2008 Jeep Patriot fuel system problems

Filed Sep 20, 2023 · Fuel system · PA

The vehicle stalls after a gas fill up. Daughter was stuck in traffic. No Power steering, brakes, etc. Started back up. very dangerous. This has happened after every fill up.

Filed Jul 19, 2023 · Engine, Fuel system · CA

Car stalls after fill up. NUMEROUS online Jeep forums have noted this issue for years. There seems to be an issue with the “vapor canister”. Recall was apparently issued for 2011 model - but not older models. It is intermittent yet consistent problem over past few months. Please note that an Engine stall leaves steering wheel LOCKED and unable to maneuver car for a period until can restart. Can leave driver on a VERY DANGEROUS situation traveling at speed !

Filed May 8, 2022 · Engine, Fuel system · IN

UNKNOWN After I fill up on gas at different stations I had the car sputter and die after filling up til the nozzle stopped itself went to go start the car the first time it happened I got maybe half a mile down the road and stopped at a light and the car died. The second time I was at another gas station and I forgot to shut the car off because it was freezing cold felt like a negative 10 I went to go leave and thought oh crap let me shut it off for a second so the gas would register faster of what I had then if I left it on. I went to go drive away then and the car wouldn’t move I thought great what could it be well I looked down and I wasn’t “on” so I restarted the car and I could tell the car started and I sat for a few and it died. I waited a few seconds and started it again and sat for a few and then was able to go about my business. The third time I filled up and didn't think anything of it because it had been awhile since it happened but I pulled out on the street and it was at a T intersection and I was coming up and to the left well when I turned I died and the light had changed to green I was barely able to make it into the turn lane from when I coasted I shut it off and turned it back on again and we were good. Well this is what happened last night I went to the gas station filled up and sat there for a second and went to start car and it died I wait a few did it again it died. I did this like 4-5 times and I wasn't far from home so I said let's just hurry up and get home. So I got it started and I was pushing the gas as little to keep it from dying and it made it about a mile down the road and acted like it was about to shut off. I made it home sat in the driveway for about 20 mins and it acted fine.

Filed Apr 27, 2021 · Engine, Fuel system · 55,000 miles · FL

Car stalls within the first minute or so of driving after filling gas tank to shutoff. When the engine dies, so does the power steering, creating a very dangerous situation. Happens consistently. Began several years ago but I lived with it by not filling tank to full. Now my son drives the car, and I am concerned that it may happen when he is driving and cause an accident. This is very dangerous. Many people have complained about it, and the federal safety agency must do something about it and hold chryslter/jeep responsible

Filed Jan 2, 2021 · Engine, Fuel system · 178,000 miles · FL

Every time I refill my tank with fuel, the first several minutes of driving the engine will hesitate and almost stall (or will stall if driving at slow speeds). While stopped in idle, engine will completely stall. Once some fuel is burned, the engine will no longer stall. This issue has been ongoing for years.

Filed Nov 20, 2020 · Fuel system · 190,000 miles · IA

Approximately 12/2018 I had to have my gas tank replaced due to a faulty rollover valve/flapper/inlet check valve located in the gas tank. I am now having the same problem with the new gas tank. The cost to repair this problem is well over $1400 and to have to do the same repair twice is unthinkable. This has to be some sort of safety issue as well, because if these valves/flappers are supposed to expel air from the system, couldn't this be harming my vehicle more and/or cause pressure to build in the tank? There was tsb 14-001-09 rev a issued. Chrysler admits this is a big problem and has recalled a bunch of jeeps, dodges, and some chrysler town & country vans. However, my make and model (08 patriot) is not covered under the extended warranty they issued for the gas tanks.

Filed Oct 8, 2020 · Engine, Fuel system · 112,000 miles · MI

When the gas tank is full the service lights come on engine stalls out about half a mile down the road. The steering wheel locks up when the engine goes out so you cant even coast over to the side of the road.

Filed Aug 6, 2020 · Fuel system · 118,000 miles · MN

After filling up gas tank to normal level, car stalled and lost controls of vehicle

Filed Jul 21, 2020 · Fuel system · 188,000 miles · OR

Filled up gas tank and car stalled at stop light shortly after. Pulled into driveway after a 5-minute drive and steering wheel locked and car had stalled.

Filed Dec 11, 2019 · Fuel system · CA

The valve inside the fuel tank broke and the jeep can no longer be filled with gas without the gas pump believing it is already full and turning off. This results in many, many attempts to put fuel into the vehicle and gas leaking out of the fuel pump down the side of the jeep and all over the ground. My mechanic was trying to find the issue and in his research found it to be a known problem but a non serviceable piece, meaning the entire fuel tank must be replaced. This is something that should not have failed and created an environmental hazard and a potential fire hazard as well.