2024 Kia EV6 transmission problems

Filed Oct 15, 2026 · Electrical, Transmission · CA

Something with the electrical system in this electric vehicle was not functioning properly as the car would go into "turtle mode" as the service department called it. 45 mph then dropping to 30 mph before reaching the dealership. My safety was at risk because driving on the highway could have had someone rear end up by slowing down. The dealership has been inspected. Waiting at the dealership since Monday Oct 12, 2026. I don't think my vehicle has been inspected by the manufacturer, police, or insurance representatives. Vehicle would warn to check the battery system at car start. Upon driving the car will notify and show a battery red light on the dashboard. The notification will say to stop and check the electrical system.

Filed Apr 27, 2026 · Electrical, Fuel system · OH

2024 Kia EV6 leased January 2025. Vehicle is subject to the federal safety agency Recall 24V‑867 / Kia campaign SC327 for the Integrated Charging Control Unit (ICCU). The recall remedy was performed at an authorized Kia dealer in July 2025 (software / operational logic update). The defect was not cured. Three months after the recall remedy was performed, the vehicle suffered complete loss of electrical power and would not move. It was towed to the Kia dealer. The dealer's own diagnostic recorded code P1A9096 — the exact diagnostic code Kia's recall instructs technicians to check for — and replaced the ICCU and high-voltage fuse. This is the recall-defined failure occurring AFTER the recall remedy was applied. Approximately three months later, the vehicle again suffered total loss of power and would not start in cold weather. It was towed in. The dealer replaced only the 12-volt battery and did not address the ICCU, despite the documented prior ICCU failure on this VIN. The 12V battery failure is a known downstream symptom of ICCU failure on this platform. Approximately one month after that, the vehicle returned for charging system failure ("vehicle charges briefly then stops") and a "check electrical/hybrid system" warning that appeared while driving. Diagnosed as charging port failure. Vehicle was out of service approximately 27 consecutive days. Total cumulative days out of service across four visits: approximately 35-40. Two safety-related stranding incidents resulted from these failures. Both occurred in winter conditions in Pennsylvania. In the first, the driver was stranded in a parking lot at night during a snowstorm in sub-zero conditions; three tow trucks were dispatched before a flatbed could recover the vehicle because the EV could not be towed conventionally with no power. In the second, the vehicle died in a school parking lot during a snowstorm; the first dispatched tow truck could not recover an EV with no power, and the driver had to walk multiple miles home in freezing

Filed Apr 26, 2026 · Transmission · MO

Vehicle display showed a message stating 12 volt battery was low and to pull over immediately, the car the died in a parking lot. I called KIA roadside service and they connected a battery pack to the 12 volt battery and got the car started. This could have been a serious problem if I was on travelling on a public street or highway and suddenly lost power.

Filed Apr 22, 2026 · Electrical, Engine · NJ

The vehicle’s ICCU unit stopped working out of the blue. This happened on a busy intersection and the car came to a sudden and violent halt. Luckily we were not involved in an accident. It’s a very well known issue with these vehicles and it’s really criminal that Kia has done nothing to fix it. They just change the ICCU unit and then it happens again.

Filed Mar 4, 2026 · Electrical, Fuel system · FL

I purchased this vehicle just over a year ago as a CPO model with only 8,000 miles on it. It now has just over 23,000 miles. In this short time of ownership, it has been back to the dealership 3 separate times for serious EV system issues. The first visit involved a software update intended to correct a 12-volt charging issue that could prevent the vehicle from charging and potentially cause ICCU failure. Shortly after that update, the 12-volt battery failed, despite being 30 miles from home, the vehicle displayed a “Check Electrical System Failure” warning. I was able to limp-mode the car back to the dealership. I am now being told that the main EV battery has failed and must be replaced, possibly also the ICCU. The dealership cannot provide a firm timeline for repairs; parts availability could mean anywhere from 2 weeks to 4 months without the vehicle. This pattern of failures raises serious concerns about the reliability and safety of the EV6. Repeated electrical system issues create a very real risk of being stranded unexpectedly, potentially in unsafe situations such as on the side of a highway. To date, I have already lost four days of use due to service repairs, and I now face being without the vehicle for an extended and uncertain period. While a loaner vehicle is being provided, I will incur fuel expenses at a time of rising gas prices, undermining the financial rationale for purchasing an EV. Meanwhile, I continue making payments on a vehicle I cannot use, which is depreciating in value. I understand that new technology carries some risk. However, despite prior updates and even a model refresh, the ICCU issue appears unresolved, and Kia does not seem to have a clear root cause identified. For a vehicle marketed on innovation and dependability, this experience has indicated otherwise.

Filed Mar 3, 2026 · Electrical, Transmission · MA

The driver (my wife) was operating the Kia EV6 (with approximately 10,000 miles) when the vehicle suddenly experienced a severe loss of motive power. While driving, a warning message appeared on the dashboard indicating an issue with the power supply. Immediately after, the vehicle forced itself into "turtle mode," severely restricting the maximum speed to 20 mph and refusing to accelerate further. This sudden, unexpected deceleration on an active roadway put the driver at a significant risk of a rear-end collision. The driver managed to slowly navigate the vehicle back to our residence at a maximum speed of 20 mph, which was extremely hazardous. Shortly after safely parking at the residence, the vehicle experienced a complete electrical failure. It would no longer start, could not be shifted into neutral, and ultimately had to be dragged onto a flatbed tow truck by roadside assistance because the wheels were locked. The vehicle was towed to an authorized Kia dealership, where it is currently undergoing diagnosis and inspection for what is heavily suspected to be a total failure of the Integrated Charging Control Unit (ICCU) and 12-volt battery system. The vehicle and the failed components are currently at the dealership and are available for inspection upon request. Note: This catastrophic power loss occurred just weeks after the vehicle was in the shop for nearly a month to have its entire high-voltage battery pack replaced due to severe range degradation, marking the second major electrical system failure on this vehicle.

Filed Feb 18, 2026 · Electrical, Transmission · MI

The ICCU failed while I was driving my car on a 50 mph road. Check electrical system warning lights appeared. Maximum speed was reduced to 19mph and my car became a road hazard for other cars on the road. I managed to pull off the road once I found a safe spot. After visiting the Kia dealership, the problem was confirmed as a failed ICCU (Integrated Charging and Control Unit) and replaced under warranty. No problems appeared prior to the failure. Vehicle was required to be towed to the repair facility.

Filed Feb 10, 2026 · Electrical, Transmission · GA

2024 EV6 GT-Line with 13,165 miles suddenly showed multiple faults, including "Check electric vehicle system” followed shortly by "Stop vehicle and check power supply". The vehicle almost immediately stopped in the roadway, and my wife (driver) was unable to move the vehicle or even put the vehicle in neutral so the vehicle could be moved. The car is at a Kia dealership for repair who confirmed an ICCU failure. This is an exceptionally dangerous situation.

Filed Feb 9, 2026 · Electrical, Transmission · MD

While operating my 2024 Kia EV6, the vehicle began displaying repeated warnings related to the power system and 12-volt battery. The instrument cluster first showed a “Power limited” message, followed shortly by a “Stop vehicle and check power supply” warning. At the same time, the vehicle indicated that the 12-volt battery was low, despite the high-voltage traction battery being at or near full charge. Shortly thereafter, the 12-volt battery became fully depleted, resulting in a complete loss of low-voltage electrical power. I was unable to electronically unlock the doors, and the vehicle could not be started or shifted into gear. The vehicle became immobilized and inoperable, requiring towing. This failure occurred without warning and created a safety concern, as loss of power could potentially occur while driving or leave occupants stranded and unable to access the vehicle. The vehicle had previously been serviced at a Kia dealership for known power system concerns related to the Integrated Charging Control Unit (ICCU). During that visit, the dealership applied a firmware update only and did not replace the ICCU hardware. The current failure occurred after that firmware update, suggesting the issue was not resolved. This incident represents a loss of motive power and loss of vehicle electrical systems, which could present a serious safety risk if it occurs while the vehicle is in motion or in unsafe environments. The inability to unlock doors or start the vehicle due to complete 12-volt battery depletion is particularly concerning. When roadside assistance arrived to tow the vehicle to the dealership, the vehicle’s 12-volt battery was completely depleted, preventing normal recovery procedures. A portable jump starter was temporarily connected, but the vehicle would not remain powered on long enough to complete the steps required to place the vehicle into neutral or tow mode.

Filed Feb 6, 2026 · Electrical, Transmission · NJ

Driving with my wife and [XXX] child, there was a pop sound from under the car, and the car suddenly showed multiple faults, including "Check electric vehicle system”, which cleared on their own. I parked and turned the car off and on again and the faults reappeared. I started driving home, and during the drive it showed "Stop vehicle and check power supply" and audibly alarmed. As I was only half a mile from my house on local quiet roads, I made it. A few minutes later, I tried to turn on the car and some displays were off, there was no drive power, the steering wheel did not turn, the door locks were flakey, and I wasn't able to tell if I had shifted into Park or if the parking brake was engaged. When the tow truck arrived, the car was completely unresponsive and there was no way to release the parking brake or shift the car in neutral, so the car was dragged across the pavement and onto the tow truck. The failure was quick and comprehensive and could have easily caused injury. There are many highways near me with fast, busy traffic and either no emergency shoulder or a very narrow one. If my car tells me that I need to stop the vehicle, that can create a very dangerous choice between stopping somewhere less safe quickly or risking the car being completely disabled while in the travel lane while I look for a safer spot. Loss of cabin heat can easily become dangerous very quickly in the winter. Many drivers may not even understand the urgency of the warning until the car starts failing to drive. The car is at a Kia dealership for repair who confirmed an ICCU failure. See related the federal safety agency recall no 24V‑867 and others. ICCU failures are endemic to Kia and Hyundai EVs. ICCU failures are widely discussed on many internet forums and seem much more common than the 1% failure rate claimed by Hyundai/Kia. FYI, an interesting root cause analysis was shared on a German EV forum: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)