2022 Kia Seltos: excessive oil consumption

Filed Jul 27, 2026 · Engine · 36,000 miles · NY

The contact owns a 2022 Kia Seltos. The contact stated that the vehicle hesitated and stalled while driving at various speeds with the check engine warning light illuminated on the instrument panel. The vehicle was taken to an independent mechanic, and the contact was provided information associated with the federal safety agency Campaign Number: 25V099000 (Engine and Engine Cooling). The contact was advised to take the vehicle to a dealer for service. The vehicle was taken to a dealer, and the contact was informed that a software update needed to be performed; however, no additional repairs were performed on the vehicle. The contact was also informed by the dealer that the engine was consuming an excessive amount of engine oil. The contact linked the oil consumption failure with the recall. The mechanic at the dealer failed to perform any further testing or repairs on the vehicle. The failure persisted once the vehicle was returned to the contact. The vehicle was taken back to the independent mechanic who replaced the PCV valve which showed excessive oil inside the valve. The mechanic also discovered blowby in the engine caused by leaking of combustion gases and air-fuel mixtures past the piston rings and down into the crankcase of the engine. The mechanic stated that it was proof that the piston oil ring was inoperable and that the recall was not performed properly. The manufacturer was notified of the failure, and the contact was provided a case number. The vehicle was taken back to the dealer and an OBD II scan was performed but showed no failures with the vehicle. The vehicle remained with the dealer. The vehicle was not repaired. The failure mileage was approximately 36,000.

Filed Apr 13, 2026 · Engine · MO

Engine issue - unknown excessive oil consumption. I started the car to drive to work and immediately it had a very rough idle. I turned the car off and checked the oil level. The car was on a level surface and the oil level was below the acceptable range on the dipstick. It has been about 4000 miles since my last oil change (around 82000 miles) and I noticed the engine was consuming oil about 2500 miles after that oil change. I added a quart of oil to bring the level back within the dipstick’s acceptable range. Throughout all of this, there have been no puddles to indicate a leak, no smoke to indicate oil burning, and no “Low Oil” warning light. I took the car to a Kia dealership in August 2025 for a piston ring recall inspection, and I was told there was nothing wrong with my car. At the time, there was nothing noticeably wrong with my car. I now wonder if the inspection properly assessed the issue. After looking on the Internet, high oil consumption seems like a common issue with my engine that persists even after Kia’s recall inspection. There was no immediate threat to my safety this morning, but I am concerned that this excessive oil consumption could cause catastrophic engine failure before an owner has a reasonable expectation to check the oil level between service intervals.

Filed Dec 9, 2025 · Engine, Transmission · MI · crash

My vehicle was sent to the Kia dealership for service after a front-end collision there was minor body damage however the car wouldn't move so long story short a modular had to be replaced on the transmission there was multiple issues trying to program it I was told there was an issue with my computer they had to reach out to Kia manufacturer for help. I received my car back and while it was there for service I had them do an oil change I hadn't drove 300 to 400 miles and all of my oil was gone from my car when I called Kia they had me bring it back in couldn't find anything wrong with it and said they want to do a oil consumption after I had already documented oil that I had to put into the car three times in the week up until my appointment because every time I check the car it was empty of oil. Now Kia is telling me to drive a thousand miles on it so they can do an oil consumption however my check engine lights on my oil lights on and it is clearly burning extremely high amount of oil. So in caution of not blowing my engine I added oil to my car yesterday one quart and now my oil light is back on after maybe 20 miles of driving. Haven't gotten to 400 mi yet total out of the thousand Kia wants me to drive and my car has stalled at three red lights and cause me to miss out on two job opportunities. My car is a 2022 and has 62,000 miles on it. Everything I research shows there's piston recalls on the engines that are causing these exact problems that my car is having except there hasn't been a recall put into place for my specific year and make. The 2021 and the 2023 Seltos are listed, but my VIN number shows no recalls. The car has a horrible smell now it constantly smells like burning rubber or oil rather, exhaust stinks now. Car is not performing as you would expect a car would with that low of mileage in less than 3 years of ownership. And related to my accident the only issue was the modular on the transmission according to the mechanics everything else was ok

Filed Nov 20, 2025 · Engine, Transmission · OH

This vehicle passed the piston oil ring recall in September 2025, by November 2025 the vehicle was burning through a quart of oil a week. Two different dealerships advised that this wouldn't be covered under the recall, stating the recall was for engine noise. The recall states that the issue in question can cause increased oil consumption that will then lead to noise. The vehicle was 5,000 miles out of warrenty

Filed Sep 2, 2025 · Engine · PA

My car was part of the piston ring recall. It burns over half a quart of oil per 1,000 miles. When I took the car in for the recall inspection, it was deemed that it needed a new engine. They then called me and told me that they “revised” the test, and it no longer would be getting a new engine. The car is still burning oil and makes a ticking sound. The recall issue was not resolved, and my car still has the symptoms relating to the piston rings being faulty. Kia did not fulfill their duty of the recall.

Filed May 5, 2025 · Engine · 206,000 miles · KY

The contact owns a 2022 Kia Seltos. The contact received notification of the federal safety agency Campaign Number: 25V099000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated while driving 25 MPH, the vehicle stalled. The check engine warning light was illuminated. The contact was able to pull over to the side of the road. The vehicle was able to restart. The contact stated that the failure had recurred while driving at various speeds, but mostly while driving at slow speeds. Additionally, the contact stated that the vehicle was experiencing excessive oil consumption, which required the contact to add a quart of oil to the vehicle every 2 to 3 days to reduce the frequency of the failure. The contact stated that upon taking the vehicle to the dealer for recall repair, the local dealer informed the contact that the manufacturer had put a hold on the recall repair. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 206,000. Parts distribution disconnect.

Filed Apr 18, 2025 · Engine · TX

What component or system failed or malfunctioned, and is it available for inspection upon request? The engine keeps stalling and there’s a recall on the engines and I had to wait a month for dealership to say the recall isn’t the problem! How was your safety or the safety of others put at risk? I drive on the highway and busy street and my car will just stop or make smoke for oil reserve. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes the number Ted that they hear the noises on my car. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? 2 months ago I started hearing a grinding noise, oil light came on irregular from oil consumption and metal shards in oil.

Filed Aug 15, 2024 · Engine · RI

A few months ago noise was coming from the engine. I could not find the noise so I just happened to check the oil level and it was down 3 quarts of oil. I put the 3 quarts of oil in and the noise stopped. Now it down almost another quart. I went to Taca Kia and talk to a lady that works in service told me it was normal for the SUV to burn a quart of oil every 1,000 miles. I never heard of a new car burning oil that much. I Heard that Kia put the wrong oil ring in some makes a models.

Filed Feb 16, 2024 · Engine · OH

Engine is burning excessive oil have to add a quart every 3000 miles