2016 Jeep Wrangler technical service bulletins
195 technical service bulletins and manufacturer communications cover the 2016 Jeep Wrangler.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC)...
- Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC)...
- Verify "Z" part number availability
- Switch - clutch starter interlock & master cylinder assembly - clutch
- Verify Reman part number availability
- Actuator - a/c and heater
- Fuel vapor canister filter evap
- Plate
- Bow - folding top
- Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC)...
- Freedom Panel Underside Rough And Or White Coating Flaking
- Suspected Engine Coolant Leak
- Lifter
- Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair...
- Suspected engine coolant leak.
- Warranty Bulletin D-16-03
- FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage
- Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review...
- Water Quality When Mixed With Engine Coolant
- WiTECH Small Leak Verification Test (SLVT)
- Adapter
- Adapter
- Decreased Remote Start And RKE Range
- Approved Use of Weld Through Primers
- Complete wiring harness Before replacing this harness, please check for an available connector repair kit...
- If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is...
- No Start, Cannot Complete Module Replace, Proxi Or Module Proxi Configuration
- Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement...
- Wiring
- Key, blank with transmitter
- Customer Complaint May Include Engine Oil Leak Or Consumption
- Battery Tester Warranty Code Procedures, Midtronics Charger Update Process
- Gear Ratio DTC?s, Transmission Shift Concerns, Does Not Shift At Times, Shudders
- Battery Tester Warranty Code Procedures, Medtronic Update Process
- Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles
- Adapter
- Customer complaint may include engine oil leak/consumption.
- Warranty Bulletin D-18-16 Rev. B Mopar Windshield Made With Corning Gorilla Glass (Rev. B)
- (Rev. A) Power Inverter Load Ratings
- Rear Wiper Will Not Turn On After Recent Hard Top Removal
- Service 4wd Light On, Message AWD System Service Required
- Malfunction Indicator Lamp (MIL) Illumination
- Disinfectant Solution Recommended for COVID-19
- Charging System, Battery Diagnostic Tools and Warranty
- Possible Driveability Issues due to the Winter-Blend Fuel into the Warmer Season
- Hands On Steering Wheel Message In EVIC
- Speed Control Operates Intermittently
- DIPAP Requirements
- Key Programming, Security Pin Request, Pin Invalid
- DIPAP Requirements
- Air Suspension Components Star Parts Catalog has been updated to show individual service parts for the...
- Repair Parts Used For Structural Repairs
- Authentic Mopar® Glass Replacement
- Use of Salvage/Recycled Parts
- Use of Aftermarket Parts
- DOOR, Assembly (Front or Rear) For concern of flag nut not aligned to hole, use a blunt tool and lightly...
- Radio [res]
- The SKU is a Tie Rod Center Stud
- Customer Satisfaction Notification S80 Aftermarket Dana 60 Front Axle The aftermarket front axle steering...
- Console Lid If you are replacing the console lid because it does not open properly or because the button...
- Fuel Tank and Fuel Evap System Components 1) For JK MIL On ? P0441: Before replacing this part due to...
- Fuel tank and fuel evap system components.
- Fuel Tank 1) Before replacing this part due to fault code P0441, check for restriction due to plastic...
- Fuel Tank and Fuel Evap System Components Before replacing this part due to fault code P0441, check for...
- Stabilizer bar actuator water intrusion Customer comes in with flashing sway bar light and it stays...
- T-case switch If you are working on a 2016 JK and you're replacing t-case position switch, please call...
- Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter...
- Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures...
- Dimpled Driver Side Front Leather Heated Seat
- Dimpled Driver Side Front Leather Heated Seat
- Squeaking Noise Below The Front Seat While Turning and Going Over Bumps
- Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the...
- Door Hinge Assembly Side door hinge noisy
- Heated Seat Elements; Cushion and Back DEALERCONNECT HEATED ELEMENT RESISTANCE INFO OUT IS OF SPEC. Prior...
- Clockspring Replacement (X68 Warranty Extension)
- Transfer Case Input Seal Leak
- Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for...
- Restraints Remove I-Sheet from packaging
- Header Weatherstrip, Center Targa Top Seal, Right Door Mounted Weatherstrip Water leak from the Freedom...
- Restraints Information Sheet (I-Sheet) has been added to Star Parts
- Water Pump For JK Bodies ONLY: If replacing the water pump for a chirp, squeal or NVH, please contact...
- Fuel Tank Pressure Sensor and Purge Valve Canister Before replacing this part due to fault code P0441,...
- Rhb/rbz
- Hands Free Module
- Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the...
- Non-desiccated Passenger Frontal Airbag
- Hands Free Module
- Non-desiccated Passenger Frontal Airbag
- Console Lid JK ONLY
- Flash: Powertrain Diagnostic And System Enhancements
- Flash: Powertrain Diagnostic And System Enhancements
- Flash: Powertrain Diagnostic And System Enhancements
- Out Of Tolerance Door And Windshield Frame Gaps Causing Water Leaks
- MY16 RA3 & RA4
- Rhb/rbz
- Flash: Powertrain Diagnostic And System Enhancements
- Passenger Seat Is Difficult To Move
- Actuator- A/C Heater Before replacing this actuator call Matt Sasina at cell (248) 464-4982
- Intake Manifold Gasket Intake Manifold Gaskets on Pentastar Upgrade (Sales Code ERC/ERF) are reusable...
- Anti-lock brake module (ABS) 2015 and 2016 jk only; before replacing the ABS module, please call breanne...
- Anti-Lock Brake Module (ABS) 2015 and 2016 JK ONLY; Before replacing the ABS module, please call Breanne...
- Keyfob 2016 Vehicle Keyfobs with Passive Entry Keyless Go Feature
- Console lid jk only
- Pentastar oil filter adapter before replacing this part, please call any one of the following people....
- Tpm sensor or control module 2015 and 2016 jk vehicles only
- Console Lid JK ONLY
- TPM Sensor or Control Module 2015 and 2016 JK vehicles only
- Discolored Door Hinge Nuts
- 3.6L Oil Pan Drain Plug and Pan: When an oil pan leak is detected and the oil drain plug is loose please...
- Fuel Pump: JK ONLY: If a customer has a P0461 fault code (Fuel level sensor 1 performance) please take a...
- 9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH...
- Speakers: For 2016 speakers issues (all bodies), before replacing this part please contact one of the...
- Replace Fuel Tank
- RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free...
- RA3 RA4
- Adaptive Cruise Control Sensor 1) If you are replacing this part due to the cluster displaying Clean Radar...
- Panel
- Windshield Sealer 2016 JK WRANGLER wind noise or water leak coming from a void in the windshield sealer.~...
- Parts.
- 2016 JK WRANGLER wind noise or water leak coming from a void in the windshield sealer
- Wheel Speed Sensors For Jeep Wrangler (JK) only
- This bulletin involves reprogramming the Instrument Panel Cluster (IPC) with the latest
- NAG1 (5A580)
- Summary to be provided on a future date.
- Two Underhood Relays Not Capped and Unsecured
- Two Underhood Relays Not Capped and Unsecured.
- Incorrect Front Caliper Slide Pins
- Incorrect Front Caliper Slide Pins.
- Part Description: Accelerator Pedal Issue Description: Vehicle has accelerator pedal fault code
- Hands Free Feature Inoperative
- 82212076, 82203694
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Jeep Wrangler?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history