2023 Kia EV6 engine problems

Filed Sep 20, 2026 · Electrical, Engine · MO

The ICCU on the car died in the middle of the street, car would not shift out of park. Car completely died after a few minutes.

Filed May 14, 2026 · Electrical, Engine · CA

Iccu failure with Kia ev6. Unreal that this car has not had a recall yet. It is totally unacceptable that this car can at any time fail. Car will not start and shut down while I was driving. Luckily I was beginning to park when it happened

Filed Apr 19, 2026 · Electrical, Engine · GA

*ICCU assembly and ICCU fuse fault (a kia recall SC327( the federal safety agency ID: 24V867000) for ICCU was performed months early but does't help AND iccu crash) *yes - cars stop workind in the midle of nower at 317 mile away from home with 5 persons in) *yes ( kia already performed recall SC327 for our car but doest help and the ICCU crash) *yes *yes-vehicle broke down while driving.Had to be towed to closest Kia dealer(the incidend hapened 317 miles away from our home Dacula GA 30019)

Filed Mar 3, 2026 · Engine, Fuel system · MA

On April 24, 2025, I plugged my Kia EV6 into my 48-amp hardwired ChargePoint HomeFlex at 7:26 PM. Around 10:30 PM I heard a noise outside but did not investigate. At 12:25 AM I noticed I had not received a “charging complete” notification. The Kia Connect app showed the vehicle at 74% and no longer charging. The ChargePoint app was unresponsive.\n\nThe next morning I found the charger’s 60-amp breaker had tripped. After resetting the breaker and rebooting the charger, the EV6 would not start charging and displayed no “Charging started” or “Charging unsuccessful” message.\n\nI then attempted to charge using a portable Tesla Level 1 charger on a 120V GFCI outlet. The EV6 briefly announced “Charging started,” but the dash showed no charging data. The outlet’s GFCI breaker tripped. After resetting, the breaker immediately tripped again when reconnecting the vehicle.\n\nI attempted to drive to a nearby DC fast charger. Upon shifting into drive, the vehicle displayed “Check electric vehicle system” and entered power-limited mode (would not exceed 20 MPH). I returned home. While backing into my driveway, the vehicle triggered a red alert with “Stop vehicle and check power supply.”\n\nThe vehicle was towed to a Kia dealership. They diagnosed a failed ICCU (Integrated Charging Control Unit) and high-voltage fuse. The ICCU recall issue is known for this model. Repairs took over two weeks due to parts delays. The ICCU and high-voltage fuse were replaced.\n\nThe ICCU failure also damaged my home ChargePoint charger, which required replacement under warranty

Filed Feb 25, 2026 · Electrical, Engine · NC

On April 24, 2025, I plugged my Kia EV6 into my 48-amp hardwired ChargePoint HomeFlex at 7:26 PM. Around 10:30 PM I heard a noise outside but did not investigate. At 12:25 AM I noticed I had not received a “charging complete” notification. The Kia Connect app showed the vehicle at 74% and no longer charging. The ChargePoint app was unresponsive. The next morning I found the charger’s 60-amp breaker had tripped. After resetting the breaker and rebooting the charger, the EV6 would not start charging and displayed no “Charging started” or “Charging unsuccessful” message. I then attempted to charge using a portable Tesla Level 1 charger on a 120V GFCI outlet. The EV6 briefly announced “Charging started,” but the dash showed no charging data. The outlet’s GFCI breaker tripped. After resetting, the breaker immediately tripped again when reconnecting the vehicle. I attempted to drive to a nearby DC fast charger. Upon shifting into drive, the vehicle displayed “Check electric vehicle system” and entered power-limited mode (would not exceed 20 MPH). I returned home. While backing into my driveway, the vehicle triggered a red alert with “Stop vehicle and check power supply.” The vehicle was towed to a Kia dealership. They diagnosed a failed ICCU (Integrated Charging Control Unit) and high-voltage fuse. The ICCU recall issue is known for this model. Repairs took over two weeks due to parts delays. The ICCU and high-voltage fuse were replaced. The ICCU failure also damaged my home ChargePoint charger, which required replacement under warranty.

Filed Dec 27, 2025 · Engine, Fuel system · CT

I am submitting this as a supplemental statement to my existing the federal safety agency safety complaint regarding my electric vehicle, KIA EV6, 2023 model. Since my original filing, the vehicle has now experienced loss of power / loss of propulsion a total of three times. These incidents occur without warning, are unpredictable, and render the vehicle unsafe to operate. The vehicle can suddenly lose motive power, creating a serious risk of collision, particularly in traffic or at speed. The manufacturer and authorized dealership have been unable to identify the root cause or permanently repair the defect. Dealer documentation reflects that the issue “cannot be replicated,” and no corrective action beyond temporary battery charging or system reset has been performed. No explanation has been provided as to why the power loss occurred or how it will be prevented from recurring. Because the defect is intermittent and safety-critical, I no longer feel safe driving this vehicle and have stopped operating it entirely. A reasonable consumer would consider repeated, unexplained loss of propulsion to present an unreasonable risk to safety. I am submitting this update so the federal safety agency is aware that: The defect is recurrent (three incidents) The condition remains unresolved The vehicle is unsafe for continued use I respectfully request that the federal safety agency review this matter for potential investigation, as loss of propulsion in an electric vehicle poses a serious safety hazard to the driver and others on the road. Thank you for your attention to this safety concern. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Dec 15, 2025 · Electrical, Engine · OH

First year of ownership rear engine needed to be replaced. The car literally stopped where I was on the road and had to be towed to dealer. It took a month to get the motor replaced. After that, my car stopped while I was leaving my house driving it out of my driveway. There were red warining lights and sounds and then it just suddenly died seconds later. It had to be towed to the dealer. They said it was fixed and that the 12v battery wasnt being charged. Then I was leaving church when my car died on me again. Same issue. Now, the third time in this vehicles 2 years of life, my car died while I was on the highway driving to work in the morning in the passing lane during rush hour. The dash went red and waring lights and sounds with a message get to safety quick check electrical system and it only gave me a few seconds the car suddenly just stopped running and I was coasting on the highway to try to get to safety. I was going 70mph in the passing lane during rush hour, I could not steer to the left to coast off the road because on my left it was just a ditch no side road to stop on, I saw in the right lane a car that was a length or so behind so I cut my wheel straight across the right lane where I coasted to a complete dead stop barely making it to the side of the road. The side of this highway was barely the width of my car so traffic flying next to me was just inches away from my drivers side door.... I called roadside assistance and had it towed to the dealer. They then told me about the recall - which I had already had it into the dealer to fix the last time it was there for this same issue. The car is 2 years old and so far I have had it stop dead in its tracks on me 4 times! I have such stress and anxiety about continuing driving this vehicle as it is completely unsafe! I almost died last week when this happened. My safety and others on the highway that day were at risk. This could have been catastrophic.

Filed Apr 7, 2025 · Electrical, Engine · TX

ICCU failure. Car was dropped off with Kia and the (second) recall they claimed to have performed did not fix the 12-v battery charging system error. They ordered in a new part, which was on national backorder and they provided no ETA. I had to purchase a replacement vehicle after 30 days of them having the vehicle without making the repair, providing an update, or having given me a loaner. Received message it was fixed after 37 days, but no information whether it is with a new part. Subreddit for the EV6 shows this is a widespread issue that has not been permanently resolved. When the ICCU fails, you are limited to 25mph "limp mode" and will lose ability to move car if 12V battery dies.

Filed Mar 26, 2025 · Engine, Transmission · CA

On January 23 2025, while driving on the highway, the car lost power an had limited control. The car was towed to a dealer and it was determined that the ICCU failed. The car was at the dealer three weeks earlier for a recall related to the ICCU (ICCU (SC273A VCU SW LOGIC UPGRADE (VSC) • SC273A and ICCU INSPECTION/REPLACEMENT • SC302 ). Obviously, the recalls did not prevent the ICCU failure.

Filed Jan 14, 2025 · Engine · NC

I received recall 24V867 from Kia dated 12/13/2024. The dealer alternately claims no knowledge of this recall, scheduled a service appointment to complete it, an today again claims no knowledge of the recall. Union Kia has put it on me to contact Kia America - that is not my job to correct their internal problems. Please advise. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)