2012 Mercedes-Benz E350 fuel system problems

Filed Jun 22, 2026 · Fuel system · 70,000 miles · DE

The contact owns a 2012 Mercedes-Benz E350. The contact stated that while driving at an undisclosed speed, there was an abnormal odor coming from the inside of the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with a fuel leak. The vehicle was not repaired. The contact researched and was made aware of the federal safety agency Campaign Number: 12V557000 (Fuel System, Gasoline); however, the VIN was not included in the recall. A dealer was contacted; however, the vehicle was not yet diagnosed by the dealer. The manufacturer was notified of the failure. The failure mileage was approximately 70,000.

Filed May 15, 2026 · Electrical, Fuel system · 35,000 miles · AZ

The contact owns a 2012 Mercedes- Benz E350. The contact stated while operating the vehicle the odor of fuel was present coming from the vehicle. Upon inspection it was discovered that the fuel had leaked from the vehicle. The vehicle was taken to the local dealer who diagnosed that the fuel pump had failed and needed to be replaced. The vehicle was not yet repaired. Also, the contact indicated that the front driver seat heat element had overheated and cause melting to the seat cushion. The vehicle was taken to the local dealer who diagnosed that the front driver seat needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failures but no assistance was offered. The failure mileage was 35,000.

Filed May 4, 2026 · Fuel system, Suspension · NC

The failed component is a fuel pump, and it is available for inspection upon request. My safety and the safety of others was put at risk due to the following: 1) Sudden engine stalling 2) Dangerous power loss while accelerating 3) Potential fire risks; a damaged fuel pump assembley can cause fuel leaks and overheating due to insufficient fuel supply can increase the risk of explosion or fire. 4) Gas fumes from a fuel leak are highly harmful and dangerous. They are toxic to inhale causing dizziness, headaches, nausea or respitory issues.

Filed Apr 8, 2025 · Fuel system · 124,900 miles · CA

The contact owns a 2012 Mercedes-Benz E350. The contact stated while driving 5 MPH, the contact smelled fuel on the interior of the vehicle. No warning lights were illuminated. The contact stated that the dealer was contacted. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the fuel filter sending unit needed to be replaced. The vehicle was being repaired. The contact related the failure to the federal safety agency Campaign Number: 12V557000 (FUEL SYSTEM, GASOLINE). The manufacturer was notified of the failure and informed the contact that the VIN was not included in the recall. The failure mileage was 124,900.

Filed Mar 16, 2025 · Fuel system · VA

I have a 2012 E350 with less than 95000 miles and I see these vehicles were recalled in the past for their fuel tank manufacturer malfunction but my VIN number was not included. This car went numerous times to the mechanics and the fuel components fixed but it still leak gas and smells even when I do not drive the car. I spent over $15000 on this matter. This is now becoming a safety issue for me and my neighbors. I don't know what to do. Here is what happened. All began February 2023, I towed the car to an approved MB mechanics who said fixed the car. 9 month later, I brought the car back for the same issue. Strong fuel smell. The attachments for repairs will show the work done. Some repeated and recharged to me. The following year April 2024, I woke up one day with a fas leak all over my drive way and a strong smell of gas. I had the car towed for a repair cost of $7754 total. I am constantly having the same problem with the car and wanted to alert here to bring Mercedes Benz awareness to their faulty parts putting consumer lives at risk.

Filed Mar 12, 2025 · Engine, Fuel system · HI

Recall exists related to a potential issue with the high-pressure fuel pump, which could lead to engine stalling and increase crash risk. My 2012 Mercedes E350 stops the engine in the middle of the road couple of times and for some reason, its stops or shut off the engine completely. The last time I was pulling out on the main road and stop right there. I made a big traffic, and I was scared because I cannot start the car. The guy stops and help me to push out of the road, but we cannot push the vehicle unless someone is inside the car. If I go out, it will automatically go on "park" and cannot push the car. When you check the dashboard the check engine light is not on. 2nd incident I bring this car to Mercedes Benz Dealership, and I told them that there is something wrong in my car, I explain what was wrong but, the guy I talk to, told me that if the check engine light is not coming on, my car is fine. I repeated that the car stops ones in a while when the temperature light is on inside the dashboard and the engine shuts off. He told me if the check engine light turns on then I bring it back. I show the code reading but the same thing he said. I left and went back home and suddenly I get stranded again; I got stock in the middle of the road for 3 to 4 minutes. I start the car and suddenly the car starts and find the nearest place to pull over. I let it call down for couple of hours and start again, the car starts and try to go back home. When I was in the interstate hwy. My car engine shut off, so I quickly pull over, but I was having a hard time to turn the wheel. I believe that this is very unsafe and should have Mercedes Dealer has to repair this issue. I research on the website that 2012 Mercedes Benz E350 have recall to a potential issue with the high- pressure pump and other things like Battery fuse relay box positive terminal and low fuel circuit.

Filed Feb 10, 2025 · Engine, Fuel system · CA

[XXX].The engine intake manifold on our 2012 Mercedes E350 (64,000 miles) EXPLODED with enough force to bend the hood up 2 inches. It was a damp cold morning & the engine had not been started in 12 hours. The car was not locked & the key fob was nowhere close. The fuel level was under 3/4 full. This happened when wife went to get something out of the car and when she pulled the passenger door handle to open - B O O M !!!! If this happened 30 minutes later, I would have been under that hood checking the fluid levels for a trip to San Francisco. I WOULD HAVE BEEN SERIOUSLY HURT OR KILLED!. It was towed to Mercedes-Benz of Carlsbad, Carlsbad California on [XXX] & they have not been able to identify the cause. They could replace the broken parts at the cost of $8,000 but that doesn’t fix the problem. And if it happens again & hurts or kills someone, they could be held liable. Similar intake explosions have occurred on these Mercedes engines but Mercedes is denying any knowledge even though it’s clearly a dangerous design flaw in this intake system. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Feb 7, 2025 · Driver assistance, Fuel system · AR

I am writing in regards to the 5 vehicle recalls that were for the make, and model of my car that is showing as having no recalls for. The recalls involved air bags, air bag software, fuel filter flange, and I am also wondering with the driver headrest deployment module if that is associated with an airbag module; as when I had purchased the vehicle I had found out that both my airbag modules had malfunctioned with showing the srs lights on the dash. I was told that Mercedes of Sarasota, FL had replaced the passenger airbag module by Mercedes of South Orlando. When asked for a printout verification of this repair showing to be completed; they said they couldn’t provide me with this information. As proof of the service to being completed could not be provided. I had tken my car to their to have them look into this, and the tpms sensors showing malfunctioned; communication error message, and they couldn’t figure out what the problem was causing this. I had to take my car to an auto electrician to find out the problem; that I had found out that a 100 amp fusible link had blown, causing all those problems with also the roof wasn’t working. Along with I was smelling fuel. I found out about the recall for these items after getting them repaired out of pocket by the auto electrician Mike from Peak Audio, and Electric, and as to the fuel filter flange I had to pay like $1,200 to replace as they had replaced the fuel level sending unit that include the fuel filter flange. I would like refun; still have the headrest driver side that needs to be replaced. I found out that their is an recall for this make, and model of car that had said the air bag deployment software was under recall for those vehicles; which I believe could have triggered the deployment of the head rest while I was driving; as if I had been near a car; I could have been involved in an accident. I think that this should have an open ticket for repair placed on all 2012 Mercedes E350 Cabriolet Blue Efficiency.

Filed Dec 27, 2024 · Fuel system · TX

Recently, I have noticed a strong gas smell emanating from the rear driver’s side of the vehicle. Upon further research, I discovered that there was an open recall affecting Mercedes E-Class vehicles of the same year for a similar issue. However,my vehicle’s VIN is not included in this recall. Given that my vehicle is experiencing the same problem described in the recall, I am concerned about the safety implications and believe this matter warrants immediate attention. I would like clarification on why my vehicle is excluded from the recall despite exhibiting the same issue. Additionally, I would like to know if I am expected to pay out of pocket for repairs related to what appears to be a manufacturing defect acknowledged by Mercedes-Benz for other vehicles of the same year and model. I kindly request that this matter be escalated for review, and I look forward to your prompt response. My goal is to ensure the safety of my vehicle without incurring unfair expenses for a known issue.

Filed Aug 2, 2024 · Fuel system · 143,459 miles · VA

The contact owns a 2012 Mercedes-Benz E350. The contact stated that the filter flange was cracked. There was an abnormal fuel odor detected. The vehicle was leaking fuel near the fuel tank onto the ground. After refueling and driving five miles, the fuel was depleted to half a tank. There were no warning lights illuminated. The contact stated that the failure was related to the federal safety agency Campaign Number: 12V557000 (Fuel System, Gasoline). The contact called the local dealer and was informed that there were no open recalls on the VIN. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 143,459.