2005 Lincoln Navigator technical service bulletins
84 technical service bulletins and manufacturer communications cover the 2005 Lincoln Navigator.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This article supersedes TSB 22-2219 to update the Parts List and Service Procedure to clarify applicable...
- When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all...
- For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to
- Grinding/clicking/ratcheting noise from the front wheel area
- Grinding/clicking/ratcheting noise from the front wheel area
- This article supersedes TSB 19-2026 to update the vehicle model years affected
- Corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust
- Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may...
- When ordering a 2005 to 2008 remanufactured 5.4L 3v or 6.8L 3v engine, spark plug boots may be provided in...
- The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic...
- Lincoln/ford: when driving from idle up to 1200 RPM, there may be an intermittent rattle noise coming from...
- Ford/lincoln/mercury: may have sludge buildup in throttle body leading to less airflow or engine idling...
- Ford: some vehicles may exhibit oil separation from the internal lube found in the unitized cartridge seal
- Ford lincoln service campaign: customer satisfaction program 07M08: certain 2005 model year F-150, f-super...
- Parking aid system is inoperative - DTC C1983
- Failed TCM programming nj
- High intensity discharge (HID) headlamps
- Spark plug removal instructions - 5.4 3V
- Air suspension performance - height sensor linkage arm disengaging
- Diagnostic trouble codes (DTC) P0340, P0344, P0345, P0349
- Parking aid system inoperative - DTC C1983
- High intensity discharge (HID) headlamps left headlamp intermittent operation flicker
- Brake shudder (rotor thickness variation) due to the new low dust front brake lining used in production,...
- Limited slip axle chatter, shudder, binding sensation, or vibration during low speed turning maneuvers
- Various electrical concerns - 3 block auxiliary relay box 1 chafing - service tip
- Floor mounted shifter stuck in park
- Diagnostic trouble codes P0340/P0344/P0345/P0349 - 4.6L 3V and 5.4L 3V
- 5.4L 3V with P030X and/or P0316 accompanied by spark knock
- Low tire indicator on - TPMS system sensor wake up
- Brake shudder
- High intensity discharge (HID) - service fix
- Wds cop kit diagnostic tip - coil on plug (COP) ignition systems - engine misfire or rough running
- Drivers front power seat will not move forward or rearward
- Rear window wiper inoperative
- A tiny crack, or cracks, around the transfer case drain plug hole
- A clunk/thump noise from the rear when the transmission is engaged or shifted, during a change in vehicle...
- Axle seal leaks
- Malfunction indicator lamp on with misfire dtc's spark knock piston scuffing
- Safety belt retraction speed
- Climate control seat heat function inoperative - vehicles built prior to 3/24/2005
- Clunk/grind/thump noise - frame repair procedure
- Clunk/grind/thump noise from rear of vehicle when transmission is shifted - vehicles built before 6/13/2005
- Service wiring harness replacement guidelines - service tips
- Axle seal leaks
- Intermittent concerns of MIL on with various dtcs hard start long crank runs rough and or no crank
- Steering wheel at 65 mph (105 km/h) or higher
- Rear axle noise repair
- Diagnostic trouble code (DTC) C1983 - inoperative parking aid system - vehicles built on 12/10/2004
- Inability to disable the supplemental safety belt warning chime (beltminder)
- Noise from a/c (air conditioning) or insufficient a/c cooling
- Lack of power on acceleration - may also be described as transmission slipping, lack of upshift or a...
- Tire pressure monitor system
- Axle whine howl
- Crank no start long crank or erratic crank
- Climate controlled seat heating inoperative
- Transmission slips, shifts slow or leaks - service tip
- Axle whine howl service with individual parts instead of an axle assembly
- Tiny crack or cracks around the transfer case drain plug
- Check transmission control module connector this may not be fully seated
- CAN not disable beltminder using the procedure listed in service manual or owner guide
- Climate controlled seat heating inoperative
- Delayed cranking when key is turned to start
- Rear axle noise repair
- Hard start/long crank, rough idle, engine idle misfire-mil-dtcs P0300 through P0308, P0171, P0172, P0174,...
- Diagnostic trouble code (DTC) P0340 and or P0344-5.4 3V engine
- Vibration diagnosis - tire/wheel runout
- Parking aid system inoperative
- Unintended brake assist
- Weld bonding procedure
- Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair
- General (PCM) power train control module programming procedures
- Reduction in power 4000-4500 RPM during wot when engine is cold
- General power train control module (PCM) programming procedures
- 6HP26 6-SPEED automatic transmission - service tips
- Grinding noise from front axle wheel hubs on acceleration in 2WD - service tip
- Multiple vehicles - fuel level indication concerns - service tip
- Tire feathering at low mileage
- Harsh engagement into drive/reverse, clunk shifting from drive to park, and/or high effort to shift out of...
- Transmission related concerns - service tip
- Reverse sensing system defaulting off, setting diagnostic trouble codes, or losing communication with...
- Engine misfire or running - coil on plug (COP) ignition systems - wds cop kit diagnostic tips
- Liftgate reversing direction when closing in hot ambient temperatures above 90 f (32 c)
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Lincoln Navigator?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history