2022 Kia Soul: engine stalls while driving

Filed Oct 30, 2026 · Engine · TX

My 2022 Kia Soul (VIN: [XXX], ~57,000 miles) is subject to Safety Recall 25V‑099 (SC336) for defective piston oil rings causing rapid oil loss, engine noise, stalling, seizure, and fire. On XXX, my vehicle suffered severe engine rattling and was towed to Kia of Frisco (TX). Technicians physically inspected it and documented two critical findings: 1. The oil pan was completely dry/empty. 2. The engine exhibited heavy carbon buildup in the combustion chamber. The vehicle was 1,000 miles UNDER its maintenance interval, with the previous service done at this same dealership. A dry oil pan and carbon fouling are direct physical proof of defective piston rings allowing oil to burn rapidly. REMEDY FAILURE & FALSE NEGATIVE: Despite documenting a bone-dry oil pan and carbon fouling, the dealership ran Kia's PNSS sound/vibration test, which yielded a false "pass." Based on this false negative, Kia of Frisco and the regional DPSM formally refused on XXX, to authorize recall engine replacement. Instead, they are forcing me to drive this internally damaged, oil-starved, rattling vehicle on public highways for a 1,000-mile oil consumption test. SAFETY HAZARD & AUDIT AQ25001: Ordering a consumer to drive an oil-starved, rattling engine on public roads creates an immediate hazard of high-speed engine failure or fire. Kia Consumer Affairs refuses to transfer calls, leaving me stranded with out-of-pocket rental costs. This directly demonstrates the flaws investigated under the federal safety agency Audit AQ25001 regarding unreliable 25V‑099 recall protocols. I request the federal safety agency investigate Kia for issuing false-pass inspections and forcing consumers to operate severely compromised, fire-risk vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 7, 2026 · Engine · TX

Engine oil light came on and went to take in to get an oil change though it had 1000 miles or so to go. Had oil change but light did not go out, and service said to get it diagnosed at mechanic. Made an appointment and car then driven by my daughter stalled when entering the freeway. The car started and I had her drive it home. I tried it the next day and had no problem other than lack of power. At the car appointment, stated that it looked like a National Safety Recall problem and to take it to Kia for the problem. At Kia, they said there were a number of recall's that the fixed on the vehicle, but the safety recall for the engine did not apply as they didn't "hear" anything. They agreed it was losing power and it stalled when coming to a stop, turning and or accelerating. They said for $250 they could run a diagnostic. Having already done that with a trusted mechanic, I seemed at a loss on what to do. I had another mechanic look at it with the same recommendation that it was a recall problem and engine should be replaced.

Filed May 8, 2026 · Engine · MD

The check engine light came on. I took the jar to Kia and also requested for the piston recall to be repaired. I was denied due to an expired warranty. The engine stalled and stopped suddenly while driving in the street. Soon the care was no longer drivable.

Filed May 8, 2026 · Electrical, Engine · GA

Weeks before the vehicle completely shut down, my car began stalling and shutting off in traffic without warning while driving. I was usually able to turn the vehicle off and restart it, and it would come back on temporarily. At red lights and stop signs, the vehicle would power down, stall, jerk forward, and then begin moving again when I pressed the accelerator. On 05/01/2026, while stopped at a red light on my way to get gas, I noticed the vehicle vibrating unusually. I made it to the gas station, filled up, and drove away. However, as I entered a heavily traveled highway, the vehicle began shaking uncontrollably and completely shut off in traffic. I was unable to restart the vehicle and had to have it towed, and later towed again to a Kia dealership/service center. The diagnostic codes identified were: * P0014:00 – Exhaust Camshaft Position Timing Over-Advanced/System Performance (Bank 1) * P0017:00 – Crankshaft Position/Camshaft Position Correlation (Bank 1 Sensor B – Exhaust) * P0303:00 – Cylinder 3 Misfire Detected I am extremely concerned because the vehicle is only about four years old, and I purchased it a little over a year ago. I have previously taken the vehicle to Kia for recalls, including recalls related to engine issues. Based on my research and the symptoms of my vehicle, I believe the recall involving the piston oil rings may be related to the camshaft and crankshaft issues now occurring. I am concerned this may represent an additional safety-related defect or recall issue that has not yet been fully recognized by Kia. I am submitting this complaint to bring awareness to this issue and request that a proper investigation be conducted before more drivers experience a dangerous failure in traffic. I would also like to request direct follow-up regarding my specific vehicle and this incident. Due to the seriousness of the failure and the safety risk of the vehicle shutting down in active traffic, I believe my vehicle should be reviewed as part o

Filed Apr 19, 2026 · Engine · TX

My car stalled with no precursors. The engine and oil was maintain but the engined stall with out smoke or mixed oil. This error falls directly under the recall for pistion rings that cause engine failure. I brought my vehicle to Archer Kia and after two-three months of waited for the recall repair they stated that they could not repair the failed engine under the recall that causes failed engines.

Filed Apr 3, 2026 · Engine · 81,000 miles · MN

The contact owns a 2022 Kia Soul. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly lost motive power and stalled, with several unknown warning lights illuminated. The vehicle was unable to restart and needed to be towed. The contact received notification of the federal safety agency Campaign Number: 25V099000 (Engine and Engine Cooling). The vehicle was towed to the dealer, where it was diagnosed and it was determined that the engine had failed and needed to be replaced. The vehicle was repaired. The contact was informed by the dealer that a used engine was installed as a replacement in the vehicle. The manufacturer was made aware of the failure. The approximate failure mileage was 81,000.

Filed Mar 20, 2026 · Engine · FL

I am filing a safety complaint regarding my 2022 Kia Soul LX with approximately 97,500 miles. The vehicle has experienced sudden and excessive oil consumption despite regular maintenance and a recent oil change about 1,500 miles prior to failure. While driving in normal traffic conditions, the vehicle suddenly began running rough, lost power, and entered limp mode. Shortly after, the engine stalled while I was actively driving, creating a dangerous situation and safety concern for myself and other drivers. A mechanic inspection found diagnostic trouble codes related to camshaft timing issues and determined that the timing chain tensioner likely failed due to oil starvation. The mechanic also found internal engine damage including piston ring failure caused by abnormal oil consumption. I was advised the engine is not repairable and requires replacement. I understand there have been widespread reports, recalls, and class action litigation involving Kia engines experiencing similar oil consumption and catastrophic failure issues. However, I was informed my specific VIN is not currently included. Because this failure caused a sudden stall while driving and poses a significant safety risk, I am requesting that this complaint be investigated. I believe this defect could affect additional vehicles beyond those currently included in recalls or service campaigns. This vehicle was properly maintained and the failure occurred unexpectedly and prematurely for a modern engine. Before the stall that happened going at least 35 mph with my [XXX] daughter In the rear seat, there was no prior warning oil lights or engine lights. Causing severe safety concerns for myself and child. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 20, 2026 · Engine, Fuel system · IL

My 2022 Kia Soul experienced a sudden loss of motive power and stalling while driving, creating a high risk for a rear-end collision in traffic. An authorized Kia dealership (Mike Miller Kia) performed a major timing repair in March 2025 [XXX] ) to address these safety issues. However, the exact same failure occurred again in January 2026. The dealership now documents that the engine was 4 quarts low on oil, nearly empty, despite proper maintenance. This indicates a severe oil consumption defect that leads to timing failure and unpredictable engine stalls. I believe this vehicle poses an unreasonable safety risk due to this recurring stalling condition, which matches the defect described in the federal safety agency Recall 25V099 (SC336), though my VIN is currently excluded. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 17, 2026 · Acceleration, Engine · IL

In March 2025, my 2022 Kia Soul developed a check engine light and drivability problems that progressed to rough idle, loss of power, reduced power with limited speed and an unresponsive throttle, and stalling after continued driving. The vehicle was taken to the dealership, and the dealer performed a major timing related repair (camshaft and related timing/CVVT components) under on 03/07/2025. In January 2026, the check engine light returned and the dealer’s printout shows timing correlation related codes again (P0014 shown as pending and P0017 stored as history). Because the prior event involved loss of power and stalling, I stopped driving the vehicle immediately and brought it in as soon as the dealer had an opening to avoid a repeat safety incident. The dealership has stated the condition is due to low oil or excessive oil consumption and has recommended either engine replacement or additional major timing/engine repairs to make the vehicle drivable. I am concerned this is a recurring engine timing or engine control condition that can lead to reduced power and stalling while driving. I am also aware of recalls or manufacturer campaigns reported for similar Kia Soul vehicles involving engine oil consumption or related engine damage concerns, but my VIN does not show as included. Given the repeat timing related codes and prior reduced power and stalling, I am requesting review of whether this condition warrants broader investigation beyond the current VIN scope.

Filed Dec 17, 2025 · Engine, Transmission · 62,000 miles · CA

The contact owns a 2022 Kia Soul. The contact stated that the vehicle stalled while idling on several occasions. Additionally, the check engine warning light was illuminated. The contact scanned the vehicle with a vehicle scanner, and the DTC: P1C28 was retrieved, which the contact related to the federal safety agency Campaign Number: 23V531000 (Power Train); however, the model year was not included in the recall. The contact later became aware that the VIN was included in the federal safety agency Campaign Number: 25V099000 (Engine and Engine Cooling), and the vehicle was taken to the dealer for the recall repair. The dealer diagnosed that the engine oil pump needed to be replaced, and the contact was informed that the repair was not covered under the recall. The contact stated that the oil pump failure might also be related to the oil piston rings failure described in the recall. The manufacturer was notified of the failure but declined to cover the cost of the repair. The vehicle was not yet repaired. The failure mileage was approximately 62,000.

Filed Oct 29, 2025 · Acceleration, Electrical · 100 miles · CO

The contact owns a 2022 Kia Soul. The contact stated that the month that the vehicle was purchased, the vehicle failed to accelerate as intended while depressing the accelerator pedal, and the vehicle stalled. The contact was unable to coast to the side of the road. The ABS, traction control, Forward Collision Avoidance, and System Check warning lights were illuminated. The vehicle was towed to the dealer; however, no cause for the failure was found. The failure was progressively worsened. The contact stated that several unknown warning lights illuminate every seven miles of driving. The vehicle was taken back to the dealer; however, no cause for the failure was found. The failure was later diagnosed as a control area network failure. The vehicle was not repaired. The contact stated that the failure persisted. The contact stated that the vehicle was parked at the residence, and afterwards, the system rebooted. The manufacturer was notified of the failure but offered no assistance. The failure mileage was 100. The VIN was not available.

Filed Oct 27, 2025 · Driver assistance, Engine · CO

Since purchasing the vehicle, it just turns off while driving. It has NEVER stopped doing this. The dealership has consistently stated they are unable to repair as the diagnostic device does not register any code. Impossible as the car should have retained a code for this and so many other warning lights going off. Even so, Kia has the responsibility of fixing it all this time. I have shown screen shots where both lower level rows of warning lights and the one in the upper right corner are all on or a variation. There are people in my car witnessing these events. My family and myself are in eminent danger. The car is unreliable and unable to pass emissions with warning lights on or the car just shutting off. Kia continues to endanger us by forcing the car back onto the road without repairs, or so they say. They do not state what they have done other than taking off the front bumper and I believe they didn't even intend to tell me. I drive away it occurs again. You turn off the car; then, turn it back on and the lights go away temporarily. Kia Customer Care will only allow a service manager to communicate with, so if they are on vacation or out the car owner has no recourse and no car. Request a Kia field manager and refuse!!! Will only take action if diagnostic show code which it doesn't and I have witnesses the car just turns off. This is not the only Kia vehicle that have known to shut down. I have never received a notice of recall and it doesn't show, but my SUV SHUTS OFF WHILE DRIVING AND KIA HAS FAILED TO REPAIR OR REPLACE. I have special road side assistance other than KIA as they are untrustworthy and must caravan if I have to travel. I should not be limited or live in fear of being killed in this vehicle. It has been towed, won't start,.....