I am reporting a safety-related electrical failure involving the heated steering wheel system in a 2023 Jeep Wrangler. While driving, the heated steering wheel malfunctioned and produced smoke from the steering wheel area. This created an immediate safety concern due to the presence of smoke and the potential for electrical overheating or fire in a critical driver control component. This was not an isolated incident. The same system required a prior repair under warranty in late 2023. Despite that repair, the failure recurred in late 2025 with more severe symptoms, including overheating and damage to electrical components. The vehicle was taken out of service for repair, and the total time out of service related to this issue was approximately 115 days due to parts delays and repair time. The problem was confirmed and repaired by authorized dealerships, including replacement of the steering wheel and related electrical components. There were no meaningful warning indicators prior to the failure. The issue occurred during normal operations. The repeated failure of the same system, combined with smoke and electrical malfunction in the steering wheel, raises concern about a potential defect that could pose a safety risk to drivers and passengers.
2023 Jeep Wrangler electrical complaints
Page 3 of 8: complaints 41 to 70 of 201, newest first, as owners wrote them.
The contact owns a 2023 Jeep Wrangler. The contact received notifications of the federal safety agency Campaign Numbers: 24V111000 (Visibility), and 25V741000 (Electrical System); however, the parts to do the recall repairs were not yet available. The contact stated that while driving at various speeds with Hybrid Mode activated, the vehicle shuddered abnormally. While attempting to defrost the front windshield, the defroster took longer than normal to defrost the windshield. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 15,000.
On July 3rd I was driving on the highway, and the Jeep went into limp mode. When it ran out of the electric charge, it didn’t switch over to the gas engine and became un-drivable. I brought it to a Jeep service center and they kept it until July 7th. They were not able to figure out why that happened, but obviously it is part of the recall.
My 2023 Jeep Wrangler 4xe has been in the shop at Tameron Jeep in Daphne, AL for 37 consecutive days. After having the recall on the hybrid battery software performed, an engine light came on. When I returned it to Tameron service department, I was told the diagnostic scan showed a fault in the hybrid battery due to the recall software update. It has remained at the service department for 37 days without remedy. The service department says they are waiting on Stellantis to advise them and that they feel like Stellantis "Star Connect" tech line is requiring their service tech to perform the same repeated tests again and again to avoid approving the hybrid battery replacement. I have called Jeep customer care, opened a case twice, escalated, requested area manager, etc., and currently there is no update, plan of action, or timeline for repair. The service department said even after the battery replacement is approved (it has not been yet), it would be more than 30 days to get the new battery. So in addition to the current 37 days in service, it could potentially be another 30-60 plus days. I have been unable to get any help, any plan, any updates from Stellantis. The service department has been very understanding but they can't do anything further without approval from Stellantis. I'm still making payments and insurance on the vehicle.
On 12/06/2025, I purchased a 2023 Jeep Wrangler 4xe from a Chrysler Jeep dealership in Myrtle Beach, SC. Recall 68C (the federal safety agency 25V741000) had been published on 11/05/2025 — one month prior to my purchase. The recall involves high voltage battery cells with separator damage that may cause a vehicle fire while parked or driving. A Stop Sale order was active on this VIN at the time of sale. I raised the recall and fire risk during the purchase. The salesperson responded that "a fire could happen in any car" and continued to minimize my wife's specific safety concerns through sustained pressure until we agreed to purchase. No documentation was provided showing the recall had been remedied prior to delivery. The recall remains OPEN as of today. Third-party vehicle history data confirms Stop Sale: YES tied to 68C. We cannot charge the vehicle or use it as intended. We are unable to obtain timely service — the dealership reports months-long wait times with no loaner vehicle available. The vehicle has not been inspected or repaired for this defect. No warning lamps were present at purchase. The vehicle was available for sale and delivered to us despite the active Stop Sale designation. The safety risk is ongoing. We are parked away from structures per the federal safety agency guidance and have ceased charging the vehicle. This complaint is being filed as part of a formal legal record.
I am writing to formally report a serious issue with my 2023 Jeep Wrangler Sahara 4xe following the second recall repair (Recall 68C) related to the high-voltage battery fire risk. In November 2025, my vehicle underwent the required recall service. The repair was completed at the end of December 2025. However, immediately after the repair, I began experiencing significant performance problems in Electric Mode. Specifically: The vehicle now has severely reduced power output when operating in pure electric mode. Acceleration is noticeably weak and inconsistent compared to its performance prior to the recall repair. The gasoline engine frequently engages even when sufficient battery charge is available and Electric Mode is selected. Before the recall service, the vehicle operated normally in Electric Mode without these issues. The current condition substantially affects drivability, fuel efficiency, and the overall value of the vehicle.
See attached document. Dear Jeep Customer Care and Chrysler Capital,I am writing to formally request the termination of my current lease agreement for my 2023 Jeep Wrangler 4xe, VIN: [XXX], due to the severe safety risk posed by the federal safety agency Recall 25V-74 l, concerning the high-voltage battery fire hazard.Due to the severity of this unaddressed safety hazard, I am unable to use the vehicle for its intended purpose.This significant safety defect renders inoperable as designed and intended for use, but more importantly the vehicle is unsafe and unsuitable for normal use, as it risks fire while driving or parked as stated in your recall notice.Your own notices further indicate not charge it as designed for normal function.Furthermore, I live in a townhome surrounded by other families now put at risk and cannot safely park this vehicle outside due to the extreme fire risk, making it impractical and unsafe for my living situation.This also puts others at risk when parked in parking structures at the airport that I frequent on a weekly basis.When the same recall occurred in late 2024, I waited for four months without resolution as Jeep developed a remedy.With the new recall, I immediately contacted Jeep customer service, who informed me on December 3, 2025, that no solution is currently available and none is anticipated until late Ql 2026 (as documented during my call with Riana, case #[XXX]).I was advised to contact Chrysler Capital regarding a potential lease suspension due to the seriousness of the recall.At 11am EST, I called Chrysler Capital and spoke with Maren (ID774178). After discussing my living situation and concerns about driving an unsafe vehicle with my [XXX], Maren placed me on hold and subsequently returned to inform me he had obtained approval fornot just a lease suspension, but a full early return with no further financial liability.He recommended that I visit my local dealer promptly to process the early lease return and advised me to discontinue further payments.Before concluding our conversation, I confir
The hybrid propulsion system in my 2023 Jeep Wrangler 4xe intermittently malfunctions while driving. The “D” (Drive) indicator on the gear selector begins flashing, and the engine RPMs suddenly decrease without warning. During these events, the vehicle loses propulsion power and responsiveness. After several seconds, the vehicle may return to normal operation. This failure affects the hybrid powertrain and transmission system. The vehicle is available for inspection upon request. This condition creates a serious safety risk because the sudden loss of propulsion reduces the vehicle’s ability to accelerate or maintain speed in traffic. This is especially dangerous when merging, crossing intersections, or driving at highway speeds, as it increases the risk of collision due to loss of power and reduced vehicle control. The vehicle has been evaluated by a Jeep dealership service department. The dealership has not provided a permanent repair, and the manufacturer recall affecting the hybrid system remains open and unresolved. The recall repair has not been performed, and the hybrid malfunction continues to occur. The vehicle has been inspected by dealership personnel, but the issue remains unresolved. The dealership indicated that replacing the 12-volt battery may help, but no definitive root cause has been identified, and the hybrid system malfunction continues. There were no battery warning lights prior to or during the failure. The primary symptom is the flashing “D” indicator and sudden decrease in RPMs, followed by temporary recovery. This indicates a malfunction of the hybrid propulsion system. This unresolved hybrid system failure presents an ongoing safety hazard and loss of propulsion while driving.
After first month the trouble began. It’s a diesel. Many times this car has stalled in traffic — while stopped in traffic and while driving at high speeds. Everything just turns off and steering wheel locks up. It says to put in park. After many tries to start, it will turn back on. Has been taken to dealer many times and nothing has worked. I’ve left Jeep there for months at a time, and they still can’t fix it. This is a safety hazard. Someone might get killed by this. How can this be allowed? We need help desperately.
There is another recall 2nd one for this vehicle that now I cannot charge it . Park near other vehicles or in my garage due to fear of fire. Dealership says they are doing approx 1-2 a month and I am #59 on the list. I have not been offered a replacement vehicle. They told me I could not trade it in because it is “unsellable”.
On 1/19/2026 I had my 2023 Jeep Wrangler 4xe serviced at a Jeep dealership to have recall 68C corrected. I received a call from the dealership later that day stating a new battery was not needed, only a software update was needed. They completed the software update. On 1/31/2026 when I started my Jeep in the morning, the check engine light was on. After stopping at a red light, my Jeep felt like it was losing power. To get it to move, I had to push the pedal down to the floor, the Jeep jerked some and did drive but felt like it was going to shut down. I pulled in the parking spot. Turned the car off and tried to turn it back on. It would not start. The red battery light appeared, a symbol of a charger (accel.), and an error message stating, "service charging system". None the hybrid options were available and electronic mode showed not available. I had to have the Jeep towed to the dealership that recently completed the recall. The Jeep did start when the tow truck driver arrived, but I was worried that it would stall and leave me stranded on the beltway. On 2/2/2026 I received a call from the dealership stating the issue was with the battery and that it needed to be replace but it will take "some time" to receive. On 2/5/2026 I received a call from the dealership stating the battery should be received around 2/26/2026. I was reviewing online comments from other Jeep owners impacted by recall 68C and the issue that I experienced appears to be a common theme. Some reported it taking 4-6 weeks due to the battery not being available.
Vehicle Safety Complaint – Instrument Cluster Failure Component/System Failed: The instrument cluster (dashboard display), part number 68522503AD, malfunctioned and intermittently went completely black while the vehicle was in operation. The vehicle and component were available for inspection and were inspected and repaired at Tomball DCJR. Safety Risk: When the instrument cluster malfunctioned, I could not see vehicle speed, warning indicators, gear position, or other critical safety information. AutoNation CDJR Spring instructed me to continue driving the vehicle and rely on a mobile phone app to view speed, increasing distraction and crash risk. Stellantis later instructed me to drive the unsafe vehicle to another dealership, showing disregard for my safety. Problem Confirmation: The defect was diagnosed in April 2025 at AutoNation CDJR Spring while the vehicle was under warranty. The dealer confirmed the cluster qualified for warranty replacement but released the vehicle back to me against my wishes due to parts backorder, despite it being unsafe. Stellantis repeatedly refused to assist after I filed complaints. Inspections: In January 2026, after the condition worsened, AutoNation CDJR Spring again refused service. Tomball DCJR inspected the vehicle, confirmed internal cluster failure, test-drove it and observed the display shutting off, then removed and replaced the cluster. I was forced to pay $111.63 for installation despite the repair being warranty-related. Warnings/Symptoms Prior to Failure: The issue began as water-like droplets or spots inside the cluster glass that could not be wiped off, reducing visibility of safety information. The spots increased over time, visual clarity worsened, and the display eventually went completely black while driving. Summary: Jeep/Stellantis and AutoNation CDJR Spring failed to repair a known, worsening safety defect under warranty and instructed me to continue operating an unsafe vehicle.
Shutting off when I make stops have to put in park start over
I am submitting this complaint regarding a confirmed safety-related defect and manufacturer nonresponse involving my 2023 Jeep Wrangler Willys 4xe, VIN [XXX] . The failed component is the high-voltage hybrid battery system. The vehicle and battery pack are currently located at an authorized Jeep dealership and are available for inspection. The vehicle was delivered to the dealership on December 29, 2025 for recall-related service. On December 30, 2025, the dealership confirmed a high-voltage battery failure. A STAR case was opened and escalated to Stellantis engineering. The vehicle was immediately removed from service and has remained unusable since that date. Prior to removal from service, the vehicle experienced repeated loss of propulsion, Electric Mode Temporarily Unavailable messages, and driveline warnings during normal operation. These symptoms were reported over multiple service visits and documented by video. The vehicle was repeatedly returned to service with repair notes stating “could not replicate” and assurances that it was safe to operate, park indoors, and charge. Those assurances were later contradicted by the confirmed battery failure and recall-related safety restrictions, exposing my family and home to avoidable safety risk. The vehicle is subject to Recall Campaign 68C. Despite confirmation of a safety-related battery failure, Stellantis has not provided a written remediation plan, assigned a decision owner, or communicated a resolution timeline. The dealership has confirmed that further action is blocked pending manufacturer authorization. Stellantis initiated corporate contact by phone on January 27 and January 29, 2026. I responded in writing and by voicemail requesting written follow-up and confirmation of ownership. Stellantis did not respond in writing and did not return my voicemail. I am concerned that a like-for-like high-voltage battery replacement does not adequately remedy the safety defect or restore confidence in INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATIO
The contact owns a 2023 Jeep Wrangler. The contact received notification of the federal safety agency Campaign Number: 25V741000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the check engine warning light was intermittently illuminated, and the vehicle jerked abnormally while driving. The vehicle was taken to the dealer for the recall repair, and the contact was informed that a diagnostic test was initiated. The contact was concerned that the dealer was trying to charge a fee and advised the dealer to start with the recall repair, which was free of charge. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 47,500.
OFFICIAL REPORT: UNJUSTIFIED DENIAL OF SAFETY REMEDY & DATA INCONSISTENCY - VIN: 1C4JJXN6XPW623043 I am filing this official complaint regarding a significant barrier to resolving Safety Recall 68C (Battery Fire Risk) and Recall 78C on my 2023 Jeep Wrangler 4xe. 1. DEBUNKING MANUFACTURER CLAIMS: Stellantis Middle East (Ref: FA-25274) has declined to perform the remedy, claiming authorized dealers in my region lack the necessary equipment. This is FACTUALLY INCORRECT. The manufacturer's own portal (jeep.com) confirms that Recall 04B (HCP Software Update) was successfully REPAIRED on this VIN by the local authorized dealer (Harlem Cars). 2. DISAPPEARING SAFETY RECORDS: I possess a prior screenshot from the official portal confirming that Recall 95B (High Voltage Battery) was also successfully REPAIRED by the same dealer. However, this record has recently DISAPPEARED from the active recall list on the manufacturer's website. This removal of a safety record, combined with the current denial of service, raises serious concerns about data integrity and safety compliance. 3. PROVEN TECHNICAL CAPABILITY: The successful completion of Recall 95B and 04B-both involving high-voltage systems and software-proves the dealer is fully equipped. Furthermore, Mopar Session ID: b27c4acf-bcff-4dbc-99ac-aba6477d31b1 confirms active, real-time communication between the dealer's WiTECH 2.0 tools and U.S. servers. 4. REQUEST: I request the federal safety agency to intervene and compel Stellantis to provide the necessary software permissions to the local dealer to resolve the 68C fire hazard and the IDCM replacement immediately.
The contact owns a 2023 Jeep Wrangler. The contact received notification of the federal safety agency Campaign Number: 25V741000 (Electrical System). The contact called the dealer several times and was advised that manufacturer would notify vehicle owners by mail when the remedy was available. The contact had received two recalls for the main battery within a 2-year period. The contact attempted to contact the manufacturer but was unsuccessful. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.
The contact owns a 2023 Jeep Wrangler. The contact stated that upon pressing the Push to Start button to start the vehicle, the vehicle failed to start. The vehicle was towed to the dealer, where the battery was replaced; however, the failure recurred approximately 3 months later. The contact stated that the vehicle failed to start; however, the interior lights, the exterior lights, the windshield wipers, and other electrical functions were engaged unintendedly. The gear shifter was locked in park(P). The contact was unable to turn off the vehicle or to lock the vehicle manually or with the key fob. The contact noticed an abnormal relay sound coming from underneath the hood. The contact stated that the failure persisted for 13 hours, from morning to evening, until both batteries were completely drained. The vehicle was towed to Peach Chrysler Dodge Jeep Ram (528 South Blvd, Brewton, AL 36426) to be diagnosed and repaired, but the diagnostic information was unavailable. The manufacturer was notified of the failure but declined to cover the cost of the repair under the warranty. A case was filed. The vehicle was not repaired. The failure mileage was approximately 25,000.
We have had this recall for over a year and now the dealer is saying that the vehicle can't be driven and there is no timeline for a resolution. We are still required to pay our lease on the vehicle and the Jeep is not able to be driven. We are getting no help from the dealer we purchased it from or Jeep itself.
Two months ago the vehicle decided to not work at all. Couldn’t turn it on couldn’t move it. Had to have it towed where they kept it for 3 weeks and said it was main battery and replaced it. Fast forward to yesterday 12/29 and the engine light came on again. Waiting for dealership to contact when they’ll have loaner vehicle. But this is the second time in 2 months the engine light has come on. We bought the vehicle in September a month later in the shop. Now again going back to the shop. This vehicle has UNDER 30k miles and I’m not a a very happy customer right now.
The high-voltage battery system on my Jeep Wrangler 4xe malfunctioned and is subject to Recall 25V‑741 (68C). The vehicle has been under safety recall for battery fire risk for months, with instructions to park outside and avoid charging due to fire hazard. On December 29, the recall remedy failed and the vehicle was rendered completely undrivable (“bricked”) at the dealership. I was informed that hybrid battery components/repair parts are not available and there is currently no way to return the vehicle to a safe, operable condition. The vehicle cannot be moved or driven and remains stored outside. This defect creates a direct safety risk to me and others. I am unable to charge or operate the vehicle normally, and I have been advised by the dealer that the recall repair cannot be performed because there are no available batteries or parts. This leaves me without transportation and continues the safety risk identified by the federal safety agency, with no practical remedy or timeline. The problem has been confirmed by a Jeep dealer, and I have written documentation showing the vehicle is non-drivable due to the recall condition. I have also attempted resolution with Stellantis/Chrysler Capital without success. I request the federal safety agency investigate the lack of remedy availability and failures related to Recall 25V‑741/68C for affected owners whose vehicles are now immobilized.
This is the third time my vehicle has been recalled for battery issues. Twice it has been noted that I should not drive, charge, park my vehicle in my garage, or park it near any building or person because of vehicle fire risk. In both 2023 and 2024 they performed a software update and yet this issue still persist. In 2024, since they didn't have a fix for the problem they said we should not drive our vehicle and I was without a vehicle for 2 months. Now in 2025 they are recalling for the same fire issue for the third time. Again, I am advised not to drive, not to charge, not to park in my garage, and to keep the vehicle away from people and buildings. I have again been without a vehicle for almost a month. I spoke to the dealer this morning and again they have a software update as a fix. I asked to have my battery replaced since the two previous software updates did not fix the issue. They said they were only authorized to do the software update and Mopar would need to authorize a battery replacement. Spoke to Mopar and they say they will do the software update and only replace the battery if needed. I do not find this acceptable. I do not feel that my car is safe to drive especially with my elderly parents, children, or pets inside and yet Mopar will not authorize the replacement of my battery. I feel that after two software updates that did not fix the issue and continued vehicle fires that a battery update should be mandated, not another software update. I now have a care I don't feel safe to drive. Florida Attorney General's Office Lemon Law Hotline suggested I report this issue here.
A 2nd recall has been issued for the Hybrid Battery system and once again Jeep has no remedy available. My safety is at risk to due to the possibility of a car fire. I am also unable to use the car as intended due to safety concerns. Jeep needs to be held accountable for selling a very expensive vehicle that not only does not work properly but could catch on fire. It is unacceptable for owners to be left in limbo due to the negligence shown by Jeep. If they cannot sell a car that operates safely then they should be made to reimburse the owners.
After pressing the start/stop button to start the vehicle, it immediately began making a loud and unusual noise. Recognizing that this was not a normal sound, I pressed the start/stop button again in an attempt to turn the vehicle off. However, the vehicle did not disengage and would not shut off as expected. The noise continued and became louder, and smoke began coming from the sides of the vehicle and from underneath. When the hood was opened, there was very thick white smoke coming from the engine compartment along with a strong burning smell. The smoke was too thick to determine whether there were any visible flames. After a short period of time, the engine finally disengaged on its own, but the smoke continued for a period of time after the vehicle shut off. The exact cause of the shutdown is unknown. We did not attempt to restart the vehicle. After the incident, there was visible melted plastic material and residue on the concrete beneath the vehicle, consistent with something overheating or melting in the engine compartment. The vehicle was not driven after this incident and was towed to the nearest dealership for inspection, where it remains pending further evaluation.
While driving at about 55 mph my Wrangler shut down and dash read to put car in park to calibrate battery. I had to bring vehicle to side of road and try to restart. It did restart. I had a recall addressed at Marc Motors Sanford Maine service dept back in April 18, 2025. For recall for high voltage. Not sure why recall is showing incomplete? I am very scared to drive this car. I called the dealership in which directed me to call Jeep customer service. No one could help me. I was told I had to pay for a rental. I do not have such funds. In the mean time I am forced to drive an unsafe vehicle that shuts off anytime while driving. I'm leasing this vehicle from Stellantis and still have no help or support. I'm afraid to drive this car. I have no other means of transportation. I need to be able to transport to my job. I was told by dealership and Jeep customer service that there is no solution to fix such recall. Not until the first quarter of 2026. Please, I need a solution Thank You [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2023 Jeep Wrangler. The contact received notification of the federal safety agency Campaign Number: 25V741000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
I am filing this complaint regarding the serious safety hazard associated with the fire-risk recall on my 2023 Jeep Wrangler 4xe. The official manufacturer recall letter states: “The high-voltage battery may become damaged under normal operation which could lead to a vehicle fire.” The recall instructions also direct me to: Fully discharge the high-voltage battery Not charge the vehicle Park the vehicle away from all structures because of the fire risk This indicates that the vehicle may spontaneously catch fire even when driven or stored as intended. I currently cannot safely store or use this vehicle at my residence. I am a 100% permanently and totally disabled Marine Corps veteran with PTSD, and this fire hazard and the required parking instructions significantly worsen my medical condition. There is no available remedy or repair at this time. I am requesting that the federal safety agency document this hazard, investigate Stellantis’ handling of this recall, and ensure owner protection given the severity of the fire risk and lack of resolution.
This vehicle has a serious recall (the car can start itself on fire) and there is no fix. The value of the car tanked, and nobody wants the vehicle. I dont feel safe in the vehicle, but I am stuck in it due to unfixable recall and dealerships being unwilling to trade for it.
The contact leased a 2023 Jeep Wrangler. The contact stated that the engine overheated on several occasions while driving approximately 25-50 MPH. The driver was able to pull over safely. The temperature gauge warning light was displayed. The message “Engine Overheated – Pull Over” was displayed. The contact received notification of the federal safety agency Campaign Number: 25V741000 (Electrical System). The vehicle was taken to the local dealer, where the engine was replaced under warranty. The vehicle was repaired, but the failure recurred. The recall was not repaired because parts were not available. The manufacturer was contacted, but no assistance was provided. The approximate failure mileage was 22,357.
Asking for lease relief so I can turn in the vehicle and get one that doesn't run the risk of catching on fire and can be used as intended.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2023 Jeep Wrangler?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history