2019 Kia Sportage: engine knocking or ticking

Filed Jan 9, 2026 · Engine, Transmission · NC

This complaint is in reference to my vehicle which is involved with Federal Class Action Lawsuits and the fact that my engine was defective from the day it was built. My engine was consuming oil at a rate of 1 quart every 361.1 miles driven. I was advised to not put oil in it and drive it until it blows up. This would have put myself, my family, friends, or any other passengers or bystanders at risk. Kia is denying my claim solely on a non rod bearing failure.

Filed Aug 28, 2025 · Engine · 95,000 miles · VA

The contact owns a 2019 Kia Sportage. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated, and the vehicle went to LIMP Mode. The vehicle was towed to the dealer, who performed an oil change and updated the Knock Sensor Detection System(KSDS). The contact stated that later, while driving, the engine oil warning light illuminated. The contact checked the engine oil and discovered that the oil level was extremely low. The dealer was made aware of the failure and informed the contact that the pistons were faulty, and the engine needed to be replaced; however, the mileage had exceeded the warranty coverage. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 95,000.

Filed Feb 17, 2025 · Electrical, Engine · AR

The car continues to burn oil and have to put oil in it although not time for oil change. I took the vehicle to dealership several times because whenever I get gas it won’t let me start it right away or stutters after getting gas. Whenever the car is in park or idle it’s making a knocking noise and shaking really bad. The check engine light keeps going off and on but this most recent time it is not on. Initially i was advised they could only diagnose when check engine light on but that’s the issue because light does not stay on. I was on the freeway going about 70mph the car started declining in speed so had to hurry and pull over. Pulled over and turned off the car then it took several times to start back up. Vehicle currently at dealership waiting for more info but said it’s something related to the engine misfire.

Filed Dec 13, 2024 · Engine, Fuel system · ID

Vehicle was throwing codes P2196 O2 sensor stuck rich, P0290 post catalyst fuel trim lean, P01720 system too rich, P016B closed loop air/fuel ratio control at limit. Brought to local dealership where they did an inspection and could not find any major issue that, in their words, “would affect drivability”. Recommended I start using premium fuel and in the future consider a fuel system cleaning. 9 days later while driving my engine starting knocking, check engine light was on and flashing, then my car died. Towed vehicle to the dealership where the assessed and found there to be no compression and stated the pistons looked “melted”. They could not give me a reason as to why, or why none of this was caught at my $100 service inspection 9 days prior. They stated I needed an engine replacement at $6700 due to failed pistons. They would not do any type of diagnostic or testing to rule out a known issue with the Theta II engine recall. They stated they did not have to do any further diagnostic since they found my pistons to be melted. Local mechanic of mine not affiliated with the dealership, assessed the engine and components, stated he did not see any abnormalities outside of normal wear and tear but did recommend I have the dealership tear into the engine since they are “Kia Experts” and know the engines. Kia dealership stated they filed a claim with corporate and it was denied. Kia corporate stated my dealership sent report stating engine failure reason is outside of scope for recall. Kia dealership refused providing me denial in writing. Sent me photo of correspondence with tech line which was a total of 3 messages. Vehicle had been at dealership since November 16th.

Filed Apr 18, 2024 · Electrical, Engine · 75,490 miles · RI

The contact owns a 2019 Kia Sportage. The contact stated while driving 45 MPH, the electrical and mechanical systems became inoperable. The headlights, signal, and hazard lights became inoperable. The contact pulled over, placed the vehicle in park, and turned the vehicle off. After restarting the vehicle, an abnormal ticking sound was coming from the vehicle. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed that the radiator needed to be replaced and the tie rod had excessive play. The dealer denied repairing the vehicle due to sludge in the engine. The vehicle was not repaired. The manufacturer was notified, but no assistance was provided. The failure mileage was approximately 75,490.

Filed Feb 10, 2024 · Engine · CA

Fully maintained services with my 2019 Kia Sportage with my local Kia dealership. I am a sales rep and use my car daily. I have 155k miles on my car. My car was needing oil changes about every 2500 miles because it was burning so much oil. Yesterday, 2/08,I turned on my car during my work day and while ideling my car in park, my engine light came on. The car immediately started to shake uncontrollably. No other indication prior to the shaking of the car did I think something was wrong. Again I get services done frequently to my car. I took it to Kia immediately. They diagnosed that in cylinder 2 one of my intake valves was broken. This is not covered under the recall already put in place or with the extended warranty with the software update. According to my Kia Dealership, the current recall for an engine replacement is only for the under rod bearing. The dealership wants $7300 for a completely new engine. I have never had a car that has ever had an engine go. Nor have heard of one having the engine fail within the first 5 years. I have looked online and many people have complained about this exact same problem and Kia says they can’t do anything for us. I do not have current documentation because my car is still at Kia. I am trying to figure out what to do before I drive it off the lot.

Filed Dec 7, 2023 · Engine · WV

Complained since buying car noise in motor was told it was fine on dec 7th car broke down 200 miles from home was told it was the rod bearings that was under recall

Filed Sep 6, 2023 · Engine · 40,000 miles · IL

The contact owns a 2019 Kia Sportage. The contact stated that while driving at an undisclosed speed, she heard an unusual ticking sound coming from the engine. The vehicle was taken to the dealer where it was diagnosed with tow hitch wiring harness deficiency. The contact was informed that the tow hitch wiring harness needed to be replaced. The vehicle was not repaired. The contact had received an interim recall notification in November 2022. The contact received notification of the federal safety agency Campaign Number: 22V703000 (Trailer Hitches) in July 2023. The contact stated that the vehicle was stolen in April 2023 for a short while. The manufacturer was made aware of the failure but provided no assistance. The manufacturer offered to cover half the cost of the repair. The approximate failure mileage was 40,000.

Filed Oct 19, 2022 · Engine · 100,000 miles · NC

The contact owns a 2019 Kia Sportage. The contact stated that while her daughter was driving at various speeds, there was a ticking noise heard coming from the engine. The check engine warning light was illuminated. The vehicle was taken to a local dealer who confirmed the VIN was not included in a recall. The vehicle remained at the dealer awaiting diagnostic testing and repair. The manufacturer was made aware of the failure; however, no assistance was provided. The approximate failure mileage was 100,000.