Kia Sedona door locks problems

Filed Aug 6, 2026 · Body, Electrical · MA

2016 Kia Sedona with power sliding doors. Both rear power sliding doors fail to completely latch upon closing. Doors make loud clicking sounds while attempting to close and require manual pushing to latch. Kia of Attleboro diagnosed and confirmed in writing that both rear door roller arm assemblies are completely missing the roller, and that this condition is contributing to the latching failure. Both power sliding door motors and rear door latches also need replacement. This is a safety hazard as the doors may appear closed but are not fully latched, posing a serious risk of doors opening while driving, particularly with children as passengers. The condition has been confirmed in writing by a Kia dealership. Kia Motors America issued Warranty Bulletin WTY019 in March 2021 specifically extending coverage for this exact latching condition on 2015-2017 Sedona vehicles to 15 years/unlimited miles. The covered components (motors and latches) have been approved for warranty replacement. However, Kia America has denied coverage for the roller arm assemblies despite their own dealer's written confirmation that these parts are directly contributing to the covered latching failure. Components are available for inspection upon request. No warning lamps appeared prior to failure. Problem developed gradually with increasing noise before doors failed to latch completely.

Filed Aug 6, 2026 · Body · IL

the drivers side passenger sliding door will not latch or close properly. The door started opening while driving and would not close. Luckily i had no children in the car at the time. The safety of my CHILD or any passenger could have been at risk. Driving while a van door is OPENING. I am taking it to the dealer this morning. Have to figure out how to get it there since the door wont close. Has not been inspected yet. The door ajar started to go off and the door started opening.

Filed Jun 13, 2026 · Body · AL

Right side sliding became stuck in closed position. Door was not openable by inside nor outside door handles. Not openable by automatic means such as push button. This situation slowed egress and could be a safety issue during emergency evacuation. During repair, KIA mechanics informed me that the forward latch (not the rear latch) of the sliding door was mechanically locked in closed position. The latch had to be destroyed from inside of vehicle to release latch to open door to be able to repair.

Filed Apr 28, 2026 · Body · VA

Both sliding doors will not open using door buttons. Both doors stopped latching on their own before this occurred. Needed to push doors manually for the door to latch.

Filed Sep 1, 2025 · Electrical, Fuel system · KY

There is a continuous leakage of oil from my van even after the dealer replaced valve cover gasket . When I complained they said it was the leftover oil. After a month again I complained . Then they re-checked and said it is my car's timing cover reseal leaking . Again after few days I had to complain as there was a leak. I got the same standard reply of leftover uncleaned oil is the cause. Few weeks later I took the van to them and they said they thoroughly cleaned and there won't be any leak. I sent them pictures of oil drops underneth the car like I did on earlier occassions. On August 11th this year they checked the car after my complaint and said there was no active leak. On 30th of this month I sent them the pictures of leaked oil spots which they are going to check on 18th September!. Since I got my first appointment on January 19 2025 I took the vehicle to the dealer 5-6 times. In between I complained to them about failure of door locks and wiper blades. They said they were fine and had no issues. A week ago passenger side door lock stopped working often . I took to a mechanic store run by AAA. Their response after few days was that the electrical system was failing due to bad alternator as the battery got depleted. They recommended me to the dealer again. I was searching google and realised that an oil leak can cause alternator to go bad leading to electric failure and even fire accidents. On [XXX] I noticed red flashing sign of alternator and some other (?) after 2 minutes drive from home. So I immediately turned back and went home and parked the van in the garage and waiting for September 18 for an inspection by the dealer. Last week drove to St Louis from Lexington, after the dealer confirmed there was no oil leak. In all their reports they mentioned vehicle is in good health! Each time when I sent a picture of a leak I requested managers at the receiving desk to park at a clean place and check the leak which they never did. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (F

Filed Nov 26, 2023 · Body · MI

The driver side sliding door will not open all the way and gets stuck even when the power door is not engaged. The passenger side sliding door often gets stuck and will not release when the power door button is pushed.

Filed Jun 23, 2023 · Body, Electrical · KS

Our Kia Sedona had the cooling fan harness negative Cable melt and caused making our engine overheat. When we took our vehicle to get serviced they told us that the cooling fan harness melted and then it's a common problem with kias. They fixed the pigtail cooling fan harness but are cooling fan does not turn on anymore and they said that it is now an electrical issue and this was from a Kia dealership in Dodge City Kansas. They recently did a recall on sliding doors because they weren't shutting all the way and it worked for exactly one day after the recall and now it's back to not shutting and making a really loud noise when it attempts to shut. When this happens we can't lock our doors because the doors won't lock when doors open and we have to constantly shut off our interior lights so that they don't stay on because the doors don't shut. We've notified the Kia dealership that have done our recall on it and told them that it didn't fix it but they refuse to make it right. We only have 106,000 MI I've got a new cooling fan resistor and put it in and a new pigtail harness and put it in but the cooling fan is still not turning on the low speed and the air conditioner doesn't work either. Our engine constantly smells very hot but it doesn't indicate that it's overheating. We haven't had this vehicle for very long and because of all the problems we've had with it are considering on getting another vehicle and we're considering a carnival but are afraid to because of the way Kia handles their issues.

Filed Oct 10, 2022 · NJ

The passenger door will not open from the inside by pulling on the handle or pushing the door open button. Pulling on the outside door handle will not open the door as well. The remote wont open them as well. This is a safety issue as passengers can't get out of car in case of accident. I have brought it to a Kia dealer and they said it works fine for them and if the problem doesn't occur when they have it they can't fix it. I have an extended warranty letter from Kia that there is a problem with the rear sliding doors. I am mystified as to why I can't get this problem fixed.

Filed Jul 18, 2022 · FL

The door locks on passenger sliding doors,do not keep doors shut,they remain open on both sides and have to use a screw driver to rotate the mechanism.

Filed Jun 28, 2022 · TX

Passenger side back, sliding door will not close securely. The risk is mainly because my grandchildren ride in those seats and the door not securing and subsequent lack of auto door locks when gear shift is moved from park is not safe. When we use that door, the indicator light on the dash is lit and the dinging bells alerts us it is NOT secure. We have to push in on the back of the door to, hear the click, get it secured. Otherwise the indicator light stays lit AND the doors will NOT lock automatically as they should.