The contact owns a 2011 Jeep Patriot. The contact stated that while driving at an undisclosed speed, the vehicle stalled. While refueling, the fuel tank failed to allow all with fuel. The contact had to restart the vehicle and add more fuel several times. There were no warning lights illuminated. The contact called the local dealer where a service appointment was scheduled. The vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic who informed the contact that the failure was due to a faulty rollover valve and the fuel tank needed to be replaced. The manufacturer was contacted but provided no assistance. The approximate failure mileage was 115,000.
2011 Jeep Patriot fuel system problems
32 complaints (10% of all complaints for this car). Typical mileage when it fails: 104,535. 2 crashes reported.
- owner complaints
- 32
- of this car's complaints
- 10%
- typical mileage
- 104,535
- crashes
- 2
- recalls
- 0
Which part fails
Owners did not name a specific part.
At what mileage
Complaints by mileage at the time of the problem.
0k-25k
25k-50k
50k-75k
75k-100k
100k-125k
125k-150k
150k-175k
175k-200k
200k+
Jeep Patriot fuel system problems in other years
Related recalls
No recalls on record for this model year.
Related investigations
Engine stall, fuel delivery failure
In a letter dated April 3, 2013, Chrysler Group LLC submitted a Defect Information Report (DIR) to the federal safety agency identifying a safety defect in the fuel delivery system in approximately 20,532 model year (MY) 2012 Jeep Patriot (11,624) and Compass (8,908) vehicles manufactured from October 18, 2011 through May 7, 2012 and equipped with certain fuel tanks produced between October 18, 2011 and January 26, 2012 (Recall 13V‑120).According to Chrysler, Jeep Patriot and Compass vehicles equipped with saddle type fuel tanks built during the affected period may experience low siphoning rate through the transfer tube from the secondary to the primary side of the fuel tank.Chrysler's investigation determined that a material change by the transfer tube supplier (TI Automotive) led to malformed tubes being shipped to the final tank assembly supplier (Kautex).The malformed transfer tubes may make the siphoning process more difficult to start and maintain under certain operating conditions.Sustained driving during this condition may deplete fuel in the primary side of the fuel tank and lead to engine stall without warning.Kautex established a 100% sort on January 26, 2012 as a countermeasure for the malformed tubes being used in production.Chrysler is able to trace fuel tank build dates by vehicle identification number and Recall 13V‑120 only includes vehicles equipped withsaddle tanks made during the affected period.Approximately 97 percent of the recalled Patriot vehicles (11,277 out of 11,624) were from October 18, 2011 through January 26, 2012.Chrysler determined that a few suspect tanks were used on vehicles produced as late as May 7, 2012 and is including any such vehicles in the recall.The Office of Defects Investigation (ODI) analyzed complaint data provided by Chrysler as well as complaints submitted to ODI from consumers to identify stalling incidents related to fuel delivery.ODI's analysis identified a total of 64 engine stall incidents related to fuel delivery, all of which involved Patriot 4x4 vehicles equipped with saddle type fuel tanks.The Patriot 4x4 vehicles account for a little over half of the subject vehicle population (59,783 vehicles).Forty-nine (49) of the incidents involved the approximately 11,277 Patriot 4x4 vehicles that were built from October 18, 2011 and January 26, 2012 and equipped with tanks from the period associated with the transfer tube material change.This equates to a complaint rate of 434.5 incidents per 100,000 vehicles sold.Fifteen (15) fuel delivery related engine stalls were identified in the remaining 48,506 Patriot 4x4 vehicles, resulting in a complaint rate of 30.9 incidents per 100,000 vehicles.The rate in the non-recalled Patriot 4x4 vehicles increases to 68.0 incidents per 100,000 vehicles if stalls with no-restart and unknown cause are added to the analysis.The Patriot front-wheel drive vehicles are equipped with single reservoir fuel tanks and are not affected by the saddle-tank fuel delivery issue.Owners of the recalled vehicles will be notified to take their vehicle to a Jeep dealer, who will replace the fuel tank transfer tube to prevent any incidents related to this issue. Chrysler will begin notifying dealers and owners in May 2013. This preliminary evaluation is closed.The ODI reports cited above can be viewed at www-odi.the federal safety agency.dot.gov/owners/Searchreference under the following identification numbers (ODI Nos.): 10481572, 10481452, 10481279, 10481254, 10481222, 10481141, 10481126, 10481110, 10501057, 10478934, 10472705, 10470121, 10468517, 10467488, 10466357, 10464745, 10464449, 10464135, 10462338, 10459383, 10421019, 10410937, 10481392.
PE12032
What 2011 Jeep Patriot owners say
Most recent owner complaints, unedited.
While driving in heavy traffic, there was a Red light and attempted to slow the vehicle. The engine started to jerk forward and the RPMs were increasing without my foot on the accelerator! My foot was on the brake! I was able to turn into a gas station to get to a safer place to park the vehicle. While attempting to park in a parking space the vehicle continued to accelerate by itself, again my foot was applied to the brake pedal. I was literally fighting to stop the vehicle and almost ran into the barrier where customers were walking. Once turning off the vehicle and restarting the engine, it was operating correctly while I’m reverse. I then shifted into drive, and the vehicle lunged forward and the engine accelerated by itself. It drove up to 45 miles per hour without my foot on the accelerator and foot resting on the brake pedal. A complete stop was a fight, as soon as there was any brake pedal release the engine lunged forward.
After filling up with gas, the vehicle sputtered, stalled and the steering locked up.
After filling up the gas tank, when I drive away, the car jerks and loses power for a minute with in a mile of leaving the gas station. Nj pumps gas for me so the tank is not overfilled. My power steering goes down for a moment as my car sputters. Then after a minute it drives great until the next time I fill up my tank. Forums have stated it is a bad charcoal cannister. Many jeep patriot owners have complained about this. It is very unsafe when this happens on the road. I fear driving my toddler now.
Every single time after putting gas, my car wont go further than 10 feet without turning off/stalling. Some times it wont turn back on and takes several tries to get it back up and running. I feel at risk for my life and those in the car with me because not only does it stall but my steering wheel locks everytime and I am unable to move or do anything. God forbid one day it stops and a car is headed in my direction I will be stuck in place. I have read online multiple people have had this issue but no one can seem to find a definitive solution. This started to happen around winter of 2019/spring 2020 and has been happening ever since. The date I recorded below is the most recent time it's occurred.
Filled gas tank and restarted Jeep. Pulled away from gas station into traffic and the jeep sputtered and died. Restarted and spit and sputtered and died again. After several tries and waiting, car started. Idled roughly for a few minutes then cleared up. No problems or indication of any problems until had to get gas again. Another incident while filling gas tank, pump continuously cut off and had to pump extremely slow to fill tank. Again, sputter and spat after starting. At times as the gas is going in it sounds like a gulping sound after I stop pumping gas. These problems happen every time have to get gas. It is dangerous and very frustrating. This has been going on way too long. I took it to the shop and the mechanic says the roll over valve inside the gas tank is stuck and I must have a new gas tank installed at $1500. I would welcome you to inspect this vehicle. There have been no warning lamps, signals, messages, or other indicator of a problem with the vehicle.
When fueling at a gas station and the vehicle is off I can only put roughly 25 cents of fuel in at a time.
When filling the fuel tank to normal full level, the vehicle will stall and run at very low ram. This only happens right after filling the tank to full and starting to accelerate at a normal rate. After doing research, this seems to be a very common issue across many jeep vehicles.
Jeep stalls after refueling. Anytime you fully fill the tank this is an issue. Was very startling the first couple of times it happened. I now expect this to happen, but for other people it could be an extreme hazard. It happens with the vehicle stationary or in motion. Subsides after second or third restart...or if you let it sit with the gas cap open for a minute or so, these seems to help.
The problem I am having is with the rollover valve which is located in the gas tank. When I put fuel in, it acts like it is full, even though the gas gauge is telling me that I have tank of gas. It will only take the gas if I put in gallon at a time. Then when I start to drive it, it wants to stall, and I have to give it the gas and then it runs. I have done research online and this is a problem in all jeeps. If I am in an accident the rollover valve could remain open instead of closing. The valve is sticking and unreliable. This valve does it every time you put gas in it.
Questions about the 2011 Jeep Patriot fuel system
Does the 2011 Jeep Patriot have fuel system problems?
Owners have filed 32 complaints about the fuel system of the 2011 Jeep Patriot, 10% of all its complaints.
At what mileage do 2011 Jeep Patriot fuel system problems start?
The typical (median) mileage in owner complaints is 104,535 miles.
Was there a recall on the 2011 Jeep Patriot fuel system?
There is no recall for this problem on this model year.
What year does the Jeep Patriot have the most fuel system problems?
The Jeep Patriot model years with the most fuel system complaints are 2012 (102 complaints), 2007 (60 complaints) and 2008 (45 complaints).
Other 2011 Jeep Patriot problems
Engine 75Suspension 55Transmission 53Body 51Airbags 43Electrical 32Seat belts 25Steering 19Acceleration 18Driver assistance 11Brakes 10Wheels 9Lights 6Tires 5Visibility 4Locks 1Seats 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2011 Jeep Patriot?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history