The contact owns a 2012 Lincoln MKZ. The contact stated that while driving at an undisclosed speed, the steering wheel became difficult to steer in either direction. No warning light was illuminated. The message "Power Steering Assist Fault" was displayed. The contact stated that the failure had progressed over time. The vehicle was taken to a local dealer, where it remained for further investigation; however, the contact was informed that the VIN was not included in the federal safety agency Campaign: 15V340000 (Steering). The manufacturer was made aware of the failure. The failure mileage was approximately 135,000.
2012 Lincoln MKZ steering problems
20 complaints (14% of all complaints for this car). Typical mileage when it fails: 65,000. 5 crashes reported.
- owner complaints
- 20
- of this car's complaints
- 14%
- typical mileage
- 65,000
- crashes
- 5
- recalls
- 1
Which part fails
Owners did not name a specific part.
At what mileage
Complaints by mileage at the time of the problem.
0k-25k
25k-50k
50k-75k
75k-100k
100k-125k
125k-150k
150k-175k
175k-200k
200k+
Lincoln MKZ steering problems in other years
Specific symptoms reported on the 2012 Lincoln MKZ steering
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Related recalls
Steering: electric power assist system
- What is wrong
- Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford Fusion vehicles without a 3.5L engine and Lincoln MKZ hybrid electric vehicles, 2011 Mercury Milan vehicles, 2011-2012 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with a 3.5L GTDI engine and 2013 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with any available engine. The affected vehicles have electric power steering assist systems that may shut down as a result of a steering motor sensor fault.
- Risk
- If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, increasing the risk of a vehicle crash.
- Remedy
- Ford will notify owners, and dealers will check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTC). If dealers find any loss of steering assist DTCs, the steering gear will be replaced, free of charge. If, no codes are found during the PSCM inspection, the PSCM software will be updated, free of charge. The recall began on July 21, 2015. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 15S18.
Recall number 15V340000 · Recall details
Related investigations
Electric power steering failure
The Office of Defects Investigation (ODI) opened a preliminary evaluation to investigate complaints of the loss of power steering while driving. The subject vehicles are equipped with a rack mounted Electric Power Assisted Steering (EPAS) unit.Some of the complaints alleged that the steering assist failed and resulted in increased steering efforts that contributed to a loss of control and in some cases a crash.The EPAS system was manufactured by TRW Automotive for Ford and was designated as Generation I.These units were first produced and put into vehicle production in July 2008 beginning with the model year (MY) 2010 Ford Fusion and Mercury Milan.The system is comprised of a mechanical steering rack-and-pinion gear with torque sensor, electric assist motor, motor position sensor and a power steering control module (PSCM). The PSCM is self-monitoring and designed to detect faults within the system and can store diagnostic trouble codes (DTCs) if a problem is detected.There are 29 potential DTCs the system can detect.Many of these allow the system to go into reduced-assist steering mode by using the default vehicle speed signal should the live speed signal be lost, if voltage to EPAS system falls below 10.7 or goes above 17 volts, the temperature at the PSCM goes above 105C (221F), or if high friction is detected.Some DTCs will cause the system to go into manual steering mode (no assist). On July 1, 2015, Ford filed a Defect Information Report (DIR) identifying a safety related defect in TRW GEN I EPAS systems installed in some of the subject vehicles (the federal safety agency Recall 15V‑340, Ford No. 15S18).The DIR indicated that intermittent electrical connections caused by quality issues associated with conformal coat contamination and ribbon cable pin misalignment within the steering gear motor may lead to a loss of the motor position sensor signal, resulting in a sudden loss of power assist while driving.The recall covers approximately 393,623 vehicles built from September 2010 through February 2012:2011-12 Fusion built SEP 2010 - FEB 2012; 2011-12 Lincoln MKZ built SEP 2010 - FEB 2012; 2011 Milan built SEP 2010 - DEC 2010; 2011-13 Taurus built SEP 2010 - FEB 2012; 2011-13 Flex with 3.5L GTDI engine built SEP 2010 - FEB 2012; and 2011-13 MKS, MKT with 3.5L GTDI engine built SEP 2010 - FEB 2012.The repair consists of updating the PSCM software to prevent a loss of steering assist while driving. The revised software will provide audible and visual warnings to the driver. If one or more of the following DTCs are stored, C1B00-62, C200B-2F, C200B-61, C200B-62, C200C-2F, C200D-49, U0300-00, U2011-49, U2011-61, U3000-46, U3000-49, U3000-61, U3000-72, U3000-96, P07AE-09, the dealer will replace the EPAS system at no charge to the owner.ODI's analysis of failure data for this PE identified a total of 2,584 complaints to ODI and Ford and 9,967 Ford warranty claims related to the alleged defect.The recalled vehicles account for 1,634 of the complaints and 7,311 of the warranty claims.ODI's analysis identified 40 complaints alleging crashes that may be related to loss of steering assist while driving, 20 of which involved vehicles included in Ford's recall.The information available for the alleged crashes were not sufficient to assess specific causes of the incidents or to verify EPAS malfunctions in each case.Most of the crashes were low-speed impacts with curbs or roadside objects resulting in wheel or minor body damage.None of the injury claims indicated medical attention was required.In addition, statistical modeling of the failure data by the federal safety agency's National Center for Statistics and Analysis projected 10-year failur
PE14030
What 2012 Lincoln MKZ owners say
Most recent owner complaints, unedited.
My car has lost powering steering three times now. I have replaced the rack and pinion module twice and I’m fixing to a third time. This has happened all within the last 3.5 years
I became the owner of a 2012 Lincoln MKZ Hybrid in 2016. At first there was no issues. Roughly a couple of months later, there was a power steering issue- so the car was driven to Ford with great difficulty where they reset the sensor or something and the power steering was working again. Now a couple of years later, the problem occurred again. The power steering chime came on, the car read “service advancetrac” in yellow and “power steering assist fault” in read, accompanied by the wheel stiffening. I pulled over turned the car off and back on, and the problem went away. It occurred several more times and turning the car off and back on remedied the problem. It would only occur every couple of months, but more recently it started happening every couple of weeks and now- the last ten days it has happened every time I drive. Each of those times, with the exception of the most recent occurrence, turning the car off and letting it sit for a couple of minutes, followed by turning it back on, solved the problem. The most recent time, I was traveling on the highway going 60 mph when the messages appeared and my wheel stiffened. It terrified me as I was moving fast on a Southern California highway where there are hundreds of cars. I was on my way to take a final exam, that I could not miss, so I kept driving. Steering was near impossible at low speeds. I went in to take my final and three hours later, when I turned the car back on, the power steering still was not working. After hours of research and years of dealing with this problem, I have found that there was a recall regarding the PSCM in the 2012 Lincoln MKZ. I am unsure if this problem extends to the hybrid model, and if so whether it was remedied by a past owner, but a detailed vehicle history report indicates that it was not. I have never received any notice as to this recall. I do know that my car was manufactured in the applicable time period (2011), and that it is experiencing exactly what the recall describes.
Power steering control module stop working. Ford is aware of this issue and refusing to classify it as a recall. Vehicle inoperable at 83k miles.
While driving I noticed that at times my steering wheel would be difficult to turn. At first, the problem seemed small until I was trying to make a left turn on a very busy 4-lane road, and without warning the steering wheel became very difficult to turn. I narrowly avoided being hit and ever since then, the steering has not been the same. I sought help at my nearest Ford dealership and after they inspected the car they determined that there was a problem with the steering assist and possibly the rack and pinion. We then discovered that the very same parts were recalled in 2011 for the same make and model car. I was never notified of any recalls and I asked why I was never contacted. The Ford dealership did not know why. According to them the vehicles that were recalled were vehicles that were made at the same facility as mine. They pointed out that normally my car would have been included in the recall and they did not know why I was excluded. I have attached the documentation they provided me proving that my car was built in a factory that had other cars recalled for the same reason. Currently, they are telling me that they cannot honor this recall because my car is not in the system as one that should be included in this recall. Due to the near misses that I have had I believe that this is a serious safety issue and should not be something that I pay over 2000 dollars to repair. Especially since all the other vehicles that had the same problem were recalled and repaired for free. Please help me figure out how to hold them accountable for not notifying me and refusing to honor the safety recall. the federal safety agency Campaign Number 15V340000
After getting an oil change and battery software update, I headed home. Before arriving home the warning light to service Power steering and traction control came on. Returned to dealer, they said the power steering needed to be calibrated. Left and before making it home power steering stopped working and warning lights returned. Dealer has stated the power steering gear needs to be replaced but because the milage is 224,000 and the car is over 10 years old Ford will not extend the warranty and it will cost $2,500 to repair.
The contact owns a 2012 Lincoln MKZ. The contact stated that upon starting the vehicle, the power steering assist fault message intermittently appeared on the instrument panel. The contact restarted the vehicle and the vehicle resume normal operation. Recently, the contact stated that the traction control and the power steering warning lights would illuminate at start-up and remained illuminated despite the engine restart. The contact also mentioned that excessive force was needed to steer the vehicle while driving at various speeds. The contact had taken the vehicle to the dealer and he was informed that the vehicle was out of warranty and the VIN was not included in the federal safety agency Campaign Number: 15V340000 (Steering). The manufacturer was also notified of the failure and referred the contact to the federal safety agency for assistance. The vehicle was not repaired. The failure mileage was approximately 65,000.
Tl* the contact owns a 2012 lincoln mkz. The contact stated while driving 60 MPH, an audible chime was heard after which, the power steering assist message displayed on the instrument panel. The contact stated that the vehicle became difficult to steer. The vehicle was taken to the local dealer felix sabates lincoln (7601 south blvd, charlotte, nc 28273, (855) 975-3985) where it was diagnosed with needing the rack and pinon to be replaced. The vehicle was not repaired. The failure recurred. The manufacturer was informed of the failure and informed the contact that vehicle was out of warranty. The failure mileage was approximately 200,000.
There is a major issue with the power steering
The electronic steering stopped working and the traction control system light came on at the same time. I was traveling at less than 5 miles per hour and ran into my garage damaging the right front of my car. Local dealer without seeing the car said cost would be around $1800 to fix steering and stabilitrak. This was a 2012 lincoln mkz hybrid.
Questions about the 2012 Lincoln MKZ steering
Does the 2012 Lincoln MKZ have steering problems?
Owners have filed 20 complaints about the steering of the 2012 Lincoln MKZ, 14% of all its complaints.
At what mileage do 2012 Lincoln MKZ steering problems start?
The typical (median) mileage in owner complaints is 65,000 miles.
Was there a recall on the 2012 Lincoln MKZ steering?
Yes, 1 recall: 15V340000. Check your VIN to see if your car still needs the free repair.
What year does the Lincoln MKZ have bad steering?
The Lincoln MKZ model years with the most steering complaints are 2014 (26 complaints), 2012 (20 complaints) and 2011 (19 complaints).
Other 2012 Lincoln MKZ problems
Airbags 68Brakes 20Body 10Electrical 9Engine 5Driver assistance 4Transmission 4Acceleration 3Lights 3Seat belts 2Wheels 2Locks 1Seats 1Visibility 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2012 Lincoln MKZ?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history