2001 Jeep Wrangler electrical problems

Filed Nov 3, 2022 · Electrical, Visibility · NC

There is a known problem with the electrical wiring to the climate control panel including the blower motor fan switch. The wiring attached to the assembly gets too hot and melts the blower motor fan switch. When this happens, you are unable to turn on any heat/ac/air speeds. You are not able to select any speed to turn on the air which means you can’t use it to defrost the windshield. This can lead to a poor visibility situation. I am the original owner of my 2001 TJ and I’ve had to have this problem fixed multiple times. There are several videos & discussions about this problem in Jeep forums. Chrysler should’ve recalled it years ago..

Filed Dec 20, 2017 · Airbags, Electrical · 139,000 miles · SC

Tl-contact owns a 2001 jeep wrangler--- spoke with chrysler --- chrsyler stated no recalls on vehicle---horn in vehicle does not work at all and airbag light is on... Contact was given number to jeep regarding air bag light....0 recalls associated with this VIN

Filed Aug 24, 2017 · Electrical · 117,803 miles · TX · fire

I was driving with the air conditioner on when I smelled burning plastic, then smoke came out of the air vents. I pulled over and turned off the air conditioner and got out of the vehicle. After about 15 min the smell dissipated and I continued on without the air conditioning. Later I removed the covers and found that there had been a fire in the plug that goes to the blower motor resistor

Filed Oct 18, 2016 · Electrical · PA · fire

I had a fire due to a recalled ignition switch that was never repaired, I had no idea when I bought the used jeep from the dealer. Chrysler is now denying any request to fix the parts damaged by the fire

Filed Oct 3, 2016 · Electrical · 200,000 miles · PA · fire

I left my top off of my jeep wrangler and it rained hard into the night and next morning. I heard the horn going off randomly so I ran outside and the drivers side dash and steering column were engulfed in flames. I quickly opened the hood, disconnected the battery and then put out the fire with the hose. The whole steering column and surrounding dash and wiring harness are completely melted. The incident happened while the jeep was parked in the driveway

Filed Jul 28, 2015 · Body, Electrical · 15,000 miles · NV

When sitting in my driveway with the engine running I noticed a burnt odor smell from the dash area. The air conditioner was running on high blower and on the max setting of internal air flow. The blower stopped working shortly after this happened. Upon inspection of the blower switch I found the switch had started to burn and melt at the connection for the max blower speed. I have replaced the switch twice now with the same problem,the circuit needs a relay in it to prevent the blower switch from over heating and causing the wire from burning up. At no time was the fuse blown on the circuit.

Filed Mar 21, 2015 · Electrical, Suspension · 214,506 miles · MA

I have a jeep that has a frame that is rusted in the rear trailing arms and were the transmission is held. No incident has happened yet but if this were to break on the road could cause an accident. I work for hyundai who has a recall on quite a few cars and suvs for the frame rotting out on cars as old as 2000 I also no toyota and nissan and other manufactures have recalls on frames why not jeep I realize it may be specific to salt belt areas but those other companies are fixing the problem. Also the climate control melted could have caused a fire I know this is also a common problem.

Filed Jan 11, 2015 · Electrical · 210,000 miles · MA

The HVAC system in my 2001 jeep wrangler was burnt and melted, due to lack of proper equipment. The HVAC blower fan, due to being old, caused resistance, sending too high of a current to the climate control head unit, melting and burning all wires, connectors, and the head unit itself. This could have been remedied with the existence of relays for each source of power heading into the head unit.

Filed Oct 18, 2014 · Electrical · 160,660 miles · NY

I went to start jeep thought dead battery and tried to charge battery gauges on dash jumped around finally battery enough to turn over but would not start saw warning lite for key on dash.engine would turn over but not start.took to jeep dealer replaced computer module and found corroded main power feed in engine wiring harness spliced in new wire and serial data all came back.I was returning home just pulling into driveway engine lite came on along with other lites engine stalled tried to start same problem as before.returned jeep to dealer currently waiting for answer to problem computer does not accept my key?I brought this jeep used that is why I am looking into any recalls or known problems of this nature.

Filed Sep 15, 2014 · Electrical · 16,000 miles · FL

Jeep wrangler sport, 4.0l was purchased as subsequent owner in 2003(?) in san juan, puerto rico. The problem appeared in maybe 2008 after moving to panama city (panam). An airbag warning light was observed, intermittently, when first starting. Usually a second attempt was successful. Grupo q chrysler jeep replaced the ignition switch, at my expense. I was unaware that chrysler daimler had recalled these vehicles for ignition switch problems in 2003/04, I think. My research revealed that gm/AC-delco was oeming these switches to chrysler-daimler, and maybe others. The only thing I experienced was an annoyance, but those symptoms seemed to suggest that I may have been driving with disabled air-bags, had I not noticed the light, or if had been non-functional. The question is how many people might still be driving non-gm cars with these defective switches, and why has this not been publicized?