2023 Kia EV6: won't start

Filed May 14, 2026 · Electrical, Engine · CA

Iccu failure with Kia ev6. Unreal that this car has not had a recall yet. It is totally unacceptable that this car can at any time fail. Car will not start and shut down while I was driving. Luckily I was beginning to park when it happened

Filed Mar 3, 2026 · Engine, Fuel system · MA

On April 24, 2025, I plugged my Kia EV6 into my 48-amp hardwired ChargePoint HomeFlex at 7:26 PM. Around 10:30 PM I heard a noise outside but did not investigate. At 12:25 AM I noticed I had not received a “charging complete” notification. The Kia Connect app showed the vehicle at 74% and no longer charging. The ChargePoint app was unresponsive.\n\nThe next morning I found the charger’s 60-amp breaker had tripped. After resetting the breaker and rebooting the charger, the EV6 would not start charging and displayed no “Charging started” or “Charging unsuccessful” message.\n\nI then attempted to charge using a portable Tesla Level 1 charger on a 120V GFCI outlet. The EV6 briefly announced “Charging started,” but the dash showed no charging data. The outlet’s GFCI breaker tripped. After resetting, the breaker immediately tripped again when reconnecting the vehicle.\n\nI attempted to drive to a nearby DC fast charger. Upon shifting into drive, the vehicle displayed “Check electric vehicle system” and entered power-limited mode (would not exceed 20 MPH). I returned home. While backing into my driveway, the vehicle triggered a red alert with “Stop vehicle and check power supply.”\n\nThe vehicle was towed to a Kia dealership. They diagnosed a failed ICCU (Integrated Charging Control Unit) and high-voltage fuse. The ICCU recall issue is known for this model. Repairs took over two weeks due to parts delays. The ICCU and high-voltage fuse were replaced.\n\nThe ICCU failure also damaged my home ChargePoint charger, which required replacement under warranty

Filed Feb 28, 2026 · Electrical · MD

While charging my vehicle at a level 2 charging station, my vehicle ceased charging. I received no other warnings or symptoms prior to my vehicle ceasing to charge. Upon being alerted by the Kia Access app that the charging stopped, I went to check my vehicle and none of my doors would unlock in response to the buttons on my keys. I had to manually unlock my driver side door in order to enter my vehicle. I attempted to start my vehicle and unplug/re-plug in the charger, but my vehicle would not start or charge. Using a portable jump starter, I was able to jump start my vehicle and begin charging again. However, after approximately 5 minutes of charging, my vehicle stopped charging and once again would not start. At that point, I called for my vehicle to be towed to a Kia Service Center. The Kia Service Center was able to reproduce the problem of my vehicle not starting or charging and informed me that there was an internal short circuit caused by a bad Integrated Charging Control Unit (ICCU). The bad ICCU shorted my ICCU fuse, resulting in the draining of my 12-volt battery. The ICCU and fuse were replaced at no cost to me. Although my vehicle is available for inspection upon request, the parts that malfunctioned have been replaced with new, functioning parts. My safety or the safety of others were not at risk in this situation, but I was fortunate that my 12-volt battery died while parked and charging, not while I was driving, which could have caused an accident.

Filed Feb 25, 2026 · Electrical, Engine · NC

On April 24, 2025, I plugged my Kia EV6 into my 48-amp hardwired ChargePoint HomeFlex at 7:26 PM. Around 10:30 PM I heard a noise outside but did not investigate. At 12:25 AM I noticed I had not received a “charging complete” notification. The Kia Connect app showed the vehicle at 74% and no longer charging. The ChargePoint app was unresponsive. The next morning I found the charger’s 60-amp breaker had tripped. After resetting the breaker and rebooting the charger, the EV6 would not start charging and displayed no “Charging started” or “Charging unsuccessful” message. I then attempted to charge using a portable Tesla Level 1 charger on a 120V GFCI outlet. The EV6 briefly announced “Charging started,” but the dash showed no charging data. The outlet’s GFCI breaker tripped. After resetting, the breaker immediately tripped again when reconnecting the vehicle. I attempted to drive to a nearby DC fast charger. Upon shifting into drive, the vehicle displayed “Check electric vehicle system” and entered power-limited mode (would not exceed 20 MPH). I returned home. While backing into my driveway, the vehicle triggered a red alert with “Stop vehicle and check power supply.” The vehicle was towed to a Kia dealership. They diagnosed a failed ICCU (Integrated Charging Control Unit) and high-voltage fuse. The ICCU recall issue is known for this model. Repairs took over two weeks due to parts delays. The ICCU and high-voltage fuse were replaced. The ICCU failure also damaged my home ChargePoint charger, which required replacement under warranty.

Filed Dec 21, 2025 · Electrical, Fuel system · CT

The vehicle experienced a total power failure resulting in complete inoperability (no start, no unlock, no electrical response). This is the second occurrence within approximately five weeks. The most recent incident occurred after the vehicle was fully charged and driven the day prior. There were no warning lights or messages before the failure. The vehicle was previously inspected by an authorized dealer and a manufacturer service campaign related to the charging/low-voltage system was performed, after which the problem recurred. This condition can strand the driver without warning and poses a safety concern.

Filed May 20, 2025 · Electrical, Transmission · CA

The ICCU in my Kia EV6 failed while driving. Thankfully I was not involved in a crash, but my speed was capped at 30 MPH, crawled back home, where the vehicle wouldn't start. I had to get it towed to the service center. All of this besides all recalls and software updates being addressed. There were multiple warning lights that went off during my drive: "Stop vehicle and check power supply" "Check electric vehicle system"

Filed May 1, 2024 · Electrical, Engine · TX

On [XXX], I went to charge the car at the Katy Mills location in Katy Texas. After fully charging the car, I went to visit my sister's house to visit. When I returned to the car it had completely shut down. I would not start and none of the electric components worked. I had to have the car towed to Westside Kia, who offered no assistance with a loaner car. I called three days later and was informed by Sabestian that the ICCU had blown out and the part is on National back order. There are three people in my home who are disabled and two young children who has to be driven to school. Upon further research about this ICCU unit, there is a total of 48,323 Affected Units and Kia Corporate has offered no assistance in buying this car back although it is still under the manufacturer warranty. If anyone can assist me with information on how to best handle this situation, I would highly appreciate it. So far I have paid over 2,000 in car rental fees, in lieu of my medical situation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 2, 2024 · Electrical · WA

Car was in garage and tried to start it. Would not start, although the dash lit up briefly and it showed the main EV battery was at 49%. Message then appeared on dash stating that 12 volt battery was discharged. Car then went completely dead electrically. No electrical power of any kind. Had car towed to KIA dealership and they have so far not been able to fix it. It is under warranty. There is a Kia recall, SC302, which seems to fit the problem with my car, but my specific VIN number is not on the recall list. The dealership ran diagnostics and said 12volt battery passed their tests. I suspect maybe a ICCU problem and that my car should be on the recall list, but is not.

Filed Mar 13, 2024 · Electrical · CA

Issues with 12v battery dying with only 8,000 miles on vehicle. Knowing Kia requests an all day testing of the battery prior to replacing the 12v, I replaced it with a higher quality one. My car still did not start not long after that. Lots of folks online with similar issue and feels like Kia needs to do a recall with a known good fix. Blame put on 3rd party apps when it’s a design flaw.