2022 Kia K5 transmission problems

Filed Nov 1, 2026 · Transmission · MO

The vehicle experienced a complete and catastrophic loss of drive power, rendering the care entirely undriveable. This failure perfectly mirrors the exact safetyhazard detailed in the federal safety agency Recall 22V760 regarding a manufacturing defect in the electric oil pump of the 8 speed dual clutch transmission, which triggers a fail safe mode and cuts all propulsion. Previously, the servicing dealership, Kia of Columbia ([XXX]), performed a transmission control unit software flash related to this recall. The dealership then reported the recall remedy as fully completed and resolved to both KIA America and the federal safety agency database, effectively cancelling the active recall status for my VIN. However, the dealership failed to perform the mandatory physical inspection or complete unit replacement required for an actively failing component. They dismissed my ongoing complaints regarding transmission driveability, flasely blaming my driving habits. Because the software update merely delayed the inevitable mechanical failure of the defective factory pump, the transmission has now completely failed, leaving my family two hours away from the dealership. Th Dealership incorrectly and falsely reported a critical federal safety recall as "repaired" to the federal safety agency while leaving a defective, hazardous transmission in my wife's vehicle, that she uses to get back and forth from her cancer treatments. I am requesting a formal federal investigation into the repair reporting pracices of Kia of Columbia, demanding the Kia America re-open this case to authorize a complete replacement transmission unit under the original saftey mandate. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 22, 2026 · Transmission · 57,000 miles · TX · crash · 2 injuries

The contact owns a 2022 Kia K5. The contact stated that while driving 50-55 MPH, the vehicle lost motive power and came to a complete stop in the middle of the roadway. The contact did not attempt to restart the vehicle. The contact activated the hazard lights; however, 20–30 minutes later, another vehicle struck the front passenger side of the vehicle near the front passenger’s side wheel. The contact sustained sharp lower back, hip, and left knee pain. The contact's boyfriend sustained lower back and right knee pain. A family member transported both occupants to the hospital, where medical attention was provided. The check engine warning light illuminated after the failure. A Police report was filed. The vehicle was towed to Custom Auto-Collision. The contact associated the failure with the federal safety agency Campaign Number: 22V760000 (Power Train). The dealer was notified of the failure by phone. The failure mileage was approximately 57,000.

Filed May 12, 2026 · Engine, Fuel system · PA

The Integrated Thermal Management System (ITMS) in my Kia K5 GT (2.5T engine) has experienced a recurring internal electronic and mechanical fault. This is the third failure of this component. The failure causes the cooling system to malfunction, either by over-cooling or failing to cycle coolant once at operating temperature. ​Under acceleration—specifically when merging onto expressways—the vehicle suffers a sudden loss of power and enters 'limp mode' with a dashboard alert stating the engine is overheating. This creates an immediate safety hazard in high-speed traffic. When the fault occurs, the radiator fans lock at 100% duty cycle. This is a documented systemic issue with the Kia 2.5T powertrain (referenced by major automotive publications and multiple Technical Service Bulletins). ​Despite a prior Lemon Law settlement and an active 100,000-mile powertrain warranty, the manufacturer refuses to acknowledge this as a powertrain or emissions defect, attempting to charge out-of-pocket for a component that prevents the vehicle from passing state emissions and safety inspections."This was also cited in a 2023 issue of car and driver magazine long-term test with The Kia Sorento that shares the same engine and transmission combination This is a third time that part has failed for me with others had to replace that part over seven times The first time it happened it was at 8,000 mi it did not get fixed until 30,000 mi The second time it happened was at 51,000 mi The third time 75,000 mi

Filed May 7, 2026 · Transmission · IN

I was driving on the highway and my check engine light came on. I pulled over and it told it was from engine control system. I had a computer connected to it and it came back the idle control system rpm higher than expected.

Filed Apr 2, 2026 · Engine, Fuel system · AZ

My 2022 Kia K5 GT-Line has had a recurring check engine light fault (P0471 — exhaust pressure sensor circuit) since approximately 9,874 miles in September 2022. The vehicle has been brought to the servicing Kia dealer a minimum of five times for this same fault across nearly 65,000 miles. It has never been permanently resolved. Most critically: dealer repair records from May 2025 (56,501 miles) confirm a technician identified fault code P047100, noted it as a history code, cleared it, test drove the vehicle, and returned it without performing any repair and without informing me. Ten months later, the same dealer presented this identical fault as a $1,121.07 customer-pay repair on a vehicle under active 10-year/100,000-mile powertrain warranty. The repair was only approved after I contacted Kia Consumer Affairs directly — the dealer had not contacted them despite claiming otherwise. The February 2026 repair failed within 15 minutes of pickup. I made five documented phone calls to the dealer over 33 days reporting the failure. No action was taken. The April 2026 repair — sensor and hose replacement — failed within one hour of pickup on April 1, 2026. Of additional concern: Recall SC288/SC288A (Fuel Tank Inspection and ECM Re-Update) was performed on this vehicle twice — July 2024 and August 2025. The ECM governs the exhaust pressure sensor circuit. The P0471 fault first appeared in dealer records between these two recall dates and has persisted through both completions. CARFAX confirms the April 2026 repair involved the engine/powertrain computer module. I am requesting the federal safety agency investigate whether SC288/SC288A is connected to recurring P0471 faults in 2022 Kia K5 vehicles. Kia Consumer Affairs Case escalated April 2, 2026.

Filed Apr 1, 2026 · Transmission · KS

STATEMENT OF FACTS: I presented my Kia K5 for two safety recalls (SC356 and SC263) with an active Check Engine Light for code P047100 (Exhaust Pressure Sensor). I informed the service advisor, Aliyah, that this code is a symptomatic secondary fault of the pressure irregularities addressed in Recall SC356, which explicitly lists an "Illuminated Check Engine Light" (MIL) as a primary warning sign. The dealership dismissed my technical assessment—which was backed by advanced AI data analysis. After the software update was performed, the advisor claimed the code remained "active," thereby "proving" it was unrelated to the recall. Based on this, I was charged a $248 diagnostic fee and told I needed a $534.02 out-of-pocket hardware repair for a "physically failing" differential pressure sensor that was allegedly reading 2 HPA against a spec of 23.09 HPA. EVIDENCE OF ERROR: Upon taking delivery of the vehicle, the Check Engine Light was completely extinguished. If the light were truly "still active" after the update, as I was told to justify the fee, the fault would have been present at pickup. Since then, I have driven over 120 miles (including multiple cold-start drive cycles between [XXX] and my place of work) with a 100% clear dashboard. My XXX App confirms the XXX fault is resolved, while the recalls remain "Open" administratively. REGULATORY VIOLATION: Under 49 U.S.C. Chapter 301, a manufacturer must remedy a safety defect without charge. A software "Logic Update" cannot physically repair a broken pressure sensor. The fact that the fault disappeared immediately following the update proves the sensor was functional and the fault was caused by the recall defect. By misdiagnosing a recall symptom as a non-covered hardware failure, the dealer effectively charged me for a federal safety repair. I request an investigation into these "diagnostic gatekeeping" practices and a full refund of the $248.00 fee. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 23, 2025 · Engine, Fuel system · CA

While driving my 2022 Kia K5 LXS, the vehicle began shaking violently and lost acceleration. The check-engine light came on, showing code P0301 (cylinder 1 misfire). The issue caused unsafe driving conditions, especially with my child in the car. Kia Roseville incorrectly documented the repair, while Kia Folsom later confirmed the issue was engine-related. The vehicle has also been subject to fuel tank expansion concerns under recalls SC288 and SC288A, which can create additional fire risk and pressure issues. Despite repairs, I still experience safety fears and severe loss of vehicle value due to these recurring defects and poor documentation. Kia America has not provided a resolution.

Filed Jul 5, 2025 · Electrical, Engine · IL

While driving the car started to have the sensors for the adaptive cruise control, automatic emergency breaking, blind spot warning, forward collision warning, and rear cross traffic warning all came on. The rpm starting going crazy the car was shaking and struggling to start, the car was shifting weird causing the acceleration to be poor. This all happened while driving if we were on a busy road we would’ve gotten hit the car randomly started breaking and slowing down, this is dangerously and could cause serious injury and damages to the vehicle and others around it. This is a problem a lot of people have been complaining about and need to be fixed it’s not okay or safe to be driving a car with these issues especially when there is no warning it just breaks and shuts down no matter where you are or how fast you may be going.

Filed Jun 30, 2025 · Body, Transmission · TX

A silver piller price of trim flew off on the highway in the rear. A lot of Kia k5 owners have experienced this and it could fly off and hit someone on the highway. Transmission is super jerky and can sometimes lose power I’ve also known a lot of people that have similar issues with the kind of transmission in the k5 GT 2022

Filed May 22, 2025 · Transmission · 38,000 miles · PA

The contact owns a 2022 Kia K5. The contact stated that while attempting to accelerate from a complete stop at the red traffic light, the vehicle failed to respond upon depressing the accelerator pedal. The contact stated that upon shifting to park(P) and restarting the vehicle, the vehicle operated as needed. The vehicle was towed to the local dealer, but was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 38,000.