2005 Mercedes Benz E320: gas smell in the cabin

Filed Aug 18, 2021 · Fuel system · HI

The passenger compartment smells like gasoline. This is due to an issue that was already investigated by the federal safety agency however the warranty that was extended is expired by two years. I just purchased this vehicle used and it is unsafe to drive. It did not smell like gas a few weeks ago when it was purchased. The odor is very strong in the passenger compartment.

Filed Jan 29, 2021 · Fuel system · TX

Filled up gas tank and had fuel odor inside car and fuel leaking outside the car until fuel level was around 3/4 of a tank. I believe that mine falls under all the other problems listed for fuel leaks for other w211 mercedes. The extended warranty for this was only allowed for original owners and not for anyone that purchased used.

Filed May 31, 2018 · Fuel system · TX

Their a strong smell of gas smell inside the car

Filed Nov 12, 2017 · Fuel system · 44,497 miles · NV

In 2015 we started to notice the smell of gasoline following filling the tank with gas. The smell of gasoline is so strong that we had to open our garage doors to vent the fumes. No gasoline was spilled during refueling. There is no visible gas leak on the garage floor. The vehicle is a 2005 mercedes-benz e320 with only 44,000 miles. After researching this problem we discovered numerous other owners of this model mercedes have experienced the same problem. Mercedes has no recall for this fuel fume defect and any repair is not within the original warranty period. The federal safety agency action #ea13003 summary test & analysis by mercedes-benz shows no risks of fire or passenger safety. This is bs as fuel fumes within an enclosed area, such as a garage where a natural gas hot water tank exists, could cause a fire. The federal safety agency needs to require mercedes-benz to recall the vehicles affected by this defect.

Filed Jul 2, 2017 · Fuel system · 135,378 miles · CA

8/4/16 vehicle had strong smell of gas inside after fillup. Went away after half full. Noticed recall in online doc's and took to mercedes of san diego where tank mod, cable harness, bracket, seal ringx2, insulation under seat were replaced no charge under warranty. 6/20/17 vehicle quit when approaching residence. Then wouldn't start but cranked. Same symptoms next day. Towed to mb san diego diagnosed fuel pump components failed $1,000 w/no offer to cover under recall. I further reviewed same internet doc's which show fuel pumps, filters, fuel level senders are covered under mb 15 yr. Unltd miles warranty. Will call service writer in morning to advise they should cover repairs, tow plus rental car while I was researchng.

Filed Jun 22, 2017 · Airbags, Fuel system · TX

Purchase this car in february 2017 smells like gas is seeping out from somewhere. Stopped in the middle of highway. Now having problems with starting car and airbag suspension light is on.

Filed Feb 12, 2016 · Fuel system, Seats · 110,000 miles · NY

Car has a very strong gas smell inside the cabin. Upon removal of back seat it appears wet with gas. This problem started on february 5, 2016 on my e320 (2005) benz and the odor started to give me headaches. I took car for shampoo and then consulted with mechanic who removed back seat and found wet area with gas.

Filed Jan 15, 2016 · Fuel system · 79,940 miles · NV

I have a 2005 e320 mercedes benz. Every time we fill the tank we get a strong gas smell inside the vehicle. After we drive the vehicle for a while with the windows open the smell dissipates. The smell is coming from under the rear seats. I suspect the seal on the gas tank has failed. This is a design flaw that should be taken care of by the manufacture. It is not a normal wear and tear item. My concern is fuel fumes can impair ones driving ability and leaking fuel can create a safety hazard. With the number of complaints that I have come across I feel that there should be a re-call to correct.

Filed Nov 9, 2015 · Fuel system · 138,000 miles · NJ

Sensed strong gas odor at fill up. Investigate online and found that this car has this known issue but it is not a recall.? Had mb mechanic look and found leaking gas under rear seat near fuel pump.

Filed Oct 28, 2015 · Fuel system · 82,000 miles · NH

Tl* the contact owns a 2005 mercedes benz e320. The contact stated that after the vehicle was refueled and parked, a fuel odor emitted from the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 82,000.

Filed Oct 5, 2015 · Driver assistance, Fuel system · 157,000 miles · GA

Replaced battery (30 days ago) and now warning light comes on saying I need to replace the battery every 10 miles and will not go off. Brake lights (ABS and esp) lights comne on and nothing is wrong when it is being repairs. Filled up my car yesterday and strong gas fumes in the car and in my garage. Made me nauseated. Read this was recall for that year and model.

Filed Oct 4, 2015 · Fuel system · 140,000 miles · GA

Re complaint number 10778442 since the last report the situation has gotten much worse. Initially the gasoline fumes would occur while the tank was more than 1/2 full. Now the fumes are very very strong when the tank is full but remain strong even as the fuel indicator nears the empty mark. This this the only vehicle I own and my family and myself cannot remain in the car for more than a few moments. The fume are overpowering and this is a major health concern wise as well as a chance of fire.