The oil was changed with no leak, and less than 1000 miles later, it all disappeared. Now, it has gone into limp mode and thrown a knock code due to no oil. Having it sent to a shop four times in a week is not okay. If there's no leak and no gasket problems, where did all the oil go? I have more posts about this daily. I have 96,000 miles on this engine with full synthetic changes every time. It was healthy, and now it's not because it's overeating oil. Make it make sense, please.
2019 Kia Sorento engine complaints
Page 4 of 7: complaints 71 to 100 of 173, newest first, as owners wrote them.
Oil Consumption: flickering intermittent oil light at various times. Occurred after routine maintenance and oil changes. Various reasons were given when serviced including leak at the cap or via a screw. Multiple trips to the dealer for service. Engine has no oil and light did not remain illuminated, only flickering occasionally. Performed combustions clean out 4 weeks ago with top off of oil. Light came on, notified that the vehicle is very low on oil since that time again with light flickering.
The engine consumes alot of oil. There are no oil leaks. I have to refill the engine with 1 quart of oil weekly. The vehicle is available for inspection. If this is not checked week, the engine could lock-up for low to no oil. The service representative at Kia in Wendell, NC, verbally stated to me the engines do burn alot of oil and to monitor it regularly. He confirmed there are no recalls on the engine though. No official inspection has been performed. But the vehicle is available for inspection by an official. There have been no warning lamps or messages. The symptom here is constant checking of the oil levels with the dip stick and refilling the engine with oil weekly.
I'm writing to formally report a serious and potentially dangerous issue with my 2019 Kia Sorento (VIN: [XXX] ), which is experiencing excessive engine oil consumption. This problem began around 55,000 miles and has progressively worsened to the point where I must either frequently top off oil between scheduled changes or get oil changes well ahead of schedule. Despite having two documented dealership oil changes within approximately 2,000 miles and three months, I have received no support from Kia or my extended warranty provider (JM&A). Kia Customer Care has acknowledged the issue, but refuses to inspect, test, or address it unless the KSDS sensor is triggered or the engine seizes — essentially requiring catastrophic engine failure before they will consider any action. JM&A has similarly denied coverage, stating that oil consumption is excluded under their warranty plan. This approach is not only unreasonable — it is dangerous. Running low on oil can lead to sudden engine failure while driving, posing a real risk to both my safety and that of others on the road. I have not been offered any proactive oil consumption test or preventive service by Kia, despite repeated concerns. I am aware that excessive oil consumption is the subject of class action litigation involving Kia vehicles, and that this may reflect a broader pattern of engine-related defects. I believe this situation deserves formal investigation and review, potentially qualifying for recall consideration or an expanded service campaign. I drive daily in the Chicago suburbs with my [XXX] and [XXX] children, which makes the risk of sudden engine failure especially concerning. I am more than willing to provide documentation, including oil consumption logs, service records, and communications with both Kia and JM&A. I respectfully request that the federal safety agency review this matter for possible investigation into its safety implications and potential systemic nature. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.
Upon starting my vehicle after going to the grocery store, the ABS, ESC, Check Forward Collision-Avoidance Assist System, and Auto Hold warning lights illuminated. The cruise control was then inadvertently deactivated. When vehicle is started the Check Forward Collision error comes on. After a few months when entering the freeway and accelerating I received an error regarding unknown engine issue. Took vehicle to Kia dealership and was who diagnosed that the hydraulic electronic control unit (HECU) needed to be replaced. Manufacturer being notified, vehicle not repaired at dealer due to cost.
The contact owns a 2019 Kia Sorento. The contact stated that the check engine warning light had remained illuminated. The vehicle was taken to the local dealer on several occasions; however, the cause of the failure was not determined. Additionally, the contact stated that while driving at an undisclosed speed, the vehicle suddenly stalled. The vehicle was towed to the local dealer, where it was diagnosed that the engine had overheated and fractured. The contact was advised that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 97,000.
Kia is well known for their engine problems. I had my engine light come on and was flashing so I pulled over and shut the car off. After a few minutes I turned it back on and the light was still on, but no longer flashing. I was able to get it to my local mechanic who told me it needed a new engine. I had it towed to the Kia dealer where I purchased it. They were able to replace it was a refurbished motor, but Kia indicated it was not part of the current recall. I feel it should be part of the current engine recall, but if it truly is not then I felt you should be made aware of the issue.
We have noticed a great amount of oil consumption in the engine. We first thought we needed an oil change. We keep up on maintenance of our vehicles. When we took it in to get the oil changed, they said we had almost no oil in the vehicle. So once we had an oil change, we took it to Kia of Alcoa and they said there was nothing wrong with it. We drove it a while and again low on oil. We take it back to Kia of Alcoa and they do an oil consumption test. We drove it 1,000 miles like they said to do and we came back. They checked the oil level and they said the oil consumption was normal. So again we drive it and still having issues with oil consumption. We always have to put anywhere from 1 to 5 quarts of oil in the vehicle on a regular basis. We should not have to add oil in between oil changes. Now we have a rattling going on and we are taking it back to Kia Alcoa soon to get looked at. We believe that rattling is from the high oil consumption. Nobody seems to have a solution and everyone thinks there is nothing wrong with the vehicle.
I own a 2019 Kia Sorento SX V6 that I purchase in January 2024 that now has 73k miles. I recently started encountering a problem where the oil light would come on and stay on while my car is an idle position. I went to City Kia of Greater Orlando to get an oil change because I assumed that was the problem. Sometime after the oil change the light continued to go on when my car was in idle position and my engine oil that was just replaced had been severely depleted so I returned to Kia to have a diagnostic done and was advised that the oil filter housing gasket, oil pressure regulator valve needed to be replaced along with some other repairs for leaks so I approved the repairs but after the repairs were completed and I retrieved my vehicle the same problem of the oil light coming own when idle continued. I returned one again to Kia and had another diagnostic done and they found that now the oil pressure switch with harness needed to be replaced which I questioned because why wasn’t this issue found with the first diagnostic. Why so many issues with parts related to my engine and is not covered under warranty or as part of a recall. I’ve done some research and found numerous complaints of the 2019 kia sorento having the same engine issues and having the same parts replaced. I strongly believe that this is a defect on this car and should be addressed immediately and these issues scrutinized.
The contact owns a 2019 Kia Sorento. The contact stated that while driving at various speeds, there was an abnormal ticking sound coming from the engine. The vehicle was taken to a local AutoZone, where a representative inspected the vehicle and advised the contact that the engine oil was extremely low. The contact added engine oil, and within two weeks, the engine oil was extremely low again. There were no warning lights illuminated. The contact stated that several local dealers were contacted; however, the vehicle was not diagnosed or repaired. The contact was advised that the VIN was not under recall. The vehicle was not repaired. The contact referenced a settlement under Kia Engine Litigation: Case [XXX] as possibly related to the failure. The manufacturer was notified of the failure. The approximate failure mileage was 69,000. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Oil consumption
I started burning oil faster than my oil changes were due. One of the techs told me he had seen far too many Kias with this known issue. My Checked engine light came on a couple months after. When I took it in the shop they ran a compression test and advised that the engine was on its way out and stated they would recommend replacing the engine due to oil consumption and low engine compression. I am the 2nd owner to this vehicle and have maintained all the maintenance on it. Its crazy that I still have 3 more years paying for it at 148,000. As many complaints as there are online for this vehicle Kia should definitely be looking into it. At least up the warranty mileage. I drive my kids with this vehicle and feel at any minute its just going to give out on the highway.
I have a 2019 Kia Sorento which I bought new and changed the oil every 5-8k miles. I was told this was fine with newer vehicles that use synthetic oil. I started having issues with my car burning oil really fast around 60-70k miles. The oil would be dark and low without any warning light, well before my window sticker indicated I should need service. The shop where I take my car warned me this was happening with Kia engines. They also shared with my that my dashboard light was not coming on because it had not been "re set." I have always had a problem with the oil light coming on when I don't need oil and it not coming on when I do. I had my oil changed and was back after 3k miles because my engine was dry. A week later I stopped for gas on my way home from work at 1am, and its a good thing I checked my oil because it was dry. I have young children I drive around town daily. This is terrifying for me- not knowing if my engine could blow up any time, without warning. So I took my car to Kia where they started an oil consumption test. Which was time consuming and stressful to deal with. I have a maintenance gap that took place during Covid. Likely because my father in law changed my oil. I am hoping we can get receipts for this or apparently I am screwed, but this was 3 years ago! :( On top of it, the back of my white car is now grey because of all of the oil I am burning. Which explains the awful smell that fills my home when I open the garage door with my car running. That really can't be good. This has been a nightmare and its only the beginning for me. Kia needs to step up and take responsibility for their faulty engines. Stop making it so complicated for customers to get the quality service they deserve. I should not be fighting for them to fix an issue that has come highly complained about.
We were driving home Saturday and our 2019 Kia Sorento EX V6, 3.3L engine with 24000 miles, just stopped running. We got the car pulled over and noticed smoke coming out of the hood. The tow truck towed it to the dealership: seized engine. We are the second owners of this vehicle, we purchased it from a Honda dealership 20K miles on it and have not had one moment's trouble with it until this happened. We have had regular maintenance done, etc. So now I have a vehicle that I owe several thousands of dollars on that is completely useless.
Engine burns too much oil
I am the owner of the aforementioned KIA Sorento EX SUV which I leased when new from TASCA KIA then purchased at the end of my lease. It should be noted that my new address is [XXX] as I moved from the Coventry address on May 26, 2023. I religiously have my oil changed (have all receipts since 2019) at the manufacturers recommendation. At around 55,000 miles I started noticed wet spots on the driveway below the engine and was not sure if it was anti-freeze or oil. As the mileage on my vehicle increased over time I noticed the spots on the driveway getting bigger. A fellow KIA owner who incidently owned a 2019 Sorento Platinum with a V-6 like mine stated that they developed a sizeable oil leak in their vehicle at around 50K miles. My vehicle had close to 74K miles and I noticed that my oil level was dipping down. On December 9, 2024, I drove my vehicle over to KIA of Attleboro, MA and after a mechanics inspection it was determined that was engine was in fact leaking oil from both the filter housing which is plastic and also from the area where the wiring harness connects to the oil pan that indicates low oil pressure which never notified of low oil. On December 10, 2024, I brought my KIA Sorento back to the same dealership in Massachusetts where the oil leaks were repaired at a cost of $912.43. I subsequently went on the web and discovered that this was a growing problem with this year and model KIA along with other years with some owners seizing their motors. I never received a notice from KIA notifying me of this potential issue which I believe is larger than being reported and should inspired the federal safety agency to force KIA USA to send out a notice to all affected KIA owners and fix this problem at no cost to the consumer. Putting this money out unexpectedly just before Christmas was painful. I would like to be compensated for this expense which is a defect. Thank you. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
This Type of vehicle has a Recall for Oil Pressure Sensor Switch. I Contact Dealer prior my Warranty Covers. But they keep denying the Repairs. Saying tis types of works its not cover on this Warranty. This Vehicle its a Recall for this Oil Pressure Sensor Switch. The Dealer Kia Dont Want to work with the Client other than offering you. A Trade for a new Vehicle Not A Good Bussiness from Kia. Very Dissapointed
The contact owns a 2019 Kia Sorento. The contact stated while driving 75-80 MPH, there was oil leaking from the vehicle. The contact also noticed that there was oil on the garage floor. There were no warning lights illuminated. The contact stated that the failure was related to the federal safety agency Campaign Number: 22V202000 (Engine and Engine Cooling). The vehicle was taken to an independent mechanic, who determined that the oil pan needed to be replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted. The failure mileage was approximately 101,011.
Oil consumption, car seizes,loses power and stalls when at 65 to 70 mph on highway,almost caused two accidents in which i was able to avoid, both times my children were in the vehicle.spoke with kia as well and they stated they were unable to help with this issue and only suggested us to go to a dealership.We have taken the car to the dealership and to auto shop 3 times in the past 6 months no resolve.Just got an oil change again and did oil consumption test (result was .8 oil burned at 1,000 miles) ,now 2 weeks later no oil in car as oil light came on after it was filled back up at the oil consumption test ,engine is faulty and burns oil at alarming rates.
Recently the 2019 Kia Sorento 3.3L V6 has had an intermittent Engine Oil Pressure Light. It will sometimes come on at low idle but not all the time. We did find a leak at the oil filter housing and repaired that, which did not solve the light issue. The vehicle has oil in it, thus not the problem. The vehicle was Manufactured in June of 2018 and there was a recall on the exact issue just prior to this for 2018's. Given the manufacture date and the fact this issue was not discovered until AFTER the vehicle were produced, I feel that given the timing it would be fair to say this vehicle would fall into the recall. I did have an independent shop diagnose this as a possible electrical short or part issue. I have spoken to Kia and they have provided no assistance on this.
The vehicle (90k miles) has a check oil light on. When I took it to the dealer, they diagnosed the issue as a faulty oil pressure sensor (see attachment #1). The model year warranty is 10yr/100k for engine/powertrain, I was informed that since I am a second owner that they will only honor a 5yr/60k warranty. I then looked to see if there was an extended warranty on this component and there is on the site. A letter from Kia dated 4/6/2022 (WTY026) (attachment #2). Attached for you convenience shows an extension of the warranty of this component to 15yr/150k. The letter includes my vehicles make and model, but uses the model year 2014-2018 with a manufacturing date of 12/17/2012 - 3/7/2018. My vehicle was manufactured on 3/2/18 from the VIN plate attached to the vehicle (attachment #3). The dealership also refused to cover the warranty based on this letter because of the model year. My issue is this model year uses the same engine and components and was manufactured before the cut-off of the extended warranty. I would like to see the extended warranty extended to cover further model years as the component is still causing the same safety issue
The engine blew up. I have all of my oil change receipts and gave them to West Herr Kia, and per Kia West Herr, Kia denied covering the blown engine because the piston went through the engine with great force. This happened at approximately 110,000 miles. West Herr Kia quoted 10,400 to replace the engine. Please let me know if you would like copies of the oil changes. I won't be able to upload all.of them.
This Engine is the Lambda II 3.3 Cylinder and it has been using a quart of oil every 400 miles. The oil light went on while my wife went to Mayo clinic in Minnesota for [XXX] and she had to pull over and put more oil in while on the side of the road. Kia dealership looked at it and said they could do an oil consumption test but that KIA would not pay for a new engine since at 96000 miles, it is out of warranty (second owner). This issue appeared suddenly and is getting worse. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2019 Kia Sorento. The contact stated that the vehicle was consuming an excessive amount of engine oil. The vehicle was taken to a dealer four times where an unknown diagnosis was provided and the vehicle was repaired four times with unknown parts, but the failure persisted. Additionally, the contact stated that while driving at approximately 45 MPH, the vehicle jolted forward, shuddered, and lost motive power. The check engine warning light was flashing. The vehicle was taken to a dealer where it was diagnosed that the cylinder #2 valve was burned and needed to be replaced. The vehicle was being repaired. The manufacturer was notified of the failure. The failure mileage was approximately 101,000.
I have been without transportation for 3 months now and I’m about to lose my Job
My car has been in recall with Kia motors and nothing has been changed or done
The contact owns a 2019 Kia Sorento. The contact stated that the vehicle was taken for an oil change and the oil warning light illuminated immediately after the oil change was performed. The vehicle was returned to the mechanic who diagnosed that oil was unclean. The mechanic informed the contact that the failure had caused the air conditioning to fail. The mechanic informed the contact that there were metal shavings found in the oil. The oil was flushed and replaced. The contact was referred to the dealer. The dealer was contacted and confirmed that the repair was not covered under recall or warranty. The manufacturer had not been made aware of the failure. The failure mileage was 149,000.
The Oil Pressure sensor was lighting up on the Dash indicating Low Oil pressure when the engine was running under 1500 RPM. Was replaced and Same condition appeared within hours leaving the dealership. KIA USA was no help in resolving the issue. Technician noted that there was no Sludge or any reason for the issue. I have seen many reported issues with the same result on line
Fuel pump malfunction. It is available for inspection. My safety was put at risk and others because the car stalled abruptly while driving and would not accelerate. Yes the dealer was able to recognize fuel pump issue. No other symptoms.
Engined failed in the middle of the highway at 100,800 miles. Engine has had horrible oil consumption issues for a long time, despite regular oil changes and checking the oil levels. KIA already has a 150k class action settlement for engine failure due to connecting rod bearing failure, but have denied warranty and wanted out of pocket $7600 for full engine replacement.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2019 Kia Sorento?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history