern is that Stellantis is requiring complete pump failure before authorizing repairs, despite documented evidence that the recall failure condition has returned. I still possess the contaminated filters, fuel samples, photographs, video, and service records and will provide them upon request. I respectfully request that the federal safety agency investigate whether the recall remedy adequately corrects this defect and whether Stellantis' refusal to repair a vehicle exhibiting the same safety-related failure condition is appropriate.

Filed May 14, 2026 · Engine, Fuel system · CA

On 5/72026@app 3:14pm after picking up one grandchild, and at a stop light on the way to p/u the other, the Jeep without warning just disengaged when the gas pedal was depressed, but to no avail. While frozen, the dashboard may have displayed something that was not noted in the panic to get the car moving! The internal panel was still illuminated, however the car would not move forwards although still in "Drive" with nothing having been switched, shifted or toggled except engagement of the brake to stop at the traffic light. The Jeep had to be placed in "Park", the starter button pressed, then pressed again to completely restart the vehicle. This was a potentially huge safety issue with many cars around us honking & rushing to pick up their own children, yet fortunately no one ran into us with our precious little rider!

Filed May 5, 2026 · Electrical, Engine · MA

I recently purchased a 2018 Jeep Grand Cherokee and began experiencing serious issues almost immediately after taking possession of the vehicle. The vehicle has stalled unexpectedly while driving on multiple occasions, including during active driving conditions. It also has difficulty starting and has shut off without warning. The vehicle has already undergone multiple repairs within a short period of time, including work related to the radiator, spark plugs, and ignition coil. Despite these repairs, the issues continue. This creates a significant safety concern, as the vehicle becomes inoperable without warning, especially during daily highway driving. I rely on this vehicle for transportation, and it is currently unreliable and unsafe to operate.

Filed Feb 15, 2026 · Engine, Fuel system · OH

While driving this vehicle under normal conditions, the engine developed abnormal ticking/knocking noises, loss of power, and misfire symptoms that progressively worsened. The vehicle was frequently used to transport children. Due to the nature of the failure and unpredictability of progression, continued operation posed a serious safety risk. An authorized dealer later confirmed that the engine suffered a catastrophic internal valvetrain failure involving collapsed lifters/rocker arms and severely damaged camshafts. The dealer technician explicitly stated this failure mode is “typical” for this engine design and documented progressive internal damage affecting both cylinder banks, not an isolated component. This failure mode is not sudden; it develops gradually over tens of thousands of miles and can lead to sudden engine power loss, stalling, or seizure without warning. A loss of propulsion at highway speed, during lane changes, intersections, or while transporting children creates a clear risk of crash, injury, or worse. There was no evidence of driver abuse, lack of maintenance, lubrication failure, or misuse. The dealer confirmed oil condition and service history were appropriate. The defect appears to be internal, latent, and manufacturing-related, consistent with numerous consumer complaints, technical service bulletins, and ongoing litigation involving this engine family. Had the vehicle continued to be driven, the failure could have escalated to: •Sudden loss of engine power at speed •Inability to accelerate to avoid hazards •Engine seizure causing loss of steering assist •Increased crash risk with child passengers onboard The vehicle was removed from service due to safety concerns. This defect is repeatable, predictable, and well-documented, yet not subject to recall at this time. I am reporting this to support investigation into a systemic engine defect that presents a serious safety risk to drivers and passengers.

Filed Aug 19, 2025 · Brakes, Fuel system · NC

The contact owns a 2018 Jeep Grand Cherokee. The contact received notifications of the federal safety agency Campaign Numbers: 22V406000 (Fuel System, Diesel) and 24V838000 (Service Brakes, Hydraulic); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The dealer was contacted and confirmed that parts were not yet available. The manufacturer was not made aware of the issues. The contact had not experienced a failure.

Filed Apr 17, 2025 · Engine, Fuel system · VA

Three concerns: (1) the engine light is on. mechanics cannot determine why. (2) the car has trouble starting. When I park indoors, the car doesn't start. The engine turns over several times and the RPM goes all the way up, but the car will not start until the 3rd or 4th try. mechanics cannot determine why. (3) when I pump gas, the fuel pump automatically shuts off even though the gas tank is not full. So I have to hold the pump in place and use the gas gauge to determine when the tank is full. mechanics have seen this problem in other jeeps but haven't given me a reason why.

Filed Apr 3, 2025 · Fuel system · TX

I have been experiencing slow crank issues for months now. The vehicle will have a slow crank then start. If it does not start on the first try, it will start on the second attempt. This concerns me as I've read many complaints regarding high pressure fuel pump issues on Jeep Grand Cherokees. I am concerned about my safety especially being stranded at night time. I was told I need to change the fuel pump. I called the dealership and was also told that many Jeep Grand Cherokees have been experiencing the same issue which was fixed by replacing the fuel pump. If many vehicles are experiencing the same problem, why is this not considered a recall?

Filed Nov 22, 2024 · Acceleration, Engine · 25,000 miles · NY

The contact owns a 2018 Jeep Grand Cherokee. The contact stated while driving 35 MPH, several unknown warning lights illuminated, and the vehicle started hesitating and then stalled. The vehicle was towed to an independent mechanic, and the mechanic had the vehicle towed to the dealer to be diagnosed. The contact was informed that the throttle body needed to be replaced. The throttle body wiring was replaced, and the codes were reset. The vehicle was taken back to the dealer, and it was suggested that the vehicle needed to be retested. The vehicle was repaired again. The contact stated that after retrieving the vehicle from the dealer, several unknown warning lights illuminated, and the vehicle accelerated independently while depressing the brake pedal. The contact stated that the vehicle stalled while coming to a stop. The contact made a left turn into a parking lot and the vehicle independently accelerated. The contact stopped the vehicle and had the vehicle towed back to the dealer where the vehicle was being repaired. The manufacturer was notified of the failure and a case was opened. The approximate failure mileage was 25,000.

Filed Oct 11, 2024 · Fuel system · 39,000 miles · UT

The contact owns a 2018 Jeep Grand Cherokee. The contact stated that while driving at approximately 45 MPH, she observed a noise that resembled air escaping from the passenger side of the vehicle. The vehicle was taken to a dealer where it was diagnosed that the diesel particulate matter harness and exhaust manifold needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 39,000.