The contact owned a 2019 Kia Sorento. The contact stated that while driving at an unknown speed in stop-and-go traffic, the driver noticed smoke emerging from under the hood, pulled over, exited the vehicle, opened the hood, and saw flames. The contact removed items from the vehicle and exited safely. The fire department was able to extinguish the fire. There were no reported injuries, airbag deployment, or crash. A police report was filed. The vehicle was towed to a tow lot. The local dealer was contacted, who referred to the manufacturer. The vehicle was not diagnosed or repaired. The vehicle was deemed a total loss by the insurance company. The manufacturer was contacted and opened a case. The failure mileage was approximately 90,000.
2019 Kia Sorento engine complaints
Page 3 of 7: complaints 41 to 70 of 173, newest first, as owners wrote them.
It need to fill the oil ever two to three weeks - oil consumption? Now this morning it has the a lot of oil in the ground - I won’t drive the car
At 79,000, the engine started running very rough. I took it to the dealer. It’s got a cylinder that won’t fire. I have an extended warranty( big $!) but I’m getting the runaround from Kia. It’s been almost 3 weeks. They’re dragging their feet because they know these Theta II engines are JUNK! I’ve maintained my own vehicles my entire adult life, and I don’t drive crazy either. It also had a knock sensor recall, which most likely kept this issue from being a recall
Oil pressure sensor light came on when I would stop or park after 10-20 minutes of driving. Vehicle was low on oil so I added a quart. About a week later the light came on again so I took it to get oil changed at an independent shop. They said a change wasn’t necessary as I still had 2000 miles left, but said they would top it off if needed. It was half a quart low so they topped it off. On the way home the light came on again. Took it to the dealership where it was diagnosed as an oil pressure sensor failure. Vehicle has 103,000 miles so I was out of warranty. This vehicle is not eligible for the extended warranty for the oil pressure sensor issue provided by Kia as the extended warranty was only for models up to 2018, or vehicles manufactured up until March 2018. This is a 2019 that was manufactured in April 2018. Because of how close the model year and manufacture date is to the Kia provided extended warranty, it is apparent the issue was not corrected for this model year either and it should be part of the extended warranty.
My vehicle is a sorento 2019 model, April 2018 production, and is experiencing oil pressure switch failure that requires $1500 of repair, there is a recall/warranty extension WTY026 for the same model but only up-to March 2018 production, kia claimed that they modified the sensor to eliminate the problem in 2919 models, but unfortunately many of the 2019 model year owners are still experiencing the same problem as the previous year. Please extend this recall to cover 2919-2020 productions as well
2019 with 56,000 miles and the oil pressure sensor AND the fuel pump need replacing. Both items should be considered part of the powertrain but of course they’re not. Called corporate but got the “there is no recall” monologue from their representatives. Needless to say, I won’t make the same mistake with my next purchase.
I am submitting this safety complaint regarding a critical oil leak on my 2019 Kia Sorento, currently at 125,000 miles. I observed a significant amount of engine oil leaking onto the ground where the vehicle was parked, indicating a substantial loss of lubricant. The oil pressure warning light has been illuminating intermittently on the dashboard, confirming that the engine's oil pressure or level has dropped to a critical point. This has been an ongoing issue for several years with this car. What started as a small oil leak that nobody could find has turned into a big issue and safety issue. I am requesting that an investigation be made into this model for oil pressure sensor. The oil dummy light only comes on when the rpms drop or brakes are applied.
2019 Kia sorento with the 2.4 is consuming so much oil and is very noisy. I just changed the oil 4k miles ago and the dipstick doesn’t show any oil. Dealer says it’s normal. There is clearly a problem with these motors. The Kia dealership doesn’t want to figure it out unless they’re getting paid a ridiculous amount of money. Kia should take care of this and pay the bill. They basically said to drive it until it dies and maybe the motor will get replaced. So basically my family and I have to drive this thing and hopefully we don’t get hurt if it seizes up. They want to charge me for an oil change, oil consumption test and an $800 cleaner for a maybe temporary fix. I don’t have a date when this started because it’s been so long with getting the run around. Kia is avoiding our problems when we spend so much money.
I have been having heavy oil leaks with my vehicle and when I check my oil a few days after adding oil it registers bone dry. Excessive oil can be seen in my drive way after pulling in and out. The oil ight has been coming on intermittently and now it stays on. Took it to Kia dealership and inquired about problem and possible recall and they said their was none and instead tried to sell me a nother vehicle.
The contact owns a 2019 Kia Sorento. The contact stated that while driving at an undisclosed speed, the oil pressure warning light illuminated. The contact checked the oil level after arriving at the residence and noticed that it was very low, almost empty. The contact added two quarts of oil to the engine. Several weeks later, the oil pressure warning light illuminated. The vehicle was taken to the dealer, where the contact was informed that an oil consumption test needed to be performed. The contact stated that the vehicle passed the oil consumption test. The dealer cleaned off the top of the engine. The contact needed to add two quarts of oil every 1,500 to 2,000 miles driven. The contact stated that on a separate occasion, while her husband was driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The check engine warning light illuminated. The contact's husband was able to drive back to the residence at a slower speed. The vehicle was taken to an independent mechanic who diagnosed that the engine had failed and needed to be replaced. In addition, the contact was told that the manifold had melted and advised the contact to take the vehicle to the dealer. The vehicle was taken to the dealer, where it was confirmed that the engine had failed. The contact was informed that a bearing clearance test needed to be performed. The vehicle failed to pass the test. The contact was informed that cylinders #1 and #4 had misfired. The dealer changed the ignition coils. The contact stated that the failure had recurred, and the vehicle was parked and was no longer driven due to safety concerns. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 65,000.
1. Vehicle Information Make: Kia Model: Sorento Model Year: 2019 VIN: [XXX] Approximate Mileage: 87,000 miles 2. Incident Details Complaint Title: Critical Oil Pressure Sensor/Switch Leak Leading to Oil Warning Light, Rapid Oil Loss, and Safety Risk Narrative: I am submitting this safety complaint regarding a critical oil leak on my 2019 Kia Sorento, currently at 87,000 miles. The leak originates specifically from the Oil Pressure Sensor (Switch). Symptoms and Diagnosis: 1. I observed a significant amount of engine oil leaking onto the ground where the vehicle was parked, indicating a substantial loss of lubricant. 2.The oil pressure warning light has been illuminating intermittently on the dashboard, confirming that the engine's oil pressure or level has dropped to a critical point. 3.A dealership/mechanic officially diagnosed the issue as a severe leak at the Oil Pressure Sensor. Safety Concern and Precedent: The rapid and severe loss of engine oil creates an unreasonable risk of sudden engine failure/seizure while driving, which is an extreme safety hazard. Additionally, oil leaking onto hot engine components poses a potential fire hazard. I note that Kia has previously issued safety recalls and/or substantial warranty extensions for this exact type of Oil Pressure Sensor/Switch leak on other Kia models and earlier model years of the Sorento. This defect appears to be recurring in the $\text{2019}$ model year, suggesting the core safety defect has not been resolved for this vehicle group. I request that the federal safety agency investigate this specific issue in the 2019 Sorento and mandate a proper safety recall to replace the faulty component and eliminate the serious risk of engine failure and fire. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine has a leak, the engine oil sensor was defected ,front axel leak and needs replacement
The contact owns a 2019 Kia Sorento. The contact stated that while starting the vehicle, the check engine warning light illuminated. The vehicle was taken to the dealer, but was not diagnosed. The dealer informed the contact that an oil consumption test needed to be performed and instructed the contact to return after driving 1,000 miles. The contact stated that the vehicle had to be returned to the dealer on multiple occasions due to exceeding the 1,000-mile interval. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 113,000.
Knocking noise started when pulling off the interstate. No engine light came on. No oil registered on 'dip stick'. Oil change was due at 130,449. The mileage on the car was 132,635. Had towed to Kia dealership where they said there was no test that could be done due to the vehicle being a 6 cylinder engine. They said the 'sound' points to needing an engine replacement. I inquired about a oil pressure switch test and oil consumption test due to past recalls and known engine issues. I was told due to the car being out of powertrain warrenty they would not perform such tests. I have video that shows the car is burning oil. Visible out of the exhaust. This is not something I was aware of until after this incident. These are the same issues as noted in previous recalls. Dealership said would need full engine replacement.
The contact owns a 2019 Kia Sorento. The contact stated that the oil level was constantly checked since purchasing the vehicle. The contact stated she was aware of the oil consumption because the oil had to be topped off after each oil change. The contact stated that there was no warning light illuminated. The contact had taken the vehicle to the dealer where the vehicle was purchased. The dealer performed several oil consumption tests, and confirmed that the vehicle was consuming an excessive amount of oil. The contact was informed that a local Kia dealer was contacted and informed the dealer where the vehicle was purchased, to allow the owner to drive the vehicle until the engine failed and then have the vehicle towed to the Kia dealer for evaluation. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 112,000.
Vehicle: 2019 Kia Sorento (VIN: [XXX] at Incident: 171,800 Description of Incident: On Sunday, August 31, 2025, at approximately 12:30 PM, my 2019 Kia Sorento experienced a sudden and catastrophic engine failure while in motion. I was driving with my two children at approximately 60 mph on Highway 111, a major highway in Palm Springs, CA. Without any warning whatsoever, no dashboard lights, sounds, or symptoms, the engine failed and the vehicle immediately lost all power. The gas pedal became completely unresponsive, and I was left to coast from highway speeds down to a natural stop. My safety and the safety of my children were severely at risk. Being in a vehicle that is unable to accelerate or even maintain speed on a major highway creates an immediate and extreme hazard for being rear-ended by other traffic moving at 60+ mph. We were a vulnerable, slow-moving obstacle with no ability to power ourselves out of a dangerous situation. The vehicle was towed to the Palm Springs Kia dealership in Cathedral City, California, where it was inspected by their service department. A certified Kia technician confirmed the cause of failure was a cracked engine valve, requiring a full engine replacement. I am the original owner of this vehicle and have a complete and documented history of performing all scheduled maintenance. This incident represents a severe safety defect, as a sudden loss of motive power in traffic places the vehicle occupants and surrounding drivers at high risk of a serious collision. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
This has to do with your investigation into the oil pan caps cracking. I had my vehicle serviced 6 months ago and KIA of York PA required me to pay for replacement. Over $150 to correct this issue that seems to be a defect.
The contact owns a 2019 Kia Sorento. The contact stated that while driving at 70 MPH, there was an abnormal knocking sound coming from the vehicle. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where an oil change was performed because the engine oil level was extremely low. The contact stated that the vehicle was not due for an oil change at the time of the service. Despite the oil change, the failure worsened as the sound became increasingly louder. The vehicle was then taken to another independent mechanic and was diagnosed it with engine failure, and the contact was provided an estimate for a new engine. The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was approximately 164,000. The VIN was not available.
My car is consuming oil. I was two and a half quarts down when I checked it and the oil light never came on! I'm glad I checked it when I did! The car is consuming oil and has to be checked every day to every other day. I called the local KIA dealership and of course, NO RECALLS. What do I do now?
Excessively burn oil, have to put in a quart or more every 1,000 miles. Recently started sputtering like there was a miss in the engine when idling or barely pushing at acceleration pedal. Bad oil consumption started around 70k miles Engine sputtering started around 100k miles
Engine consumes oil. Have to add oil all the time. No leaks
The contact owns a 2019 Kia Sorento. The contact stated that while driving 65 MPH and depressing the accelerator pedal, the vehicle failed to respond as intended. The contact pulled over to the right side of the road and waited for several minutes before the vehicle started working as intended. The check engine warning light was illuminated. A dealer was contacted. The vehicle was taken to a dealer where it was diagnosed and determined that the transmission needed to be replaced, and that the transmission fluid was burnt. The contact had experienced the failure on several occasions. The transmission was replaced, and the vehicle was repaired. The manufacturer was notified on the failure and opened a case. The approximate failure mileage was 71,682.
There is almost no engine oil in the engine room. This phenomenon does not happen once, but continuously.
Car suffered catastrophic internal engine failure due to rod bearings. Began having problems with engine stuttering then knocking July 2025. Car was taken to local mechanic stated that the engine failed. Followed up with local Kia dealer and they verified that the engine had indeed failed. Car is in my possession and available for inspection. My safety and the safety of other drivers was compromised in that all engine systems failed rendering me incapable of driving vehicle and needing to push the car manually. Dealer has reproduced and confirmed the engine failure. Car inspected by dealership only. No warning lights came on. The only lights that have EVER come on in my vehicle are the low tire pressure sensor and the scheduled maintenance light. NEITHER of these sensors came on during these events.
Purchased this vehicle in June 17 2025 from a used car dealer, as i was driving from time to time, i noticed that the vehecle would hesatate, and at times would stall, i had the spark plugs and coild replaced along with a new high pressure fuel pump, it still hesatates when pulling out into traffic, from a stop, this places the vehicle in a very dangerous position in that it can be broadsided, or another form of collision with on comming traffic, I looked on line on various sites and there are quite a number of kias with this issue, some contacted the mfg and were told that it is withing the 8 speed transmission, something about the servers inside it, this appears to be an issue with several year models, and the mfg does not repair or replace the defective part, so i am quite sure they are awar of it, i am not aware of any loss of life for this priblem, i have also seen that by placing the selective system out of eco, economy or comfort mode into ( sport ) mode that it does not do it as often, but at time does, this mode also has a determental effect on millage. i am sure that many KIS SORENTO owners have the same issue and shoudl be fixed under a nationwide recall, ASAP before anyone is hurt or killed like stalling out when pulling out into highway traffic.
Engine started to knock, had it towed to KIA dealership it's been there for 6 weeks. Dealership stated needs new engine, Warranty company refuses to honor coverage and replace engine. 2019 KIA Sorento known for engine failures. Have provided oil receipts which is not needed. (Nothing stated in our contract) If we continued to drive the car the engine would have seized or caught fire. There were no lights on the dash for oil change or engine lights on. There are reports on the internet/social media of many people having the same issue with this engine. There should be a recall on this engine. And it shouldn't be this hard to get KIA or the warranty company to step up and fix a known problem. We paid for the warranty and expect it to work for us. Right now the car is still at KIA of Huntington. We have made a complaint with the BBB and with KIA Headquarters in CA hopefully this will be resolved soon.
Excessive oil burning Burns an insane amount of oil every week, 2-3 quarts of oil has to be added every week. Started noticing slightly low oil a year ago wasn’t a lot but it has gotten worse.
Car burns oil excessively. It is an ongoing problem. I also had a kia soul before this that also burned oil excessively
The contact owns a 2019 Kia Sorento. The contact stated that while driving at an undisclosed speed, the vehicle abnormally shuddered, with the low oil warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with engine failure due to excessive oil consumption. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The vehicle was taken to the dealer, where the diagnostic result was confirmed. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The approximate failure mileage was 74,750.
The contact owns a 2019 Kia Sorento. The contact stated that while driving 55 MPH, the vehicle unintendedly accelerated to 95 MPH. The check engine and hazard warning lights were illuminated. The brake pedal was depressed; however, the brakes failed to respond as needed, and the steering wheel seized. The contact turned off the vehicle and was able to stop the vehicle on the side of the road. The vehicle was towed to a local dealer to be diagnosed, and the contact was informed that the throttle shaft was faulty and needed to be replaced. The vehicle was repaired; however, the failure recurred the following day, and while driving at 55 MPH, the vehicle unintendedly accelerated to 80 MPH. The contact pulled over to the side lane and turned off the vehicle, and the vehicle gradually slowed to a stop. The check engine warning light and hazard light were illuminated. The vehicle was restarted and slowly driven back to the same deale,r and the contact was informed that additional diagnostic tests were needed to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 100,000.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2019 Kia Sorento?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history