Tl* the contact owned a 1991 mazda protege. While driving various speeds, smoke appeared under the hood. There were no flames visible and no injuries. The vehicle was destroyed. The contact received notification of the federal safety agency campaign number: 15v674000 (electrical system). The failure mileage was unknown.
The worst 1991 Mazda Protege problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Seat belts27
- Body7
- Electrical4
- Transmission4
- Brakes3
- Acceleration2
- Engine2
- Suspension2
- Airbags1
- Lights1
- Locks1
- Seats1
- Tires1
- Wheels1
Specific symptoms reported on the 1991 Mazda Protege
Recalls 1
Electrical system: ignition: switch
- What is wrong
- Mazda North American Operations (Mazda) is recalling certain model year 1989-1998 MPV, 1990-1995 323, 1990-1998 Protege, 1992-1993 MX-3, 1993-1995 929, 1993-1997 MX-6, and 1993-1998 626 vehicles. In the affected vehicles, grease applied to the contact points inside the ignition switch may become conductive and overheat.
- Risk
- If the ignition switch overheats there would be an increased risk of a fire.
- Remedy
- Mazda will notify owners, and dealers will replace the ignition switch, free of charge. The recall began on December 17, 2015. Owners may contact Mazda Customer Experience Center at 1‑800‑222‑5500, option#6. Mazda's number for this recall is 8715J.
Recall number 15V674000 · Recall details
See all 1 recalls for the 1991 Mazda Protege
Defect investigations
Auto restraint system fail
There is no summary currently available
EA94039
Auto restraint system fail
There is no summary currently available
PE94059
Technical service bulletins for the 1991 Mazda Protege 20
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer
- In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer
- Speedometer replacement procedure
- In accordance with federal regulations, follow the procedure listed below when replacing a...
- Battery test procedure requirements
- Speedometer replacement procedure
- Experiencing popping noise from front brake caliper during slow speed braking
- Subject on passive seat belt retractor switch
- Conditions with steering wheel slightly off center
- Subject pertaining to mtx overhaul information
What 1991 Mazda Protege owners say
Most recent owner complaints, unedited.
Tl* the contact owns a 1991 mazda protege. The contact stated that while driving at approximately 45 MPH during rain weather conditions, the vehicle went over a pothole causing the contact to lose control of the vehicle and stopping on the shoulder of the road. The contact then attempted to drive and the vehicle spun crashing the front of the vehicle into a tree. The seat belt detached and the contact was released from the rear window. The air bags did not deploy. The vehicle was towed and deemed destroyed. The contact received knee, head, and back injuries which required medical attention. A police report was filed. The manufacturer was not notified of the failure. The approximate failure mileage was 90,000. Updated 03/15/16*lj
Rear strut towers rust right through.
The automatic shoulder belt would retract slower and slower until it finally stopped retracting. The consequences were: on april 18, 2005 I was given a fix-it ticket for not wearing my shoulder harness.*ak the automatic harness no longer fully retracts, so it is useless.
The seat belt cord on my 1991 mazda protege has become inoperable and therefore I have no top seat belt on my cars driver side.
While driving, the vehicle's hood detached resulting in the hood hitting the windshield.*mr *cb
Driver side seat belt will not return to the retactor, leaving the occupant unrestrained. Dealer notifed. Feel free to provide any further information.
Transmition locked up going 65 MPH.
Trunk lid was in the up position and trunk came down and hit consumer's daughter on head. *ak consumer states nothing to keep the trunk lid in upright position. A slight wind or elevation could blow the open lid down and may cause serious injury.
Seat belt seat belt warning light and beep go on and off intermittently while driving due to an electrical connector wearing through in the drivers shoulder belt retractor located in the center console. Replaced several times under warranty. Part is nearly $300. Several people I know with this model and year have the same problem.
Compare the 1991 Mazda Protege
Other model years
Questions about the 1991 Mazda Protege
Is the 1991 Mazda Protege reliable?
Owners have filed 51 complaints about the 1991 Mazda Protege, fewer than a typical Protege model year.
What is the most common problem with the 1991 Mazda Protege?
Seat belts, with 27 complaints. Next is body (7).
How many recalls does the 1991 Mazda Protege have?
1 recall, covering electrical system.
What year does the Mazda Protege have the most seat belts problems?
The Mazda Protege model years with the most seat belts complaints are 1994 (37 complaints), 1992 (34 complaints) and 1991 (27 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used 1991 Mazda Protege?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history